My 2015 Ford Escape is diagnosed with a coolant intrusion due to flawed design issues by Ford. Coolant is slowly leaking into valve 2 and causing white smoke upon startup. The engine block is cracked due to faulty coolant system by per the designed of Ford. Only remedy is a new engine which is quoted at $8000. As this problem is entirely caused by Ford, it is unfair to expect the consumers to pay such a price.
2015 Ford Escape engine complaints
Page 2 of 10: complaints 11 to 40 of 273, newest first, as owners wrote them.
MIL activated, reported misfire in cylinder 2. Attempted to replace spark plugs but they had seized. Took to dealership: was told coolant leaked into cylinder and entire engine needed to be replaced. Technician said this was common with Ecoboost engines for this model year, but not enough to merit a recall. Cost to replace engine more than the vehicle is worth
The contact owns a 2015 Ford Escape. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact was concerned about driving the vehicle due to a potential fire risk. The contact received notification of the federal safety agency Campaign Number: 25V695000 (Back Over Prevention) and 26V011000 (Equipment). An appointment was scheduled with the local dealer who confirmed that the parts were on backorder. The vehicle was not diagnosed or repaired. Additionally, the vehicle was scheduled to be towed to the local dealer. The manufacturer was not contacted. The failure mileage was approximately 88,000.
- The car loses coolant while the engine is running. This coolant loss is nearly imperceptible, except that the car's heat stopped working reliably. If the car is left idling with the heat on, it does not become warm. It only begins to become warm at higher speeds, then loses heat after slowing down.There are no easily visible coolant leaks. - If I had not caught it in time, the car could have overheated, causing a breakdown and emergency stop. - I have reproduced the problem, but it has not been brought to a dealer. - It has not yet been inspected. -There were no warning lights, I only noticed the coolant loss because I observed the radiator not working and checked under the hood. - The car is still available to be inspected, and is safe to drive short distances if the coolant is topped off.
Service engine warning light came on. When checked, coolant was found to be leaking into cylinder 3 due to the engine block being porous. Service center said they see this a lot in this particular engine.
The contact owns a 2015 Ford Escape. The contact received notification of the federal safety agency Campaign: 25V695000 (Back Over Prevention); however, the part to do the recall repair was not available. The contact stated that occasionally, while shifted in reverse, the rearview camera failed to display as intended and was possibly impacted by severe weather conditions. No warning light was illuminated. In addition, the contact stated that during colder weather, the heater failed to operate as intended while activated. After further inspection, the coolant reservoir was abnormally low. The vehicle was taken to a local dealer, where it was determined that the coolant level was extremely low. The coolant reservoir was refilled; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.
Cabin lost heat November 2025. Brought it in to the local Ford dealership right away and they said replacing replacing the oil cooler hose will probably fix it. Car worked fine for a couple of weeks but the cabin heat tapered off again. Made another appointment with the Ford dealership, but the first available appointment wasn’t until 2/23/26. I tried to drive anywhere as little as possible after this because I live in Fairbanks, AK and it’s commonly -30 this time of the year. Tried to leave work on [XXX] and a warning came up as I started driving away that the engine was overheating and power was reduced to minimize damage. I put my car back in my work parking spot and plugged it in until I could get an appointment at a local mechanic shop. Had the car towed to a local shop 1/6/26 and they inspected it 1/7/26. The report came back saying there was an internal coolant leak and found hydrocarbons in the cooling system. The recommended fix was to replace the entire engine with a quote for $12,000. That is more than I paid for the vehicle and way over the Kelly Blue Book worth. I did some research and found that there is a common coolant leak issue damaging engines of a certain range of Ford vehicles that has not become an official recall yet. I looked at other Ford Escape owner complaints and it looks like my 2015 Escape 1.6L has the same engine defect. I’m afraid if I pay for the engine replacement, this will just happen again. If I don’t pay, I still owe for my lease and will only get pennies to sell it as is for parts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Ford Escape. The contact stated that while driving approximately 50 MPH, the vehicle stalled. The contact pulled over to the side of the road, and after several attempts, the vehicle restarted but continued to stall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Vehicle Information: 2015 Ford Escape – approximately 165,000 miles Incident