The contact owns a 2016 Ford Escape. The contact stated that while driving approximately 40 MPH the check engine light began flashing, and the vehicle began misfiring. When the contact reached their destination the check engine light turned from flashing to solid. The vehicle was taken to the dealer diagnosed that there was coolant intrusion due to coolant leaking in cylinders 1,2,3 and 4. The dealer stated the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,780.
2016 Ford Escape engine complaints
Page 4 of 9: complaints 71 to 100 of 249, newest first, as owners wrote them.
The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the engine overheated and several unknown warning lights illuminated. The vehicle was driven to the shoulder of the road to allow the engine to cool down. The contact opened the hood and checked the fluids. The contact stated that the coolant reservoir was low. The contact refilled the coolant reservoir. The vehicle was taken to an independent mechanic and was diagnosed with catastrophic coolant intrusion in cylinder #4. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 97,000.
The contact owns a 2016 Ford Escape. The contact stated while driving 25 MPH, the vehicle stalled while depressing the brake pedal. No warning light was illuminated. The contact stated that on a separate occasion, while the vehicle was stopped, the vehicle was idling rough, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic; however, the vehicle was not diagnosed. The contact stated that the vehicle received undisclosed repairs; however, the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.
Antifreeze leaks in cylinder, Ford says need to replace engine only 75k on the engine.
The contact owns a 2016 Ford Escape. The contact stated that the heater failed to operate with the check engine warning light was intermittently flashing on the instrument panel. The vehicle was taken to a dealer where it was discovered that coolant was leaking into cylinder #3. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to file a complaint. The vehicle was not repaired and remained with the dealer. The failure mileage was unknown.
The contact owns a 2016 Ford Escape. The contact stated while at a stop light, "The engine was overheating" warning message illuminated. The vehicle was taking an independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 84,100.
Coolant leaks into engine. Not repairable and requires full engine replacement.
Coolant leaked into the heads and ruined engine.
The contact owns a 2016 Ford Escape. The contact stated while starting the vehicle, there was a loud knocking sound coming from the engine. The engine overheated with the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the flex plate and Oxygen sensors had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline for assistance. The approximate failure mileage was 113,918.
The contact owns a 2016 Ford Escape. The contact stated while driving at approximately 25 MPH, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that there was an internal coolant leak into the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no recall on the VIN for the failure. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 44,000.
The contact owns a 2016 Ford Escape. The contact stated that while stopped on several occasions, the vehicle was idling rough. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was a misfire in cylinder #1. The vehicle was not repaired. The contact stated that an undisclosed DTC code was reset however, approximately a week later the code reappeared. The engine then started overheating and coolant was added to the coolant reservoir was administered. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.
Has internal coolant leak
The car is releasing large amounts of white smoke when starting the car in the morning, and shows declining levels of coolant (way below MIN when I checked). I suspect this is due to a leaking gasket.
The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle intermittently hesitated while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the engine block was cracked, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 150,000.
The contact owns a 2016 Ford Escape. The contact stated while starting the vehicle, there was thick white smoke coming out of the exhaust pipes, and the engine was running rough while driving. The vehicle was taken to the local dealer, where it was diagnosed with coolant intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 63,500.
Transmission faulty
Ford is aware of a design flaw with the 2.0 Ecoboost engines. It impacts Escapes, Fusions, Edges, and some Lincoln vehicles. They issued TSB # 22-2229 about this. According to Ford, the only fix is to replace the engine. The engine block has a design flaw that causes the head gasket to blow and cause severe coolant leakage into either cylinder 2 or 3. Ford says to replace the Long block. My vehicle had less than 70k miles on it and started having issues just a month or so after the warranty expired. An engine should last much longer than this. Now our vehicle may be worth $500 instead of about $9,000. Ford knows this is an issue and there is significant information on the Internet about this. Ford should have been forced to recall these engines. From a safety standpoint, our engine fails to start at times. The cylinder is so full of coolant at times, the engine won't turn over for a while. We have to keep bumping the starter to get it to finally turn over. We purchased this vehicle new from a Ford dealership. The vehicle is otherwise in excellent condition and has had the oil changed every 4,000 miles, much less miles than required by Ford.
The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, the vehicle failed to properly accelerate with the check engine warning light illuminated. The vehicle was taken to the local mechanic to be diagnosed. The contact was informed that there was a coolant intrusion in cylinder #1. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were not yet contacted. The failure mileage was 135,000.
