2006 Ford E-150 technical service bulletins
46 technical service bulletins and manufacturer communications cover the 2006 Ford E-150.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21,...
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- On some vehicles, when the gateway 401 module transitions from its power down mode (ignition off) to its...
- Lack of power due to low fuel pressure - fuel tank liner seperation
- High pressure system diagnostics - 6.0L engines
- MIL on with DTC P03XX and/or P0606 - vehicles with 5.4L or with 6.8L
- DTC P0172/P0175 and/or downhill engine surge with 5.4L engine - harsh transmission engagement, shudder on...
- MIL on with DTC P03XX and/or P0606 - vehicles built before 08-22-06
- MIL on with P0172 or P0175 - 6.8L engine - vehicles built before 08-22-06
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Slow fuel fill on vehicles with a 4.6L or 5.4L engine and mid-ship fuel tank
- Un-commanded tcc apply on the 1-2 shift causing perception of hesitation and/or lack of power during shift
- Headlight adjustment needed
- Watch for oil flow from the base engine oil pump
- GTWY401-A1 rev 1.0 and 2.0 when module transitions from power down (ignition off) to its power up...
- Oil flow from the base engine oil pump
- Runs rough or misfire due to a stuck valve
- Intermittent DTC P0316
- Lack of power or MIL on - turbocharger sticking - revised diagnostics
- P0404 service tip
- GTWY501-AI module repeatedly resets due to excessive ambient temperature of 150 f or higher, module will...
- White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0L
- Exhaust smoke and/or smell, harsh transmission shifts -- 6.0L
- Fuel conditioner
- Part changes on vehicles built after january, 2006
- Coolant degas bottle overflow - 6.0L
- High pressure system diagnostics - 6.0L for a hard start/long crank or no start condition due to low...
- Misfire, lack of power, buck/jerk, excessive smoke or crank/no start
- ABS light on concern - 6.0L diesel
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Buck/jerk or surge - 6.0L vehicles built before 8/22/2005
- Coolant degas bottle overflow
- Hard start, no start and/or other symptoms caused by a high pressure oil system leak - service tip
- Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park
- Flutter noise on deceleration
- Headlight adjustment - chassis cab incomplete vehicles
- Safety belt retraction speed
- Daytime running lights inoperative and a/c not cooling
- Lack of power and/or DTC P2263 or P0299 after turbocharger replacement - service tip
- Misfire lack of power buck jerk excessive smoke crank no start 6.0L engine diagnostics for fuel system
- A driveline clunk or bump when starting from a stop
- Diesel exhaust smell in CAB-6.0L engine
- MIL on DTC P0172 and/or P0175 -- 4.6L
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Ford E-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history