1999 Ford Contour engine problems

Filed Jan 14, 2008 · Engine · 100,000 miles · CA

Tl*the contact owns a 1999 ford contour. The contact received a letter from the manufacturer stating that the dashboard needed to be replaced. After the replacement was made, the dashboard developed a gap next to the passenger side vent, which over time, caused the vent to sink behind the dashboard. The contact took the vehicle to the dealer (ken gordon ford) and had it repaired. While driving approximately 55 MPH under normal conditions, the vehicle overheated. The vehicle was taken to the dealer and the thermostat was repaired. A few days later the vehicle overheated again. The contact discovered that the timing belt and water pump needed to be replaced. The current and failure mileages were 100,000.

Filed Jan 14, 2008 · Electrical, Engine · 99,279 miles · OH

I have a 1999 ford contour I bought it and 6 months later the timing belt went out this cost me $800.00 out of pocket after the warranty paid their part. Drove it another 3 months when it stalled out and started sputtering I replaced the plugs, wires, ignition control box, and fuel filter and found a hose that had a hole in it from being melted after replacing all of that found the transmission to be leaking and no way to get to it easily. Still ran crappy took it to a garage and was told they could not figure it out brought it home and it won't run anymore it still does not run not sure what else to do had to buy another vehicle to get to and from work while still paying on this one and can not use it anymore. This is my second ford and I will not ever get another one. And with all this going on when the mechanic shut the back passenger the glass shattered and it was shut normally. Also the radio has issues.

Filed Aug 14, 2007 · Body, Electrical · 60,000 miles · MN

1999 ford contour se sport dashboard peeling. My dashboard started to peel away at approx 60,000 miles. I now have 80,000 miles on my car. I did not receive notice of a recall on this matter, which was apparently a secret. I have owned 3 fords and will never buy another due to the lax customer service and failure to take responsibility for product failure. I have also had all the head gaskets replaced (I am 60 and hardly hot rodding), rear struts and something related to a loud humming sound under the hood that was essential for the car to remain in working order and problems with the key sticking in the ignition and also a fuel pump.

Filed Apr 19, 2007 · Engine · 40,000 miles · WI

Check engine light comes on three times for different oxygen sensors. These greatly effect the gas mileage and timing of engine resulting in more expensive repairs. The mechanic stated he has seen a lot of ford contours in with this specific problem. Cost is minimum $250-$450 to replace.

Filed Nov 6, 2006 · Electrical, Engine · 95,000 miles · MD · fire

Dt*: the contact stated the vehicle caught on fire while in gear. A pop noise was heard and smoke came out from under the hood. The front of the vehicle then caught fire. The insurance company deemed the vehicle a total loss and it was never taken to a service dealer. A fire department report was processed.*ak updated 12/11/06.

Filed Jul 13, 2006 · Engine · 98,616 miles · FL

Dt*: the contact stated, while driving 45 MPH blue smoke issued from under the hood and from the exhaust pipe. There was also a rattling sound emitting from under the hood. The motor then bogged down and would not accelerate above 20 MPH. The vehicle was towed to the service dealer where upon inspection, the service dealer's mechanic determined there was no problem found. On 7/13/06, the vehicle experienced the same events and stalled on the side of the road and was unable to be restarted.

Filed Apr 10, 2006 · Engine · 73,000 miles · GA

The check engine light in the consumer's vehicle continued to illuminate. The mechanic determined that the catalytic converter needed to be changed. *ts to date the catalytic converter has been changed 3 times.

Filed Nov 10, 2005 · Body, Brakes · IL

The federal safety agency website confirms 79 similar complaints of ford's known manufacture defects in dashboard assembly is a safety hazard that compromises the occupant/pedestrian saftey: warped dash panel and sprung out front defrost grill obstructs driver's view; loose grill strikes windshield while car in motion and could break it; deflects proper airbag deployment; proper airflow of defrost is deflected; ford knowingly manufactures and sells defective vehicles. Then immediately issues a "customer satisfaction program" notice (in this case cps # 01b78) that has an expiration date designed to preempt manifestation of the defects by the customer. On my 1999 ford contour se, the defroster grill has sprung out and juts out of alignment so that the airflow from defrost mechanism is obstructed. Dashboard warped and separated from windshield on the driver's side with the fissure spreading toward the passenger side. Ford customer service declined to do repairs/replacement at no charge, stating ford is no longer liable because the customer service program expired august 2002. Instead, the ford dealer service department offered me the loyal customer service deal of making the repair for cost of only $1638.12. I purchased the vehicle new in february 1999 for $18077.16 (financed price of $24318.40)!!! My car loan has been paid in full february 2004 with no late payments. My vehicle's routine maintenance was done by the ford dealer's service department. I am a second time ford owner; my previous vehicle was a 1992 ford tempo. However, lord willing, the 1999 contour will be my last. These are just some of the additional expenses I incurred seldom used A/C repair $275 faulty engine light 02 sensors replace $500 dealer cut brake roters too low $800.

Filed Sep 29, 2005 · Engine · 40,000 miles · 00

Dt: the consumer owns a 1999 ford contour that had cracks in the flywheel along the rear area of the motor. There was a ticking noise in the engine. The consumer took the vehicle to an independent transmission shop, who confirmed there was a crack in the flywheel. There was no explanation as to why this failure occurred. Apparently, it was cracking it is near the bolts that hold the flywheel onto the motor. This happened from hole to hole as if it was at a fatigued point. Was replaced at 40,000 kilometers, and the second flywheel now needs to be replaced at 126,000 kilometers. There were no other apparent problems with the vehicle other then the same issue occurring on both the original flywheels and the replacement.

Filed Sep 12, 2005 · Electrical, Engine · 65,000 miles · CA

Dt: the consumer could hear the radiator coming on/over and over again. Previously it overheated in june 2004. When the consumer took vehicle to dealer for repairs they changed the thermostat, added more water to the radiator, and something else in the transmission area. When the consumer picked up the vehicle the problem recurred. Afterwards, there was a rattling noise coming from the dashboard. They told her that it was due to a bracket that broke.. Dealer replaced the radio. The consumer stated that the air conditioner was no longer working properly since they replaced the radio. Also, the dashboard was loosening and there were wires showing. The front driver's side window knob came off. These were the only known problems with the vehicle at this time. There had been no accidents concerning these issues.