The contact owns a 2018 Ford Ecosport. The contact stated that while driving approximately 40 MPH, the vehicle lost motive power, shook and vibrated, and then stalled. During the failure, the check engine warning light illuminated, and the oil pressure message was displayed. The vehicle was towed to the local dealer, who diagnosed that the engine had failed due to a faulty oil pump drive belt tensioner. The engine was replaced, but later the replacement engine experienced an oil pressure failure. The vehicle was taken to the local dealer but had not yet been repaired. The contact received notification of the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The manufacturer was made aware of the issue. The failure mileage was approximately 55,000.
2018 Ford Ecosport engine complaints
Page 3 of 23: complaints 41 to 70 of 643, newest first, as owners wrote them.
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine completely failed less than a month after purchase at approximately 58,000 miles. The vehicle is currently at Wicklund Auto in Rolla, MO for inspection and repair, and the engine is available for inspection upon request. 2. How was your safety or the safety of others put at risk? A complete engine failure caused the vehicle to shut off while driving, which could have resulted in a sudden loss of power, stalling in traffic, or inability to accelerate or brake properly, creating a serious risk of a collision or other accidents. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Wicklund Auto has confirmed catastrophic engine failure. The dealership, Arizona Car Sales in Mesa, AZ, has not taken responsibility but may have inspected the vehicle. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by Wicklund Auto, and repair documentation is available. The manufacturer and dealership have been notified but have not assumed responsibility. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? On August 10, 2025, at approximately 8:07 PM, the LOW ENGINE PRESSURE indicator illuminated. I exited to a Mobil gas station and waited for 30 minutes. During this time, the FULL ACCESSORY POWER ACTIVE indicator turned on, and shortly afterward, the vehicle shut down completely and became inoperable. No prior warning lamps or messages appeared before this date. Additionally, I was not informed of any relevant recall at the time of purchase from Arizona Car Sales, which could have affected the safety and reliability of the vehicle.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while the transmission was shifted into reverse, or while diving during rainy weather, there was an abnormal sound coming from the rear wheels. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the battery needed to be replaced. The vehicle was repaired out-of-pocket. The local dealer was contacted on several occasions about the recall repair; however, parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 400.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that while driving at 30 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed that the oil pump drive belt material had degraded and lost teeth. The engine was replaced; however, the compressor for the A/C failed to function as intended once the new engine was installed. The dealer informed the contact that the failure of the compressor was not related to the recall. The contact disagreed with the assessment. The vehicle remained at the dealer unrepaired due to the compressor failure. The manufacturer was not notified of the failure. The failure mileage was approximately 53,600.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The contact stated that two dealers were contacted, and the contact was informed that the manufacturer would not approve the repair if the vehicle was not actively experiencing the failure associated with the recall. The contact was also informed by a dealer that if the repair was performed, the vehicle might still experience the failure because the dealer had seen other vehicle with the failure after the repair was performed. However, the contact was informed that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the repair would not be repaired without a failure being experienced. The contact had not experienced a failure.
The contact owns a 2018 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power and was unable to accelerate above 40 MPH. The “Low Oil Pressure” warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the engine oil pump. The vehicle was not repaired. After investigating the failure, the contact attributed it to the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The VIN was included, but the vehicle was not yet repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was 70,000.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, after contacting several local dealers, the contact was advised that the vehicle would not be inspected unless a failure had occurred that was related to the recall, and then the recall repair would be provided. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Vehicle Information: •Year / Make / Model: 2018 Ford EcoSport Titanium 2.0L •VIN: [XXX] ] •Mileage: ~70,000 miles Problem Description: I am experiencing multiple engine and emissions-related issues on my 2018 Ford EcoSport at only ~70,000 miles. These include: •Check engine light illuminated continuously •P0016 – Crankshaft/Camshaft Correlation (Bank 1 Sensor A) •P0017 – Crankshaft/Camshaft Correlation (Bank 1 Sensor B) •P0420 – Catalyst System Efficiency Below Threshold •All emissions-related lights, including camshaft indicator, are on •Vehicle is sluggish and struggles to accelerate These issues first appeared around 30,000 miles and recurred more severely at ~70,000 miles. The vehicle has been maintained according to manufacturer recommendations, with regular oil changes using the correct oil type. This appears to be a premature failure of timing chain/cam phasers and possibly catalytic converter components. I have checked for recalls and found none applicable to my 2.0L engine, and there are no known Technical Service Bulletins specifically covering this problem. I am concerned about safety and reliability, and I am submitting this complaint so that the federal safety agency can track these issues and determine if further investigation or action is necessary. Additional Comments: •I am aware of other Ford owners experiencing similar timing chain and cam phaser issues at low mileage (60k–80k miles). •I request that this information be considered for investigation into potential safety defects or extended coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The vehicle was taken to the dealer six times; however, the contact was informed that the parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure related to the recall.
The contact owns a 2018 Ford EcoSport. The contact stated the vehicle was idling roughly. While checking around the engine, the temperature coming off the engine was significantly hotter than the other temperatures around the vehicle. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed the vehicle and determined that there was coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The dealer informed the contact that the failure was a known failure; however, there was no recall related to the failure. The vehicle was no longer operable. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case regarding the failure. The failure mileage was approximately 100,000.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part required for the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check oil light was illuminated. The vehicle was taken to the dealer, who diagnosed that the light was illuminated due to a frayed wire. The wire was replaced. The dealer ended up denying the repair. The dealer asked if the check engine warning light was illuminated, if the vehicle sputtered, or if there was smoke coming from the vehicle. The vehicle was not repaired. The contact stated that the remedy stated that the vehicle would be repaired immediately, without mentioning any requirements prior to the repair. The contact called another dealer, Hempstead Ford (301 N Franklin St, Hempstead, NY 11550), who confirmed the information. The manufacturer was made aware of the issue and confirmed the dealer information. The manufacturer advised the contact not to drive the vehicle for over an hour. The failure mileage was approximately 49,143.
