2018 Ford Ecosport: fire, smoke or burning smell

Filed Aug 18, 2025 · Engine · 49,143 miles · NY

The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part required for the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check oil light was illuminated. The vehicle was taken to the dealer, who diagnosed that the light was illuminated due to a frayed wire. The wire was replaced. The dealer ended up denying the repair. The dealer asked if the check engine warning light was illuminated, if the vehicle sputtered, or if there was smoke coming from the vehicle. The vehicle was not repaired. The contact stated that the remedy stated that the vehicle would be repaired immediately, without mentioning any requirements prior to the repair. The contact called another dealer, Hempstead Ford (301 N Franklin St, Hempstead, NY 11550), who confirmed the information. The manufacturer was made aware of the issue and confirmed the dealer information. The manufacturer advised the contact not to drive the vehicle for over an hour. The failure mileage was approximately 49,143.

Filed Jul 26, 2024 · Engine · 95,201 miles · GA

The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling) however, before receiving notification the contact had experienced a failure. The contact stated that while driving approximately 65 MPH, there was smoke coming from under the hood with an abnormal rattling sound coming from the engine compartment. The contact stated that the vehicle was losing motive power with the check engine and low oil pressure warning lights illuminated. The contact drove back to the residence and later had the vehicle towed to an independent mechanic. The mechanic diagnosed the vehicle and determined that the oil pump had failed. The contact stated that the mechanic replaced the oil pump and timing belt, and recommended that the turbocharger be replaced. The contact stated that all parts were replaced; however, the turbocharger was not replaced. The vehicle was partially repaired. The contact started the vehicle and shifted into drive (D); however, the vehicle failed to exceed 30 MPH. The manufacturer was not informed of the failure. The contact stated that after receiving the recall notification, a local dealer was contacted, and the contact was informed that the part was not available. The failure mileage was 95,201. VIN tool confirms parts not available.

Filed May 16, 2024 · Engine · VA

On March 8th, 2024, I was traveling full speed northbound on I-95 returning home from a family funeral. I heard a loud "whipping" noise come from the engine, then immediately received a notification on the dash alerting me to "low engine oil pressure". Within seconds, there was a loss of all acceleration capability. The car had to coast off of the highway onto the shoulder. I was in a construction zone, and luckily had just enough room on the shoulder to pull off in between the concrete dividers. Once the car was put in park, I could smell burning oil. I tried turning the car off and back on. The dash would turn on with power, but the engine would not turn over. I had to call AAA to have my car towed to the nearest Ford dealership.

Filed Feb 25, 2024 · Engine · 102,284 miles · OH

I purchased the vehicle and not even two weeks goes by before I am going 55mph and the entire car started shutting down. I managed to get off the road. I had the vehicle towed to Klaben Ford in Warren where it took months to replace the engine and turbo. I finally get it back and not even 24 hours went by before it stalled going over railroad tracks. Klaben tells me they left a clamp on my engine and gave it back. I had it for two days before I had a loss of power again while turning left in an intersection. Luckily the oncoming traffic were extremely quick to respond and were able to stop before hitting me. This time they had my car for a week or two and gave it back finally working. Unrelated to this exact case, but Klaben also in that time had my vehicle catch on fire when another vehicle exploded next to it. They took it to their own body shop without my consent originally. Since it was already there I agreed to have them estimate repairs. Little did I realize they would cut their labor costs to be able to not total out the vehicle. Looking back I should of had an unrelated body shop estimate the repairs to have the [XXX] car totaled out and replaced. Fast forward about two years where I have my car finally running and seems great. January 2024 comes and the engine light warning comes across my car while I am on [XXX] driving 70 miles per hour with my 1 and 3 year old in the car. I stop and I have it taken to my mechanic who told me to drive it as little as possible because the engine would need replaced. I then call Ford to tell them about it and asked about a buy back. This was TWO DAYS before I get the advance recall letter. Not once in the phone call did they tell me how dangerous my car was at this point and never said anything about the recall. I try to go to work the next day and my oil light then comes on. I then finally get the recall to find out I would still have to pay about $7,500 out of pocket for engine and turbo as well at $1,800 a month in rental cost. INFORMATION REDACTED PURSUANT TO THE F

