2016 Ford Edge visibility problems

Filed Apr 15, 2026 · Visibility · MI

Saw there was a recall for wiper motor defects for Ford Explorer and Escape, per the federal safety agency Campaign Number 26V117. We had intermittent wiper failure with our 2016 Ford Edge Sport years back, which resulted in Ford repurchasing the vehicle back through the BBB (back in 2019). If carry-over parts / design are similar between the Explorer/Escape & Edge, then you may want to investigate incase the scope of this recall needs to be expanded. Please give me a call if you have any questions. (I'd like to stay anonymous as I am a Ford employee) I think we still have videos of this that we can share too.

Filed Dec 8, 2025 · Driver assistance, Visibility · CA

Manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner: Sep 08,2025 Manufacturer Recall Number 25S89 the federal safety agency Recall Number 25V572 Recall Status Recall Incomplete, remedy not yet available

Filed Nov 11, 2025 · Visibility · WI

The rear window spontaneously shattered/exploded. The rear defrosted was on as well as the rear wiper. It was 30 degrees outside.

Filed May 27, 2025 · Visibility · MI

On [XXX], around 7 PM, while my 2016 Ford Edge SEL was parked in front of my apartment, I used the remote start feature to start the vehicle. After activation, the rear window shattered unexpectedly. I could hear the crackling sounds, and the rear window was falling apart. There were no external impacts or visible damage to the window prior to this incident. The vehicle was stationary, and the weather conditions were normal at the time. I went to Elder Ford of Rochester Hills. The manager informed me that they could not do anything and that I should fix the car before returning it at the end of the lease period. I mentioned that there was Technical Bulletin FSA# 17B39 for the 2016 Ford Edge in Canada, but the manager informed me that it was only valid for Canada. He advised me to keep the receipt in case Ford USA issues a similar recall. FSA# 17B39 informs that war and salt can weep through the rear wiper motor shaft grommet. The residues in the rear defroster and cause uneven heat in glass and cause it to break or shatter. I live in Michigan so this is a common situation of salt/water during winter. It is unacceptable that this issue was not addressed. I had to pay $397 to fix a problem that was not caused by me. There are numerous complaints in forums about this same issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 22, 2025 · Visibility · 98,009 miles · IL

The contact owns a 2016 Ford Edge. The contact stated that while driving 65 MPH on the interstate with the rear windshield defroster engaged, the vehicle made an abnormal, loud popping sound, and the contact noticed that the rear window had shattered. The contact drove under an underpass, switched lanes, and pulled over safely. There was no warning light illuminated. The contact called the local dealer, who confirmed that the VIN was not included in a recall. The vehicle was inspected by a glass specialist who secured the rear windshield with plastic. The specialist determined that the rear window defroster had been overheating. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the federal safety agency hotline for assistance. The failure mileage was approximately 98,009.

Filed Apr 15, 2024 · Visibility · 71,000 miles · FL

The contact owns a 2016 Ford Edge. The contact's daughter opened the partition for the panoramic sunroof and discovered that the rear stationary panel of the panoramic roof had developed several, spider web cracks along the edge of the glass. The vehicle was taken to a dealer and the contact was informed that the vehicle was out of warranty and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 71,000.

Filed Mar 19, 2024 · Body, Visibility · VA

Sunroof is cracked, concerned about it flying out and hitting another car.

Filed Feb 6, 2024 · Visibility · NE

Rear window suddenly shattered while driving . No other vehicles around . Entire windshield shattered and pieces are now falling into back hatch area . There were no passengers with me at the time . This renders the car not safe to drive . I was pulling into my driveway but had I been out on the highway (In January) this would soon become an issue of exposure to below freezing temperatures. Ford claims they have never heard of this when I’m finding other reports of this happening online . Dealership is saying it’s replaced at all my cost also ? Seems like a manufacturing fault ? There is a FSA # [XXX] that Canadian owners have listed. My car originally was sold in North Dakota. Currently I’m in Nebraska . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 27, 2023 · Visibility · NY

Back windshield - not available for inspection as I have had it repaired already. Back windshield shattered/exploded sounded like a balloon being blown up too much and then popped - hazard to when someone is physically driving the vehicle and has no idea what just happened Inspected by insurance reps No warnings besides at the time it happened I heard a strange blowing noise After glass broke and was replaced multiple shards of glass jammed the trunk lock making it unable to be opened from outside or inside. Had to have dealership replace plastic trim and lock also after glass was repaired by safelite

Filed Jan 27, 2023 · Visibility · WI

Rear window breaking for no apparent issue. Broke on me over night sitting parked. Could break on someone driving dow the road and cause an accident.