1996 Ford Econoline brakes problems

Filed Jun 30, 2005 · Brakes · 100,000 miles · FL

On june 25th I changed the battery on my 1996 ford e150 because the battery was dead. About a half an hour later I heard the alarm going off. When I went outside there was white smoke coming out from under the hood. I raised the hood and the sending unit on the master cylinder for the cruise control was smoking and the white smoke was increasing by the second. I pulled the wires that were leading to it and the smoked started to disapate. The vehicle was not running and the ignition was turned off. On june 29, I was watching the jane pauly show on cnn. They were reporting about a problem with this same part on the ford f150 pickups. I believe that if my alarm had not sounded my vehicle would have caught on fire like the pickup trucks in the report. As of yet I still have not repaired the vehicle and all parts are as they were on the day of the incedent. If you would like I will leave the vehicle this way so you can inspect the problem if you would like. Please contact me asap so I know how to proceed.

Filed Oct 12, 2004 · Brakes · 90,000 miles · CO

The ABS will not engage when braking during a emergency situation or a sudden stop. The vehicle has been to a repair shop on two separate occasions. The mechanic replaced the front pads and both front rotors and the problem continued.

Filed Oct 18, 2002 · Brakes · 137,000 miles · WA

Consumer states of having problems wit the ABS system. Dealer was contacted, the consumer also stated that the hcv/hyd control unit for the ABS failed and was replaced. The vehicle did not stop under hard bearing, the ABS warning light would come on/off. The consumer was told by ford that there was a recall #96vz14000. The consumer stated he owned another vehicle like this before and it also had problems-should have been recalled. *mr *sccb

Filed Sep 10, 2002 · Brakes · CA

Brakes wore out and were replaced every 4-6 months. The caliper was made of fiberglass and crumbled under the heat of braking causing the brake pads to wear prematurely. The consumer was having the front disk brakes and the caliper piston replaced with metal a metal kind, consumer has also had problems with the ABS.*yh

Filed Aug 17, 2002 · Brakes · CA

Fiberglass caliper piston on front disc brakes covered with metal plate cover brake pads only lasted 2 months because it started to crumble dangerous.

Filed May 4, 2002 · Brakes · CA · crash

This makes the 2nd time I have reported this, please respond to this!..... I have had many occasions when traveling the california freeways, when wet, and the rear drums/shoes get wet and become innoperative. I have been a repair tech on all systems of brakes, technical and simple, and find there to be a design flaw in the backing plate/relationship to the rear drums which allow water mist to enter and wet the rear shoes. I am not talking about deep puddles or gully-washers, just a light drizzle will produce this problem. When brought to fords attention, they said they have not expeirianced this with any one else, and must be my driving habbits. Well, it doesn't rain all that much,and at slower speeds, say under 35, it does not seem to happen. It is apparant when just the front wheels lock up, and the rear will not even respond to the emergency brakes, you know the rear are wet and need to be dried out like in the olden days. I see it as a safety condition, and actually rear ended a lady and had to pay for her rear bumper, fortunately, she didn't have any neck injuries, as of this day in may 20002. It has been a little over a year. Please respond to this letter. Rick wolff. 714- 821-5678 thanks.

Filed Mar 25, 2002 · Brakes · UT

The problem starts when the van starts pulling right intermittently. The ABS light starts coming intermittently on and when it comes on the vehicle starts driving straight. The light goes out and it starts pulling again. When braking it pulls hard right. The hydraulic control unit has been replaced at least 4 times and will drive good for 5000 miles. It has failed again. After driving several miles you can feel the front right rotor is significantly hotter than the left.

Filed Mar 11, 2002 · Acceleration, Brakes · MD · crash · 1 injury

Van was slowing getting up speed then surged while parking and did not stop when brakes were applied. The van hit a parked pickup and pushed it up the parking lot embarkment. The abc light came before the accident.

Filed Aug 30, 2001 · Brakes · DE

The ABS system is performing poorly although the consumer holds foot on the brake pedal with steady pressure. Nlm

Filed Aug 15, 2001 · Brakes · WV

I bought the van when it was 2 yrs. Old in dec. 1998, by that summer I had to replace both front rotors because of cracks, and I have had to do this every year since. The van is not used on a daily basis so I am wondering about a possible defect for this to be happening every 2-3,000 miles. Ford shows no recalls on this model, but the garage that has changed the rotars every time says it is not normal with so few miles between each time it happens.