Description: During normal operation while backing out of a parking space, the vehicle unexpectedly slipped out of the drive gear immediately after I shifted from reverse to drive. There were no warning lights, messages, or prior symptoms indicating a potential issue. After restarting the vehicle, it briefly engaged drive but was only able to travel approximately ten feet before abruptly shifting through multiple gears without any driver input. During each occurrence, the engine surged to unusually high RPMs despite no acceleration being applied. Safety Concerns: The unintended gear changes were accompanied by loud whining noises, and the vehicle was unable to remain in any gear long enough to be operated safely. This failure left the vehicle immobilized on a main roadway, causing a traffic backup and creating a hazardous situation for myself, my children, and surrounding motorists. Current Vehicle Condition: After the vehicle was towed home, I attempted several restarts. At no time did any warning indicators or a check‑engine light illuminate. Each attempt resulted in the transmission immediately disengaging from gear when shifted into either drive or reverse, accompanied by continued loud whining noises and repeated engine surging to high RPMs without throttle input. The vehicle is currently inoperable. Additional Details: I plan to take the vehicle to Keith Hawthorne Ford for diagnostic evaluation. I am concerned that this failure may be related to a previously repaired transmission recall, as the recall documentation states that the defect may recur and could require additional corrective action. The dealership is currently requiring a diagnostic fee of $199.95 to inspect the vehicle.
Unknown coolant leak. Coolant is being lost somewhere in the engine no visible leaks. Added coolant several times.
Engine began giving white smoke from exhaust at start up. 2 Mechanics have checked it and said it’s a well Known coolant intrusion issue with these ford eco boost engines. High risk of overheating and engine failure (while driving, which is a major safety risk for my family).
Coolant leak has been checked by mechanic to not be due to problems with any hoses or connections within the coolant system. Inspection is available upon request. The issue has caused the coolant level to drop below the minimum coolant level 4 times within 3 months with no warning or visible leaking occurring. This has been a regular occurrence with this vehicle for several months now.
The contact owns a 2015 Ford Escape. The contact stated that while driving approximately 45-50 MPH, the engine was overheating. Upon inspection, the contact noticed that the coolant level was significantly low. The contact added coolant to the coolant reservoir. Additionally, the contact noticed that coolant was leaking onto the ground. The vehicle was taken to an independent mechanic, where a coolant line was replaced; however, the failure persisted. The check engine warning light was illuminated. Additionally, the contact stated that the failure had caused collateral damage to the vehicle. The contact stated that the transmission, the serpentine belt, and the pulley were replaced. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 150,000.
We had to replace the engine about 4 years ago and we’re still getting gas smell into the cabin. About 3 years ago, we broke down on the road because the transmission quit. All our repairs have been done through Ford service department. We are now broke down again because of the transmission. Something has to be done with the Ford Escape!
Vehicle is leaking coolant.
The 6F35 transmission in my vehicle is shuddering and it seems like it’s going to possibly mess up my engine or anything else soon. It also jerks a bit forward from 0-25 along with gears slipping. This has almost caused an accident for me.
all equipped with 1.6-liter gasoline turbocharged direct-injected engines â could be subject to a lack of coolant circulation resulting in the engine overheating
Purchased my 2015 escape in Aug. of 2023 used knowing that the head gaskets needed to be replaced. Took it to a certified mechanic and had everything fixed on it. Fast forward to October of 2024 - Transmission went out had to purchase a brand new transmission had it installed at the certified mechanic. Then in July of 2025 all of the sudden it overheated. Took it back to the same mechanic and once again the head gaskets are blown. They stated that coolant had leaked into the motor and now it all needs replaced. How is this not a recall yet with everything that I have been reading. A recall has been issued for a back up camera but not this. We have been driving without back up cameras forever but we cannot drive a vehicle when every few months we need to dump thousands of dollars in it.
There appears to be coolant leaking into/into the engine that compromised the seals and created oil leak/burn issues with the engine.
I am having a issue that is not new to ford, my ford escape is having the coolant leak issue, I already have spend more than 2k on it, still engine is over heating, Ford Escape reps and almost all the mechanic know the issue is very known, I hope this issue is addressed.
