Sudden brake hose failure. 1994 ford diesel e350 w/4-wheel ABS. Brake hose failure due to rusted portion of the hose assembly . The area that rusted away is the crimped connection which joins the rubber hose to the steel fitting at the caliper end of the hose assembly. This rust is not visible while doing a routine inspection of the brake system because it is covered by a rubber sleeve. Apparently water/moisture is collecting under this rubber sleeve and corroding the steel crimped area of the fitting until there is no more of a secure connection of the rubber hose to the steel , then when the brakes are applied and the fluid is pressurized in the brake system the rubber hose will blow away from the steel fitting. (identical failure in the federal safety agency database may 06, 2002 - toms river, nj).
1994 Ford E-350 brakes problems
16 complaints (32% of all complaints for this car). 1 crash reported.
- owner complaints
- 16
- of this car's complaints
- 32%
- crashes
- 1
- recalls
- 1
Which part fails
- Antilock/traction control/electronic limited slip11
- Power assist: vacuum: hoses, lines/piping, and fittings1
- Foundation components: master cylinder1
- Foundation components1
- Antilock/traction control/electronic limited slip: control unit/module1
At what mileage
Complaints by mileage at the time of the problem.
Ford E-350 brakes problems in other years
Specific symptoms reported on the 1994 Ford E-350 brakes
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Parking brake: conventional
- What is wrong
- These vehicles do not comply with fmvss 105, "hydraulic brake systems." the parking brake application force for a foot operated control system should not exceed 125 pounds to hold the vehicle on a 30% grade. Interference between the parking brake pedal and a wire harness may increase the needed pedal force to greater than 125 pounds to set the parking brake to hold the vehicle on the 30% grade.
- Risk
- The interference between the foot pedal and the wireharness may not allow the parking brake to fully set. If this occurs when thevehicle is parked on an incline, it may roll, causing a crash.
- Remedy
- Final stage manufacturers will be informed of this condition and provided with parts and instructions necessary to correct this situation.
Recall number 93V194000 · Recall details
What 1994 Ford E-350 owners say
Most recent owner complaints, unedited.
When trying to stop abruptly antilock brake system takes over which causes the vehicle to lose brake power. The dealer has been contacted.
Abs warning light illuminates intermittently.
Brakes vibrated due to cracked rotors and pads, after repair within 200 miles the motorhome experienced the same problems.
Abs warning light intermittently illuminates, also, when appyling the brakes vehicle vibrates and extended stopping distance occurs. Please give any further details.
Abs locked up when the brakes were applied. Vehicle hit traffic light pole while going 30mph. Vehicle had no air bags. Had the brakes checked by mechanic & nothing was found. Police report #rpc412/ofcr pauleski #2599 2156863040/3041.
Anti lock brake indicator system failed, recall component however vehicle denied due to VIN.
When the brakes were applied at about 30-40mph the pedal went to the floor, resulting in extended stopping distance. The manufacturer has been notified.
The vehicle ABS braking system malfunctioned, causing the light to stay on and the ABS system to be inoperative ,which will not assist the occupant in event of an accident. Dealer replaced a major component in the ABS system, and stated that the reason for the malfunction was because ABS system was not used. Please provide details.
When traveling 60 to 65 MPH the ABS light is illuminated on the dash. Consumer has no problem with stopping the vehicle. Consumer has contacted the dealer, dealer has replaced all parts within the ABS brakes, problem still occurs. . *ak
Questions about the 1994 Ford E-350 brakes
Does the 1994 Ford E-350 have brakes problems?
Owners have filed 16 complaints about the brakes of the 1994 Ford E-350, 32% of all its complaints, more than any other problem.
At what mileage do 1994 Ford E-350 brakes problems start?
Not enough complaints include the mileage to tell.
Was there a recall on the 1994 Ford E-350 brakes?
Yes, 1 recall: 93V194000. Check your VIN to see if your car still needs the free repair.
What year does the Ford E-350 have bad brakes?
The Ford E-350 model years with the most brakes complaints are 1995 (34 complaints), 1996 (19 complaints) and 1997 (17 complaints).
Other 1994 Ford E-350 problems
Engine 8Tires 6Fuel system 5Transmission 5Suspension 4Lights 3Acceleration 2Electrical 2Steering 1Visibility 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Ford E-350?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history