2000 Ford Contour fuel system problems

Filed Mar 18, 2013 · Fuel system · 120,000 miles · NH

Tl* the contact owns a 2000 ford contour. The contact stated that when the fuel tank was half full, the engine would hesitate, lose power, surge and stall. The vehicle was taken to the dealer where the fuel pump and fuel filter were replaced but the failure recurred. The manufacturer was not contacted. The VIN was unknown. The failure mileage was 120,000 and the current mileage was 170,000.

Filed Sep 15, 2011 · Fuel system · 173,000 miles · WI

Tl* the contact owns a 2000 ford contour. The contact stated that after refueling, a strong odor of fuel was emitted from the vehicle. The contact examined the vehicle and noticed that the fuel tank was leaking. The vehicle was taken to an independent mechanic and the contact was informed that the filler pipe grommet was leaking. The manufacturer was made aware of the failure and informed the contact that the vehicle was not included in the recall associated with the federal safety agency campaign id number 00v350000 (fuel system, other:storage:tank assembly). The vehicle was not repaired. The failure and current mileages were 173,000.

Filed Nov 22, 2010 · Fuel system · 67,400 miles · SC

Tl*the contact owns a 2000 ford contour. The contact stated that when putting fuel in the vehicle, the fuel would spill onto the ground. The dealer stated that the fuel filter grommet failed. The contact called the manufacturer who stated that the vehicle was not included in recall 00v350000 (fuel system, other: storage: tank assembly). The current and failure mileages were 67,400.

Filed Sep 28, 2008 · Fuel system · 86,125 miles · LA

Car acceleration was sluggish when brake was applied,a week later engine would kill when driving. Changed air filter,oil,and fuel line was cleared. A month later same thing is happening. Mechanic says may need new fuel pump,but not sure that will correct problem.

Filed Nov 11, 2007 · Engine, Fuel system · 121,359 miles · PA

My 2000 ford contour se starting acting like there was no gas at around 1/4 tank. This continued every time my car got to 1/4 tank. Mechanic replaced fuel filter $54.90 for filter and diagnostic on 3/13/07. It still stuttering, hesitated and now was stalling. Mechanic replaced fuel pump $297.22 on 3/28/07. The problem persisted and now it was happening at 1/2 tank. Once summer hit, it was worse with the A/C. Between march and june 2007, mechanic replaced pump once and filter twice. On 6/27/07, car stalled and would not restart, tank was at 1/2. Mechanic replaced intake manifold runner control unit and the problem remained. The problem continued with hesitating and stalling especially uphill. On 8/21/07 replaced all the spark plugs and wires $234.90. The problem continued. My mechanic is at his wits end. The code on the check engine light is always the same. On 10/26/07, took the car back to my mechanic who had to replace the intake manifold runner control unit again. Decided to take my car to a different mechanic due to my current one not finding the problem. Replaced 2 oxygen sensors this week (11/7 and 11/9) one upstream and one downstream. The check engine light has come back on once again. If this is an intake manifold runner control unit problem then everyone that has had fuel pumps replaced will have to have them replaced again. This is not enjoyable since I drive 40 miles a day to work and halfway there I have to pull over and wait for the car to idle down before I can drive again or it will stall. This is not safe as this happens while people are driving and for no reason the car stalls in mid drive. Someone will get hurt and then there will be a recall. There were no events leading up to the failure except for taking my car for inspection which it passed. Two days later my car starts stalling and losing power. In 9 months I have spent close to $1000 to try and fix a problem that still is not fixed.

Filed Aug 9, 2007 · Fuel system · 114,112 miles · CA

Tl*the contact owns a 2000 ford contour. The current mileage was 134,112. The failure mileage was 114,112. While driving 70mph the vehicle hesitated a few times and then the engine died. The vehicle was restarted after 15 minutes. The dealer stated the fuel tank had failed. The VIN was not included in the federal safety agency campaign number 00v350000 (fuel system, other: storage: tank assembly).

Filed Jul 17, 2006 · Fuel system · 60,160 miles · MA

Dt*: the contact stated that the vehicle's gas tank strap detached on 07/01/06. A strap was observed hanging from under the vehicle while parked. The vehicle was taken to an independent repair shop who determined that the right hand fuel tank assembly strap had become detached. The independent repair shop contacted the dealer who contacted the manufacturer to order fuel tank assembly strap. The manufacturer determined that the fuel tank assembly strap was on back order and that there was not a specific date when the part would arrive.

Filed Nov 15, 2005 · Engine, Fuel system · 40,000 miles · NY

The dashboard, which was once recalled, the recall has since expired. Is delaminating off the foam , preventing proper defrosting of windshield and hindering view out of front window. The fuel pump which was recalled on other ford models for exactly the same problem, fails, preventing acceleration onto highways. The water pump, which is plastic, disintergrates in the motor.

Filed Nov 14, 2005 · Body, Engine · NY

Dt: the contact stated the plastic dashboard delaminated from the foam. The dashboard laminate was pushing upward, thus hindering the contact's vision through the front window. He contacted the manufacturer, and they said it was under review, and that it was cosmetic. Also, he is also experienced fuel pump and water pump problems. Under hard acceleration the fuel pump shut off. The dealership stated the contact's vehicle needed a new fuel pump. The bearings on the water pump failed and the vehicle overheated. *ak.

Filed Jul 25, 2005 · Fuel system · 50,000 miles · MI

The car hesitates, stalls, loses power, surges, etc. While accelerating onto the freeway, going up hills, turning onto a highway etc. We've been lucky that it has only happened when we had a shoulder to coast on to. We could have easily been rear-ended by other vehichles in traffic. This has happened several times : at first it only happened when the gas tank was less than 1/4 full, then at 1/2 tank, now 3/4 full. We try to keep the tank full. The federal safety agency has a recall id # 04v421000 for the 1999 and later mercury cougar that has the identical fuel delivery module as the 2000 ford contour (v-6). This recall should be expanded to include ford contour and mercury mystique v-6 models at the very least. The federal safety agency has also recalled the 2000 ford focus with similar fdm design defects and performance problems