2005 Ford Crown Victoria technical service bulletins
44 technical service bulletins and manufacturer communications cover the 2005 Ford Crown Victoria.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article supersedes TSB 19-2026 to update the vehicle model years affected
- Corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust
- The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
- For 2005-2012 Crown Victoria, 2005-2011 Grand Marquis and Town Car vehicles, Regional Program 13R01...
- Inpected or repaired under 13R01
- Summary to be provided on a future date.
- Ford: the lower intermediate steering shaft, has corrosion of swing link joints, combined with collapsed...
- Ford: the lighting control module has extended warranty coverage, on certain vehicles, due to a possible...
- Ford: information regarding the lighting control module extended warranty coverage, for some vehicles, to...
- Ford: swing link joints on lower intermediate steering shaft, has corrosion, and combined with collapsed...
- Ford/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and...
- Ford/mercury/lincoln: vehicles may exhibit one or more of the following symptoms: drive away hesitation,...
- Malfunction indicator lamp (MIL) on--diagnostic trouble code (DTC) P2106 and P061B--POLICE interceptor...
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Reduction in power at wide open throttle
- Extended coverage program for forward clutch cylinder in the transmission may crack at the snap ring...
- Un-commanded tcc apply on the 1-2 shift causing perception of hesitation and/or lack of power during shift
- The forward clutch cylinder in the transmission may crack at the snap ring groove location causing loss of...
- Catalytic converter brick rattle or buzzing noise
- Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers
- Malfunction indicator lamp on with diagnostic trouble codes P0305, P0316, P0171, and/or P0174 after...
- High effort to activate horn - vehicles built before 5/6/2005
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Driver's seat cushion sagging
- Malfunction indicator lamp (MIL) on with diagnostic trouble code (DTC) P0305, P0316, P0171 and/or P0174,...
- Safety belt retraction speed
- High effort to activate horn
- Safety belt web stop button service
- Delayed reverse engagement
- Idle vibration vehicles equipped with single exhaust
- AM/FM and cellular phone reception interference - service tip
- Parking brake control slow to release, vehicles built from 12/06/2004 through 11/21/2005
- Auto release parking brake system difficult to set
- Light steering efforts at highway speeds
- Numerous anti-lock brake (ABS) wheel speed sensor (WSS) diagnostic trouble codes (dtc's) C1145, C1155,...
- Weld bonding procedure
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- Malfunction indicator lamp (MIL) on with diagnostic trouble code (DTC) P0455 or P0457
- Customer satisfaction program 04M05
- Police interceptor vehicles equipped with front power distribution box (PDB) option 66F - blunt cut wires...
- Pinpoint test error for front wheel speed sensors - workshop annual update
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Ford Crown Victoria?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history