While I was driving, suddenly check engine light pop up. After investigating and troubleshooting by mechanic it shows need to replace Evap canister purge valve. Vehicle has just 68000 miles and this component should not be failed this early in life cycle.
2016 Ford Escape fuel system complaints
Page 2 of 4: complaints 11 to 40 of 72, newest first, as owners wrote them.
The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who determine that the canister purge valve was stuck in the open position. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 80,000.
The contact owns a 2016 Ford Escape. The contact stated that after parking in the vehicle, the odor of fuel was present inside the garage. Upon inspection, the contact discovered fuel leaking from under the vehicle. The vehicle was taken to the local mechanic who diagnosed that the fuel lines had rusted and failed causing a fuel leak. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 23,000.
Ford Escape is experiencing multiple symptoms: * Fuel smell in the cabin * Sluggish acceleration * Hard start (cranks several seconds without ignition) after refueling * (RARE) Engine stall when coming to a stop.
The following all occurred in just the past year. The following is a report from this May 2024: Performed Cooling System Pressure Test, Discovered Coolant to Be Leaking From Behind Engine Next to Firewall, Continued Diagnosis and Performed Physical Inspection Removing Wiper Cowl to Get a Better View of Behind the Engine, Once Wiper Cowl Was Removed Discovered Rear Heater Hose to Be Leaking Coolant Causing Customers Concern. Recommend Replace Heater Hose and Perform Cooling System Service During the Courtesy Inspection Aaron Noted: ***Coolant Fluid Very Low Due to Coolant Leak, Recommend Perform Cooling System Service with Hose Replacement ***Vehicle is Equipped With Timing Belt, Check Customers Records For Previous Replacement - The inital issues was the purge valve stuck open, which lead to a misfire code, so they mechanic had a replacement of purge valve chassy and replace spark plugs. - 2 weeks following this event, we were told the engine would need to be replaced due to an internal coolant leakage that resulted from a broken gasket. The vehicle does not even have 200,000 miles.
Uncontrollable acceleration increase; Difficult and rough starting; Engine overheating warning lights and message alerts; Coolant empty and no visible leak; Continued loss of coolant; Copious moisture smelling of anti freeze coming from exhaust; Check engine light codes: P1450, P1450 pd, PO302
While driving home going about 40 mph my Ford Escape lost acceleration and then completely shut off IN THE MIDDLE OF THE ROAD! I was able to "limp" it to the side of the street where it would not start at all. I then placed it in reverse (as I was on a hill) to roll it backwards into a neighborhood to get it out of the way of on coming traffic. It was 10 PM at night! I waited for a few minutes and was able to get it to start but not change gears. I was able to get it to my neighborhood with hazards on going barely 10mph. It literally rolled into my driveway where it has been since (November 2023).
When driving the car at interstate speeds the transmission overheats after just a few minutes. When this happens it triggers the car’s information system to send a message stating “Transmission Fault Service Engine Now.” Just a moment or two later it sends another message stating “Speeds Reduced To Lower Engine Temperature.” Once that message is received you no longer have any throttle control and speed will continue to decline, speed dropped from 70 mph to 30 is maybe an minute, until you pull over and let the transmission cool down. This is especially hazardous on the interstate if your in faster moving traffic with cars behind you and you can no longer accelerate with no way to signal this to the traffic behind you except the four ways. The problem seems to be the fan to cool the transmission never gets the signal to turn on and cool down the transmission. This is an ongoing issue with this vehicle and has been since I got it, there are also multiple site and forums full of this same year make and model having the same issue.
On November 14th, 2023, a red alert appeared on the dash that indicated an engine temperature warning indicating that there was a high temperature warning and that I should find a safe place to pull over and immediately stop the vehicle. The temperature indicator on the dash showed the needle move instantly into the red/high area and then drop down. This happened twice, back-to-back. I checked the coolant and it was below the minimum level indicator as shown on the reservoir. A day later, the service engine light illuminated. I took the vehicle to Advanced Auto and asked to pull the service code and was told there were two, P0303 and P0304 which indicated a cylinder three misfire and cylinder four misfire. I noted that the coolant was also low once again despite seeing no fluid on the ground after allowing the vehicle to run. Bill Collins Ford inspected the misfires and coolant and found the issue to be related to a flaw in the engine design which allows coolant to leak into the cylinders. I was told this could have allowed the vehicle to overheat and catch on fire as well as causing the engine to lock up while in operation. Bill Collins Ford provided an estimate of $13,000 to repair the vehicle stating it required a new engine. I purchased this vehicle used from CarMax on August 2, 2023 and have put less than 3,000 miles on it before experiencing this issue.