Filed Jan 12, 2024 · Engine · CA

I was driving approximately 60 mph on the freeway for only 2 or 3 miles when my engine suddenly started to stall & white smoke came out of the tailpipe. i immediately pulled onto the emergency side lane and was towed

Filed Jul 13, 2023 · Engine · 93,000 miles · AR

The contact owns a 2018 Ford Ecosport. The contact stated that when the vehicle was shifted to drive or reverse, the vehicle started to jerk. The contact stated that while driving approximately 30 - 55 MPH, the engine started to overheat with the "Low Engine Oil Pressure" message and the oil lamp warning light illuminated. The vehicle stalled and the contact coasted to the side of the road. The contact was able to restart the vehicle. The failure recurred 3 times on that day. The contact became aware of white smoke coming from the rear of the vehicle near the exhaust pipe which dissipated after the vehicle was shut off. The vehicle was taken to the dealer and the contact notified that vehicle had experienced engine failure; however, the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 93,000.

Filed Jun 19, 2023 · Fuel system · FL

Hello, This is my first recall complaint so I will do my best the Dashboard light is on indicating low oil pressure along with the engine light as well. After researching this issue, with my 2018 Ford Eco, sport. I have also read a lots of complaints from online website including YouTube videos from customers and mechanic Indicates that this is an ongoing problem for this year, make and model of vehicle. This is a very expensive part to replace a long with the hours of labor Involve With this repair $1500-$2000 later. My mechanic also indicates this is an ongoing problem after just having a vehicle a few years, the belt will break and get stuck in the oil pump were it will have trouble getting pressure where this parts will have to be replace along with a few other small parts that goes with it and if you’re lucky like myself you’re car won’t catch on fire in the process or at least that is what mechanics are talking about online about this particular issue. Mechanics are also saying that this is a poor design on Fords behalf with the belt, breaking. I checked for a recall on this problem could not find one. I’m hoping that you will see that this issue needs to be considered a recall because $1500 to $2000 is a lot of money for someone like myself that is broke and has nothing to their name but one car made by Ford motor company and someone like myself that is living paycheck to paycheck. If you need more information please contact me anytime [XXX] or [XXX] Thank you so much for your time INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Jun 9, 2023 · Engine · FL

On my way to work as a travel nurse in another state from home, my car had an engine oil pressure light come on. It was the dark hours of the morning and I wasn't sure what it meant so I looked for the next place to stop safely. Not even five minutes later, I heard a large bang, almost like a gunfire sound, and large billows of smoke came from the front part of the car. My car handling went out and I lost complete control of the car and it started to skid. I gripped the steering wheel as a way to turn into my skid to steady the car until it came to a stop. Luckily there was no one on the road and I avoided a crash. After sending it to the Ford dealer, I found out a few weeks later that the car needed a total engine replacement which astounded me on a car that had less than 32,000 miles. My car is under warranty and I had just did an oil change and 21 point inspection two months before which was checked out good and it was not due for another couple hundred miles. I am now fighting with Ford to address this issue as I now know this is a common problem with the Ford 1.0L Ecoboost Engines. The car is getting the Engine replaced (a band-aid fix to a open, bleeding wound) but it doesn't help the fact that this is an unsafe vehicle and can happen again. When, not if, that happens, safety is a huge issue as I almost crashed the car the first time. Unfortunately, my state of Florida will not buy this car back as I have owned it for over the two years, however, I still owe money on it and have no choice to keep it until I can trade it in. Ford and the federal safety agency needs to address the safety issues with this vehicle. The next person that this happens too (could be me again) might not be so lucky.

Filed May 24, 2022 · Engine · WI · fire

Engine Caught fire and car was engulfed in flames. Insurance is investigating. Oil Pressure Low light came on roughly 10 minutes before this occurred.

Filed Jul 31, 2019 · Engine · 50,000 miles · CA · fire

Check engine light illuminated after a short drive, vehicle was turned off and parked a short time later in a parking lot. A few minutes after that, the vehicle engine compartment caught fire. Vehicle was at the dealer a few days prior to the incident for repair work (coil, spark plug)