Ford Ecosport fuel pump problems

Filed Apr 1, 2026 · Engine, Fuel system · AR

My light engine comes on a few times. First it was the coolant, then the engine light came off. The next is when I was fueling my gas tank. I try to start it, it won’t turn on all the way. Third time it has happen. Went to ford they want to charge almost $900 just to fixed the vehicle. It had a recall in 2020. Bought the car used at Crain in Fayetteville Arkansas. They fix the belt and fuel pump. After they got it fixed I’ve been having the light engine comes on constantly. Now I’m stuck with no vehicle because I don’t feel safe driving it. 12/15/2025 the first engine light came on. For a coolant, then 1/24/2026 light came back on. For another coolant code, they check it and they said my coolant was fine. 3/04/2026 service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. 3/11/2026 service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. 3/12/2026 The Engine system has detected a fault. 3/12/2026. Came back on The Engine system has detected a fault. 3/20/2026 Your service engine soon alert is on because an issue has been detected with your vehicles’ s emissions system. I took it the shop on the 3/27/2026 They put a diagnosis on the computer The code came for P0496 EVAP System High Purge Flow 02 Sensor Signal Biased/Stuck Rich - Bank 1, Sensor 1 ABS Anti-lock Brake System U0155-00 Lost Communication With Instrument Panel Cluster They said it wasn’t part of the 80,000 warranty for the federal law. I’ve done research and it came up on the same code I got. So now they want almost $900 dollars with a $250 dollar diagnostic when I’ve already told them we went to auto part to get the code. They had to hook it up again to see if it’s the same code.

Filed Sep 12, 2025 · Engine · 105,000 miles · MS

The contact owns a 2020 Ford EcoSport. The contact stated that while driving approximately 55 MPH, the vehicle stalled. The contact observed smoke coming from the engine compartment, and the check engine warning light was illuminated. The vehicle was not able to restart. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the repair was unavailable. The vehicle was towed to the dealer, where it was diagnosed that the fuel pump tensioner assembly and oil pump drive belt had failed and needed to be replaced. The dealer confirmed that the parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and the contact was informed that parts were on back order, and a case was opened. The failure mileage was approximately 105,000.

Filed Dec 9, 2024 · Engine, Fuel system · CO

I broke down in the middle of nowhere while roadtripping. My engine fuel pressure light came on. The closet Ford was an hour away. 20 mins in my engine started making a horrible sound. I had to pay to get myself and it towed the rest of the way. After being diagnosed by the dealership, the recall of the oil fuel pump/belt completely failed and went through my engine. If I had continued driving my engine would have seized. I now need a whole new engine in which Ford said will take a minimum of a month before my car will be fixed. up until this point I always took care of routine maintenance and oil changes even having my whole car completed inspected last month. There were no warnings once so ever up until the actual moment the part was failing and the warning came up on my dash.

Filed Nov 22, 2024 · Acceleration, Engine · 91,000 miles · FL

The contact owns a 2018 Ford EcoSport. The contact stated while driving 40 MPH, the check engine warning light illuminated. The message that there was “No Oil Pressure” was displayed. The vehicle decelerated and stalled. The vehicle was restarted but failed to accelerate above 20 MPH. The contact pulled over safely. The contact stated that the failure was related to the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where it was diagnosed and determined that the fuel pump had failed, and the engine needed to be replaced. After the engine replacement, the mechanic informed the contact that there was engine oil leaking onto the ignition coil. The vehicle was not repaired. The dealer informed the contact that the additional repairs would be an out-of-pocket expense. The manufacturer was contacted, and opened a case, but no additional assistance was provided. The failure mileage was approximately 91,000.

Filed Sep 6, 2024 · Engine · 103,000 miles · OK

The contact owns a 2020 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the low oil pressure warning light illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure due to the fuel pump failure. The contact was informed that the engine needed to be replaced. The contact received notification of the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 103,000. VIN tool confirms parts not available.

Filed Jun 24, 2024 · Engine, Fuel system · GA

Almost 6 months ago, my car began to malfunction. It would not start at all. I paid $500 to have a mechanic diagnose the issue and replace the battery, but nothin worked. I had to have the car towed to the Ford dealership, and they advised me that my engine had failed due to a defect in the fuel pump tensioner, which was an issue that was under recall. They told that they could not do anything to repair the issue, however, because the recall had not been officially published. It has now been nearly six months with my vehicle sitting at the dealership, unusable, because Ford refuses to repair it until the recall comes out. They have also refused to provide a rental or loaner car so I have been out of a vehicle.

Filed Mar 6, 2024 · Engine, Fuel system · TX

Low engine oil pressure fuel pump

Filed Dec 14, 2023 · Engine, Fuel system · MD

Oil flow light came on and I went to Walmart to have oil changed and to make sure oil filter was good. went to leave Walmart and oil flow light came on again. they took back in to take another look at it and could find anything noticeable. I was then told I should take it to a mechanic cause to him it seemed like the fuel pump wasn't flowing oil properly. I started home and while on the interstate I started smelling gas and the car started making a very loud whistling noise, like a teacup whistle. I was going 70mph and all of a sudden, the car jerked and quickly went to 30mph with all lights coming on. Had a tractor and trailer quickly coming upon me that had to serve to the next lane to keep from hitting me and almost hitting yet another car in that lane. Could get the car to get up past 30mph so I pulled off to the side of the road and once coming to a complete stop vehicle shut off and wouldn't restart. Had vehicle towed to a garage where I was informed that I need a engine replacement.

Filed Dec 1, 2023 · Engine, Fuel system · WV

Fuel pump failure has caused low engine oil pressure and now the engine in the vehicle has to be replaced

Filed Nov 15, 2023 · Engine, Fuel system · MI

The low oil level indicator light went on while I was driving in my 2019 Ford EcoSport. I stopped at an auto parts store and had them add oil. The light did not go off when we tried to clear the sensor. I drove it home (about a mile) and it struggled to pick up speed and the engine started to knock. I did some research on the model and the government is currently looking into to this issue and there are several lawsuits. All have indicated they were just out of the warranty and the entire engine needed to be replaced. It is going to cost me thousands of dollars to fix this. I was told that there is not indication that there are any issues with the engine or fuel pump until it is too late. There is an open case with the federal safety agency (SSM 48093) so this is a very well known issue and will continue to get worse with other EcoSport drivers as they near 60,000 miles. It is HORRIBLE business practice to do this to customers. I now have to pay thousands of dollars for a problem I did not know about it was too late. Ford needs to take responsibility for this.