2006 Ford E-350 engine problems

Filed Oct 2, 2014 · Engine · 95,367 miles · CO

This vehicle has had multiple issues since its purchase. We have replaced all injectors, with some injectors replaced more than one. Finally, in april 2014 when the motor overheated we were forced to replace the motor.

Filed Jun 10, 2013 · Electrical, Engine · 102,000 miles · CO

Tl* the contact owns a 2006 ford e-350. The contact stated that while driving approximately 55 MPH, the vehicle stalled without warning. The vehicle was towed to and independent mechanic for diagnosis. The mechanic stated that the alternator would have to be replaced. The vehicle was repaired but the failure recurred. The alternator was replaced a total of five times but to no avail. The approximate failure mileage was 102,000.

Filed Apr 30, 2013 · Brakes, Engine · 140,000 miles · CA

Tl* the contact owns a 2006 ford e-350. The contact stated that while driving 3 MPH, the vehicle stalled without warning. The vehicle was restarted and resumed operation as designed. The vehicle was later taken to a dealer for diagnosis and the contact was informed that the oil cooling system was the cause of the failure. The contact also stated that the parking brake did not hold when engaged. The vehicle was taken to a dealer and the contact was informed that the entire parking brake unit would need to be replaced. The vehicle was not repaired for either failure. The failure and current mileage was 140,000.

Filed Jun 19, 2012 · Engine · 95,000 miles · VT

Tl* the contact owns a 2006 ford f-350. The contact stated that the egr valves malfunctioned and as a result, radiator fluid leaked into the motor. The vehicle was taken to the dealer who diagnosed that the egr valve and oil cooler needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was repaired. The failure mileage was 95,000 and the current mileage was 117,000. Updated 08-09-12 *bf updated 08/15/2012

Filed Feb 17, 2011 · Engine, Fuel system · 61,333 miles · VA · fire

Spark plug blow out on a 2006 ford e350 5.4 liter engine. Causes fuel to spray out and fire to ignite. Thin aluminum head is not strong enough to hold spark plug in place. There are over 5 million web pages concerning this issue.

Filed May 6, 2010 · Engine · 80,000 miles · NY

Ford 6.0 diesel engines have issues in respect to the seals on the oil pumps for the injection system. It is not a question of if the seals will fail, it's when. When the seals fail, the engine will shut down completely leaving the driver without power steering or brakes. I have two (2) vehicles fail in traffic causing the drivers to attempt to exit the roadway without being hit by another vehicle. The issue seems to be related to the "o-ring" seals used through-out the injection system. Unfortunately, I don't have the old parts available, but with approximately ten of these vehicles in our fleet, I'm sure it won't take long before another one fails. This effects all 6.0 ford diesel motors in all model vehicles from 2004-2008. I don't understand why there has not been a safety recall on all vehicles with this motor. As mentioned, it is not a question of if the engine will fail, but when.

Filed Dec 30, 2008 · Engine · 50,000 miles · NY · fire

Tl*the contact owns a 2006 ford e350. The vehicle was parked at the contact's job for two hours when he was notified that the hood was on fire. The fire marshall investigated and found that a faulty wire under the hood caused the fire. The insurance company declared the vehicle to be destroyed. A fire report was filed. The failure and current mileages were 50,000.

Filed Dec 4, 2007 · Engine · 39,900 miles · GA

Failure of injectors and internal oil cooler LED to immediate engine shut down causing immediate loss of power steering, power brakes, etc. This happened on two separate occasions, (1 while driving on interstate during 8am morning traffic, 2 while towing a 5th wheel rv in heavy afternoon traffic in a construction zone with no shoulder available for me to get off highway). As I often pull rv's to the far west, it greatly concerns me as to what the outcome would be if this happens while on a 6% downgrade in the mountains. I have had three injector failures recently.

Filed Jul 20, 2007 · Engine · 40,000 miles · CA

Tl*the contact owns a 2006 ford e-350. While driving, the contact depressed the brake pedal and the engine completely shut off. At times, the vehicle would restart immediately, but at other times, it would restart after an hour. The vehicle was taken to the dealer on five different occasions. During three of the visits, the dealer found no failures. On two other occasions, the dealer replaced the wiring harness and the sensor. The purchase date was unknown. The current mileage is 80,000 and failure mileage was 40,000. The consumer stated the dealer placed a computer in the vehicle to determine codes for the defect in the vehicle. The dealer stated the vehicle has a loose rattle noise after driving over bumps. The consumer provided multiple repair invoices. Updated 08/13/07

Filed Apr 6, 2007 · Brakes, Engine · 9,000 miles · FL

Tl*the contact owns a 2006 ford e350. While driving 60 MPH the steering began vibrating and shaking. The road conditions were clear. The dealer balanced the tires. However; they were unable to diagnose the failure. Approximately 4 months later the dealer replaced the steering gear box and performed an alignment; which, did not correct the failure. Also, the contact smelled exhaust fumes inside the vehicle , and the dealer was unable to diagnose the cause. Approximately three months later the engine was replaced and the exhaust fumes became stronger after being repaired. The vehicle has not been inspected. When engaging the brake pedal it caused him to depress the accelerator pedal due to it extending to the floorboard. The contact was aware of the safety risk involved. The dealer was unable to diagnose the failure. The current and failure mileage were 9000.