While driving the car shuddered and then shut off. The transmission light came on with a warning about 5 minutes after it shut off. So there was never a warning and we were unable to get it to go back into any gear.
Stalling in the middle of highway twice
Vehicle check engine light goes on usually during hot weather. Vehicle stalls and hesitates on acceleration causing unsafe conditions with traffic, intersections, etc.
Car suddenly stalled out and stopped. Restarted and stalled again, and several more times. Diagnosed with fuel pump failure.
The contact owns a 2016 Ford Escape. The contact stated that while his wife was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who retrieved a code indicating a failure of the fuel separator sensor. Further investigation determined that the sensor was stuck in the open position, potentially exposing the vehicle occupants to toxic fumes. The contact stated that the diagnosis was confirmed by a second independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline. The failure mileage was 32,825.
Defect in the coolant system which caused leaking into my cylinders
The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, she smelled an abnormally strong gasoline odor inside the cabin of the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed but no failures were found. The contact's son used the OBD reader and Ford computer system to diagnose that the fuel line originating from the engine to the fuel tank appeared to be clogged. The contact's son diagnosed that the purge valve Evap System had failed and needed to be replaced. The manufacturer was notified of the failure and opened a case. The manufacturer informed the contact that the vehicle needed to be diagnosed by the dealer, and it would then be determined whether they could assist with the repair. The vehicle was not repaired. The failure mileage was approximately 14,000.
The contact owns a 2016 Ford Escape. The contact stated that the transmission was previously replaced. The contact stated that after refueling, the vehicle was unable to restart immediately. The contact depressed the accelerator pedal while turning on the vehicle to correct the failure. Additionally, the vehicle made abnormal sounds and would shake and then stall while driving. The vehicle was taken to an independent mechanic, who diagnosed that the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 150,000.
Jerking, unwanted jolting, locked up steering
On April 10, 2022, I received the check engine light indicator on my 2016 Ford Escape. I took the vehicle to a local mechanic to be inspected on April 15, 2022. I was informed after a diagnostic that my Vapor Canister Purge Valve was malfunctioning. I was told that the part could be ordered, but it was on backorder in excess of 4,000 orders. I have had the following problems that continue to put myself and other motorist in danger: I am unable to accelerate past 50MPH due to air build up in my engine causing engine stall outs on major roadways and intersections with the inability to restart the vehicle, as well as the inability to safely refuel my vehicle due to restart problems. My car has stalled out on major state highways and interstates, creating unsafe situations for myself and other motorists. Over the past 4 months I have continued to call my mechanic and Ford, with Ford offering no ETA on the production of the needed part.
The contact owns a 2016 Ford Escape. The contact stated that immediately after refueling the vehicle, the vehicle failed to start as needed. The vehicle was towed to an independent mechanic to be diagnosed. The mechanic was unable to determine the cause of the failure. The mechanic was able to start the vehicle. The contact stated that on another occasion while driving at an undisclosed speed, the engine started to rev causing the vehicle to lunge forward. The contact stated that the vehicle was difficult to control. The vehicle was stopped and then towed back to the independent mechanic. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 140,002.
2016 Ford Focus SE check engine light code P1450 Malfunctioning Canister Purge Valve / Fuel Tank Vacuum. This error is common and known. This causes the engine to not start after fueling. And engine to buck / stall while in Motion / driving. Yet no recall notice on file for vin.
My car has 25000.00 miles on it. This started last year. It is a 2016 escape. Runs fine until I put gas in it. The car will not start after I fill up. I thought I was crazy, as that is the only time it does this. Once I get it started it is fine until I fill up again. I look online to see if anyone else had this problem and found out it is common with this car. I spent 257.00 for new purge valve and it fixed the problem. The car never showed a check engine or code. This is a comon problem and should be recalled!