The car suddenly lost oil pressure and the engine light came on. I immediately pulled to the side of the road and my vehicle was trailered to a Ford service center. They termined that the engine needed to be replaced. Now I receive a recall for this same issue but we already paid fir a new engine replacement.
The contact owns a 2018 Ford EcoSport. The contact stated that while driving at 35 MPH, the vehicle jerked abnormally. There was no warning light illuminated. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The dealer was contacted and informed the contact that the vehicle would not be serviced under the recall if the engine had not failed or seized. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was not available.
As I was driving in the highway the car began to loose power... it began to slip, it speeds up then goes down etc, once I slowed down but before coming to a complete stop the car shut down while I was exiting the highway. We could have been hit from behind if it wasn't that i had already been slowing down because the car didn't feel right. It has happened more than once, the slippage of power is constant. According to the codes and the diagnostic it was the turbo that needed replacement along with other things I have a video summary of the issues. However, this began right after my warranty expired and the engine had already been replaced due to another issue not even a year before. This car seems to be nothing but problems. You get the check engine light that comes and goes amd the "see manual" light which doesn't tell you anything other than it could be anything. This car is not even 10 years old... it's not high mileage. They seem to know that the turbocharge is an issue but nothing is done about it.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Ecosport. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the turbo charger. The contact was informed that the turbo charger need to be replaced. The vehicle was not repaired. The contact stated that a failure with the turbo charger had occurred less than a year prior and was replaced. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was unknown. The VIN was not available.
The contact owns a 2018 Ford EcoSport. The contact stated while driving 80 MPH, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway and turned off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated but had since turned off. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The contact was advised to bring the vehicle back if the check engine warning light became illuminated again. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); the VIN was included, but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 17,000.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
On your vehicle, it may be possible for the engine oil pump drive belt tensioner arm to fracture, separate from the tensioner backing plate, andor the oil pump drive belt material may degrade and lose teeth, resulting in a loss of engine oil pressure.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, the vehicle hesitated and jerked while attempting to accelerate. There were no warning lights illuminated. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while idling at a stop sign or a stop light and attempting to accelerate, the vehicle failed to accelerate, and the transmission shifted into neutral. The contact manually restarted the vehicle to continue driving. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed that the head gasket needed to be replaced. The vehicle was repaired, and another unknown repair was completed. The dealer confirmed that parts for the recall repair was not yet available. The manufacturer was not made aware of the issue. The failure mileage was 76,000. VIN tool confirms parts not available.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The contact stated while driving 40 MPH, there was an abnormal hissing sound coming from the engine and then a popping sound. In addition, the accelerator pedal involuntarily moved, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. Additionally, there was an abnormal squeaking sound coming from the vehicle. The contact drove slowly to the residence. The contact stated that the oil engine pressure warning light was illuminated. The contact stated that at the residence, a family friend opened the hood and noticed oil intrusion into various parts of the engine. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 106,000. VIN tool confirms parts not available.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2018 Ford Ecosport. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was restarted after several attempts. The check engine warning light was illuminated. The contact stated that the failure had occurred twice. The vehicle was not diagnosed or repaired. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 32,000. VIN tool confirms parts not available.
My 2018 Ford EcoSport is subject to Safety Recall 23S64, concerning a defective oil pump belt and/or tensioner that can lead to engine failure. My VIN is listed in this recall. The engine has symptoms consistent with this recall, including performance loss, mechanical noise, and diagnostic codes such as P0014 (camshaft timing over-advanced), P0303 (cylinder misfire), and U0100 (lost communication with ECM/PCM). The vehicle is currently located at an authorized Ford dealership (Sunrise Ford of North Hollywood). However, the dealer has refused to perform the required diagnostic inspection unless I pay $1,084. This is a direct violation of federal law under 49 U.S.C. § 30120, which mandates that both diagnosis and remedy of safety-related recalls must be provided free of charge. I have also documented communication from the dealership and a written inspection from an independent licensed repair shop showing the engine is in as-found condition and that no repairs were attempted. I am seeking enforcement action to ensure that the recall is honored as required by law. Dealership: Sunrise Ford of North Hollywood Address: 5500 Lankershim Blvd, North Hollywood, CA 91601 Service Advisor Name: Bruno Rivero
The contact owns a 2018 Ford EcoSport. The contact stated while driving at an undisclosed speed, the low oil pressure warning light illuminated, and the vehicle was shaking erratically. In addition, the contact noticed an abnormal rattling sound coming from the vehicle. The contact parked the vehicle and performed an inspection of the vehicle. The contact checked the oil level and noticed that the oil level was sufficient. The vehicle was towed to the residence. The contact inspected the oil level and noticed oil was leaking from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 57,350. VIN tool confirms parts not available.
The contact owns a 2018 Ford EcoSport. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 65 MPH, the low oil pressure warning light was illuminated, and the vehicle stalled while driving off a ramp. The vehicle was towed to D & M Auto Service, where the contact was informed that it was a known failure, and the engine might be damaged. The vehicle was not diagnosed or repaired. An unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 27,000. VIN tool confirms parts not available.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford Ecosport?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history