Driver's seat stop working and the engine leaks and the suspension went bad and transmission stopped in the middle of traffic on foulk road in wilmington delaware april 18, 2025 and was very scared and nervous..
While driving to Las Vegas, I noticed the engine felt unstable and coolant levels were low. After topping off coolant, the car drove normally for the remainder of the trip, but the air conditioning intermittently blew hot air. A mechanic performed diagnostic and pressure tests, but no codes appeared. The issue recurred with repeated coolant loss and stalling sensations. The following day, the vehicle overheated on the freeway and stalled. A mechanic diagnosed a blown head gasket and cracked cylinder head, which cost me $4,500 to repair. Less than a month later, the same issue happened again. This defect creates ongoing safety concerns due to the risk of sudden stalling, overheating, and potential engine fire. I have learned that this issue is widespread in Ford Escape EcoBoost engines, and Ford has not issued a recall or permanent fix.06
UNKNOWN, but appears like other version of Ford Escape the 2015 suffers from the same fuel pump issues. On at least 10 moments the car stalls and dies during driving. When brought to Fords attention, they have on 2 times indicated that no error codes or way of duplicating problem. I had independent car repair place as well look into the issue with the same response. We now only drive the car if we have to and only in short areas where we are not driving on the freeway and if we can walk home. Please add this to the recalls.
While driving, the car hesitates changing gears. Sometimes the car will not go in gear or go into Park. Had a recall in 2022 for some bushings and cable shifter. The car is too dangerous to drive and mechanics have stated a new transmission is needed.
The contact owns a 2015 Ford Escape. The contact stated that while accelerating from a stop, the vehicle failed to move. The contact placed the vehicle into Sport Mode and was able to drive as needed. The check engine warning light was illuminated. The contact replaced the vacuum, and the engine light went off. The contact had an independent mechanic arrive at the residence, and the mechanic determined that the vehicle was about to throw a rod. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 97,000.
The contact owns a 2015 Ford Escape. The contact stated that the check engine warning light was illuminated. The contact stated that upon scanning the vehicle with a vehicle scanner, the contact retrieved diagnostic trouble codes indicating an engine misfire. The contact replaced the ignition coils; however, the failure persisted. The contact stated that while replacing the spark plugs, the spark plug thread of cylinder #4 remained stuck in the cylinder head. The vehicle was taken to an independent mechanic, where the contact was informed that the spark plug thread might be stuck because the cylinder head had melted around the spark plug thread. The mechanic determined that the cylinder head needed to be replaced. The dealer was notified of the failure and recommended the cylinder head replacement. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in an undisclosed recall. The contact was referred to the federal safety agency Hotline for assistance. The failure mileage was approximately 80,000.
My 2015 Ford Escape, VIN [XXX], equipped with the 2.0L EcoBoost engine, has experienced a repeat engine failure due to what appears to be the known “coolant intrusion” defect currently under active litigation (Miller v. Ford). The original engine failed due to loss of coolant into the cylinders, causing rough idle, misfires, abnormal engine noise, and loss of performance. Ford replaced the entire engine under warranty approximately 24.5 months ago. The replacement engine is now exhibiting the same symptoms, including: Rough/unstable idle, especially on startup Abnormally loud engine noise Suspected internal coolant loss with no visible external leaks Reduced performance and hesitation This is the second major engine failure in a short time, creating a serious safety concern due to potential sudden loss of power while driving. The EcoBoost coolant intrusion defect is widely reported in Ford Escapes from this model year and is the subject of a class action lawsuit. Ford has not issued a recall for all affected vehicles, leaving owners at risk of repeated engine failures. I am submitting this complaint to document the repeat failure, as it poses a risk to safe operation and may affect other vehicles on the road. I can provide repair records, photos, and video evidence upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Transmission sticks and only will tend to shift once it hits 3 RPM! And jerks
On 7/25/25 at about 1pm my son was driving the ford escape 2.0 engine (2015) and it started jerking, stalling while driving. The AC shut off suddenly and the car was overheating. He almost got in a car accident when it suddenly stopped! Turns out it was coolant oil intrusion issue and now requires a new engine 12k
Coolant intrusion
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history