My car overheated when I pulled over I noticed my engine coolant low. I had a mechanic add more fluids then a day later car shuts off why I was going 65 on a highway . I was pushing down on the gas peddle but my car would not go. It was barely moving no matter how far I pushed gas peddle. I finally found a somewhat area to pull over . I almost died or was seriously injuried in a few close call accidents this day. Had someone look at it from a garage in town he said it was a fuse and a cylinder misfire. No engine light no issues then my car over heated again no warning just shut down but the car still on Emmy lights didn’t work my turn signals didn’t work . Then my car stopped dead in a busy roadway over heated smoking . Now I’m time I need an engine replacement Let me add my car only has 60000 miles on it and is in great maintained condition I am a single mother of 3 young kids and take care of my mom. Not employed due to a bad relationship and trying to get back on my feet and now this . Coolest leaks into cylinder causing over heating and catastrophic engine damage , so upset over this and ford won’t even diagnose my car with out a 200 dollar charge to start with . It’s pathetic
65,000 miles, coolant intrusion into #1 cylinder confirmed by Ford service center. First signs were Check Engine Light, rough idle. Replaced all spark plugs and coils. Check engine light returned the following day with loss of coolant in tank. Engine runs rough and overheats with coolant loss and continued intrusion into engine, endangering occupants
Throttle body and motor was replaced twice due to engine keep stalling issues on the roads intermittently. Had faced life threatening occasions multiple times because the car engine stalled while car was driving on the roads. I brought the car to the local Ford service center several times and got the DTC P2112 code each visit. Ford service center approved the throttle body replacement on 2/10/2020 (car mileage 26688) but the same issue came back a few months later. P2112 was detected again on 4/30/2023 (mileage 40215) It was not very frequent but it happened once per month or every other month. I brought this car once again to the same local Focal service center and they diagnosed the throttle body and motor to be defect again (mileage 46476) and replaced it on 10/15/2024.
Ford Escape is experiencing multiple symptoms: * Fuel smell in the cabin * Sluggish acceleration * Hard start (cranks several seconds without ignition) after refueling * (RARE) Engine stall when coming to a stop.
The car was running fine, but check engine light came on. Took it to the dealer to have it checked out. They told me there is coolant intrusion into engine cylinder 2 (I think number 2) and the engine needs to be replaced. Apparently this is a known issue that can lead to overheating, “catastrophic” engine failures and potential engine fires. They quoted me roughly ten thousand dollars to have it replaced. I told them it was still running fine. They said I could maybe keep driving it but there is no way to know what will happen and when but it needs to be replaced. I am only now seeing page after page of consumer complaints regarding the same issue.
Power reduced to lower engine temperature message appeared on the dashboard. Stopped and saw coolant seemed empty. I filled it up to the max line. The next day it was empty again. It’s been 2 days and I filled it again today.
The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating. After a visual inspection of the engine compartment, the contact observed that the coolant reservoir was abnormally low, even though the coolant reservoir had recently been refilled. There was no warning light illuminated. The vehicle was taken to the dealer, who determined there was coolant intrusion into cylinders#3 and #4, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 86,000.
Catastrophic engine failure. "Engine skipped timing; timing codes coolant intrusion in cylinder#1 inside cylinder head". Car towed to Portland Oregon Ford dealership and remains there. When warning lights appeared saying "engine failure pull over safely", the driver pulled over; it was not a safe area to be parked indefinately. The Escape vehicle has needed towing twice for related engine /coolant problems including driver being on a road out of town alone and needing to take a bus back home from the rural area. Engine/vehicle is available at dealership for inspection. Problem has been recreated and the Ford mechanic has given the above description.
The contact owns a 2016 Ford Escape. The contact stated that while his nephew who is a mechanic was replacing the front passenger’s side ball joint, he observed that the radiator was hanging down and the support brackets were rusted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 160,000.
The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, the vehicle went into LIMP Mode, with the "Engine coolant over Temperature" message on the instrument panel. The vehicle was taken to a dealer where a diagnostic test revealed that there was coolant intrusion into an engine cylinder and the contact was provided an estimate for the repair. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 124,500.
The contact owns a 2016 Ford Escape. The contact stated that while cold starting the vehicle, there was an abnormal knocking sound coming from the vehicle. In addition, the contact stated that the check engine warning light intermittently illuminated on the instrument panel. The vehicle was initially taken to an independent mechanic where a diagnostic test was performed on the vehicle. The mechanic discovered a misfire in cylinder #2 due to coolant intrusion into the engine. The dealer and an independent mechanic informed the contact that the engine needed to be replaced. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 85,000.
After riding around with a friend one afternoon, we went to a drive-thru for a snack and my car began to notify me that it was overheating. The dashboard stated that I should pull over and immediately shut off the engine for it to cool down. Upon doing so, I checked the coolant level, and upon releasing pressure, I noticed the coolant was low. I drove to the nearest Autozone and appropriately filled the coolant levels as needed. After that, the engine never overheated again, but it began to have issues accelerating, as well as running rough upon starting the engine and while in idle. A couple days later, the check engine light came on so I took my vehicle to the nearest Ford Dealership to see what was going on. Ford concluded that coolant was leaking into the 2nd cylinder of my engine. Due to this, the entire engine needs replaced at only 160,000 miles on a not even 10 year old vehicle. After investigating online, I noticed that thousands of other Ford vehicle owners with the same make, model, and year, are having this exact same issue. Ford knew that they were mass producing engines with faulty head gaskets and now their customers are paying for it out of pocket. Ford needs to make this right for their customers and issue a recall on the entire engine.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history