Tl* the contact owns a 2016 ford escape. The contact noticed that there was a burning odor coming from outside of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the turbocharger was leaking and they needed to replaced the turbocharger, fuel line and fuel gasket. The dealer was not notified of the failure. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 89,805.
Vehicle at various times acts as if it is not getting fuel, tends to almost stall, seems to be when making start from being stopped then moving forward and sometimes when making left turn at light, occasionally on right .
Tl* the contact owns a 2016 ford escape. The contact stated that after refueling, the vehicle would not immediately restart. After restarting the vehicle, while driving at undisclosed speeds, the vehicle hesitated and stalled without warning. The cause of the failures were not determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was 107,000. The consumer stated snow was entering the vehicle at the hatch and the driver side back door.
2016 ford escape while driving the car goes into limp mode especially on hot days. While driving on the expressway with my family in the car, the vehicle just shuts down and I pray that I can get over to the shoulder to turn it off and let it rest. Is not pulling any codes so they can't figure out what needs to be fixed. I bought this vehicle brand new. It is scary knowing it could shut down at any time while I am driving with my family in it. Ford needs to fix this probelm asap!
Emissions purge valve is bad/stuck. Truck stalls while driving at times. When shut off to get gas, must wait 20 minutes before truck will start.
Driving down very busy street and vehicle stalled as I pulled up to traffic light and came to a stop. As many as 3-4 times I was almost rear ended while trying to get vehicle started. Problem seemed to only occur when fuel tank is below 1/2 tank and I would notice fuel fill port flapper vibrating and sucking air into fuel tank. The ford focus has this recall on the canister purge valve, why not on a ford escape. Same part used on both. This problem went on for two weeks before I could get vehicle into dealership.
I bought it around aug 1, 2019 with about 30,000 mi. Less 2 months after I bought it, it started intermittently going to limp mode, where I can't accelerate past ~1500 rpms. Restarting the car usually makes it go back to normal. Though sometimes I have to restart the car several times, which sometimes triggers the check engine light, and/or turn it off and wait a couple min to make it go away. If I restart the car, and it immediately goes back to limp mode, I can hear/see the rpms go abnormally high for sec then go back down. When in limp mode, the traction control warning light, airbnb warning light, "hill start assist not available" message, and "engine fault service now" message come on. It usually goes into limp mode at low speeds in stop and go traffic when I'm stopping and sometimes when accelerating, especially on hills. Though it came once on the interstate when I was just slight braking going from ~ 70 MPH to 65 MPH, requiring me to dangerously pull over onto the shoulder of the interstate at night. I took it to the toothman ford dealer in grafton, wv where I bought the car, and they the found code p2107 about the throttle actuator. They told me that the throttle body needs replaced. I had that done 2 times with 2 different throttle bodies but that didn't fix it. I took it to another ford dealer for a 2nd opinion while it was in limp mode, and they found a code about a problem with the throttle body circuitry/wiring, but they checked all the wiring and couldn't find anything wrong. Also, once when I did a cold start after my car was parked in the rain all day, the car went straight into limp mode as soon as I turned it on.also, one time in limp mode I smelled gas burning. I took it to an independent shop to diagnose the odor and was told the gas wasn't getting to all the cylinders. Restarting the car temporarily made the problems go away these times too.
I have a 2016 ford escape 4wd. It is consistently stalling when driving. I've been told that the transmission needs to be replaced. I paid $22,000 for the car and it is only a few years old. The internet has several complaints from others reporting the same or similar problem with their 2016 ford escape. It is extremely dangerous to drive the car as it stalls in intersections with on coming traffic. Ford company is stating if it's not under warranty and their is no recall for this problem they will not do anything accept an engine or transmission replacement at my cost which is upwards of $6000. I can't do anything with the car and it's too expensive to do what they are saying is the repair. They know this problem is common and a huge safety issue. I guess they have weighed the cost of the recall and decided people should die first before they will be forced to do the right thing by acknowledging and fixing the problem.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history