2005 Ford Escape Hybrid electrical problems

Filed Mar 29, 2019 · Electrical, Engine · 130,000 miles · CA

Tl* the contact owns a 2005 ford escape hybrid. The contact stated that the vehicle stalled without warning and the "stop safely" warning indicator flashed. The vehicle was unable to be driven due to the failure. Manteca ford (555 n main st, manteca, ca 95336, (209) 239-3561) was notified of the failure and stated that the vehicle needed to be diagnosed in order to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 130,000.

Filed Jan 3, 2019 · Brakes, Electrical · 45 miles · FL

The ABS control module. Noticed many complaints. Had 1700 dollars of work to fix the issue and the brakes went out on me yesterday. Three weeks after the work. The ABS and brake light came on again and the brakes failed on hwy 19 fl. Pulled over ,turned the car off like what I read online about this type a vehicle, started up and the brakes were back' took it home and parked it. When is ford going to put a recall on this, when someone dies.of course had I known about this defect I would have never purchased it. I have only had it for a little over a month and it has low mileage..

Filed Sep 16, 2015 · Electrical, Engine · 200,000 miles · MN

Tl* the contact owns a 2005 ford escape hybrid. While driving approximately 30 MPH, the speed suddenly decelerated before the vehicle stalled. The vehicle was restarted, but continued to experience the failure. During the incident, the master vehicle electrical hazard warning and the engine electric coolant temperature sensors illuminated. The cause of the failure was not diagnosed or repaired. The manufacturer was notified. The failure mileage was 200,000.

Filed Dec 10, 2014 · Electrical · NY

The electronic coolant pump that cools the hybrid battery is faulty we have had this problem for two years and the car continually breaks down on trips. We have spent over 1500 fixing it. There is a recall on this product and ford refuses to honor because the light is not on currently. As soon as my son drives somewhere the light goes on and the car comes to a stop. He currently is in grad school in denver and we are getting complete run around from ford.

Filed Jul 29, 2014 · Electrical, Steering · 127,844 miles · CA

Car was parked and turned off left sitting for 2 hours. Got back, turned vehicle on, backed up from parking stall and power steering locked. It became hard to turn or control the steering. Tried turning off car and restarting, but that did not reset or release the power steering. No warning sound or lights came on. Drove car home with emergency lights and on the shoulder for about 3 miles. Parked car and left sitting for 5 hours hoping it would reset. Before turning the ignition, I turned on AC, then turn on the car. That did nothing. Now the wrench light came on and "power steering service" warning came on. Isn't the warning done before an incident can happen? Had a mechanic place a machine to diagnose the car, but no luck. Please help in fixing the issue. There should be an investigation for defect on electrical warning.

Filed May 29, 2014 · Electrical, Engine · 75,000 miles · OH

Tl* the contact owns a 2005 ford escape hybrid. The contact stated that while driving 60 MPH, the vehicle stalled without warning. The vehicle was taken to an independent mechanic where the technician diagnosed that the water pump for the hybrid battery failed and needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage was 75,000. The VIN was not available.

Filed May 3, 2014 · Electrical, Engine · 99,000 miles · NY

0

Filed Jan 23, 2014 · Electrical, Suspension · 105,000 miles · MA

I was driving my vehicle and the "service soon" light came on then about 10 seconds later the "stop safely" light came on and my vehicle shutdown and would not restart. I had the vehicle towed to the nearest ford dealership and found out that there was a failure with the electrical system that had to be reset (shutdown was to protect the hybrid battery). Once ford fixed the electrical system to get car to start again, they informed me that the passenger side rear shock absorber had fully detached from the wheel house and was basically a dangling piece. Ford could offer no help "they didn't have the equipment or capability to fix" and said I had to go to a auto body shop to have the piece welded back to the frame. Turns out there is nothing there to weld, the entire connection has rotted out and needs to be replaced. From what I can find online this is a recurring issue on 2005 ford escapes and ford refuses to deal with it. Cars with these issues are extremely unsafe to drive. Luckily I was not involved in an accident when this happened but I was only driving 35mph on a side street, imagine what could've happened if I was traveling at 70mph on the highway and the piece just fell out. This is an extremely difficult fix that ford owners should not have the burden of dealing with financially on a car that is less that 10 years old. My car is very well maintained and has a lot of life left in it, but now this fix is going to cost close to $2500. This should be further investigated so ford has to fix this safety issue! Has anyone considered filing a class action suit for defective car parts???

Filed Sep 11, 2013 · Electrical, Engine · 140,000 miles · MD

Tl* the contact owns a 2005 ford escape hybrid. The contact stated while driving approximately 25 MPH, the vehicle lost power and stalled. The contact also mentioned that a red triangle illuminated with a message to stop safety. The vehicle was taken to the dealer and the mechanic diagnosed that the service harness needed to be installed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 140,000. According to the service bulletin, the program involved installing a service harness in the high-voltage traction battery and reprogramming the battery control module. Updated 11/06/13 updated 11/29/13

Filed Nov 26, 2012 · Acceleration, Electrical · 115,790 miles · FL

Driving at night on four-lane us highway at 50 MPH when engine suddenly stalled. Warning lamp came on with stop safely now message. Scary in traffic but was able to pull over onto shoulder without causing an accident. Aaa towed to ford dealership which diagnosed stuck open circuit in throttle body. Replaced part 5m6z*9e926*ca throttle body and motor asy. Part $376.70 labor $262.50 shop fee $2.50 sales tax $48.13 total $ 689.83 very expensive but lucky to not have been hurt.