A cracked engine block caused coolant intrusion into my Eco Boost engine resulting in overheating engine. I was almost stranded in the Cascade mountains. Randy Wright at Bill Pierre Ford of Seattle says he sees a Ford Escape with this problem once a week. After multiple conversations with Ford corporate, it appears Ford is aware of the problem but unwilling to issue a recall for these dangerously defective engines. The vehicle gave no prior warnings before the overheating took place.
2018 Ford Escape engine complaints
Page 14 of 50: complaints 371 to 400 of 1,458, newest first, as owners wrote them.
OBD trouble code P0302 — cylinder 2 misfire caused by coolant seeping in from a deformation in the block.
In 2021 my engine was replaced by the dealership I purchased it from, with a manufacturer made engine. The issue was that the coolant was leaking into the cylinders causing the engine to overheat which is a potential risk of fires. It was under warranty for 5 years or 50K miles whichever came first. Today, I was notified by the dealership that my engine needs to be replaced AGAIN for the SAME ISSUE as 4 years ago. Coolant leaking into cylinder causing misfire. I was charged $1400 for repairs that DID NOT HAVE ANYTHING TO DO WITH THE ISSUES. Ford is now telling me there is nothing they can do for me and my car is safe to drive so long as I keep it filled with coolant.
Engine light came on. Took directly to Ford dealer. Code P0303:00-A8. Cylinder 3 misfire. Coolant leaked into engine. Need long block replacement. 2018 1.5L engine. 57000 miles. Ford won't warranty. $14,000 to replace engine.
The engine light came on and we took it to the dealer where we purchased it. They told us the engine had coolant leaking into it from a warped engine block. The vehicle has less than 50,000 miles on it. The dealer told us it would cost $14000 to replace the engine. We are feeling quite frustrated as FORD was aware this was a known problem / design defect. They even went as far to correct the design on new models. What can we do?
The car began a rough idle, followed by odd fluid noises from the engine once shut off. I then saw an engine fault light come on and brought it straight to the dealership. They diagnosed a coolant leak into the engine, based on a default in that model, which would require a full replacement. Otherwise the car could lose power without warning.
The contact owns a 2018 Ford Escape. The contact stated that while driving on several occasions at various speeds, the contact observed smoke and coolant. The check engine warning light illuminated, and the message "High Engine Temperature - Stop Safely" was displayed. The vehicle was taken to an independent mechanic who retrieved DTC: P0303-28 (Cylinder #3 misfire) and P0316-28. The mechanic informed the contact that the coolant level was low, and the short block needed to be replaced. The vehicle received unknown repairs. The vehicle was repaired, but the failure reoccurred within one week. The vehicle was then taken to a dealer, where it was diagnosed with coolant intrusion into the engine, and the short block needed to be replaced. The vehicle was repaired; however, the contact was then informed that the turbo needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 87,742.
I was sold the Escape and was not informed about the coolant intrusion and have been having the check engine light come on and off since I purchased it last September, I've replaced multiple spark plugs on cylinder 3 and later found out that the inside of the cylinder had developed surface rust and was having coolant leaking into that cylinder, and due to the coolant leak, my engine overheated and shut it self off in my driveway.
I have 117k miles on my ford escape and have always maintained the services on my car. I was driving and my car started to overheat and warning lights came on. Pulled over immediately and turned car off and had it towed to the shop. Mechanic told me the coolant leaked into the cylinder and caused a misfire in cylinder 2&3. He currently has 3 other ford escapes there with the same issue. Yet there is no recall for this? He quoted me $6,400 for this job. This is crazy. Something needs to be done about this if so many people are having the same issue.
Check engine light came on. Then overheat light. Stopped vehicle and stayed 45 mins. Had to put refrigerant in vehicle drove home. Took to parts store than ran codes. #2 spark plug misfire. Now my car at Ford dealership with engine gone. Will contact ford.
Blown head gasket which is causing coolant to leak into the cylinders. Check engine light came on at 72,000 miles (leased the car at 71,000) with coolant loss. The problem was diagnosed by an independent service center on 8/19/25, 3 weeks after leasing to buy.
The contact owns a 2018 Ford Escape. The contact stated that while operating the vehicle, the check engine warning light illuminated and remained illuminated. Additionally, the vehicle experienced harsh driving and hesitation while accelerating. The vehicle was also consuming an excessive amount of coolant. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 146,000.
[XXX] Ford Escape panel flashed red with warnings about overheating. Could not drive vehicle. Vehicle towed to nearest Ford dealership. After inspection, advised that coolant intrusion into Cylinder 2 caused engine to overheat and was not repairable. Replacement cost ranges from $8,000-11,000. Contacted Ford Corporate since class action suit involved this exact problem. Ford Corp said that they could not assist with repair even though this make and model was included in a class action suit of which we knew nothing. There is a loan on the vehicle that cannot be sold except to a salvage company. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Escape. The contact stated that while driving 55 MPH and depressing the accelerator pedal, the vehicle lost motive power with white smoke coming from the exhaust. The contact pulled over to the right side of the road, turned off, and restarted the vehicle after approximately 30 minutes. The contact stated that there was still white smoke coming from the exhaust, and the vehicle was driving in LIMP Mode. No warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed that there was coolant intrusion into the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 94,000.
The contact owns a 2018 Ford Escape. The contact stated that upon starting the vehicle, there was white smoke coming from the exhaust, and the vehicle surged forward unexpectedly. The check engine warning light remained illuminated. The contact stated that upon inspection, the coolant level in the coolant reservoir was low. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the engine was faulty due to coolant intrusion and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 102,000.
The contact owns a 2018 Ford Escape. The contact stated that after starting the vehicle, the check engine warning light displayed, and the vehicle was taken to the local Auto Zone who diagnosed a cylinder misfire. The vehicle was later taken to the local dealer who diagnosed the vehicle and determined that there was coolant inside the cylinders, causing the spark plug to fuse inside the cylinder, and the spark plug could not be removed. The contact was later advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 88,418.
The contact owns a 2018 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The vehicle was losing coolant. The contact related the issue to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The vehicle was taken to the local dealer for an oil change, and it was diagnosed that the coolant was bubbling and entering the engine. The vehicle was not repaired. The manufacturer was contacted, who confirmed there was no recall coverage on the VIN, and the contact was referred to the federal safety agency Hotline. The failure mileage was approximately 67,500.
The contact owns a 2018 Ford Escape. The contact stated that when the vehicle was cold-started, the vehicle was idling roughly and vibrated abnormally before the vehicle stalled. The contact stated that several unknown warning lights were illuminated. The contact stated that the failure was a recurring failure. The contact had taken the vehicle to an independent mechanic, where it was diagnosed and determined that there was coolant intrusion into the engine, and that the engine needed to be replaced. The vehicle was not repaired. The contact was informed by the mechanic that the failure was a known failure. The contact called the manufacturer and was informed that there was a TSB, but the vehicle was not covered under warranty. The manufacturer referred the contact to the federal safety agency Hotline. The failure mileage was approximately 140,000.
Due to a lack of power I took my car to my mechanic for diagnosis. After performing compression checks he found that 3 of the 4 cylinders had low compression. Additionally the coolant level was found to be low. A check of the Ford web site showed that TSB #22-2229 was issued and indicated that coolant was leaking into the block. The Ford remedy was to replace the short block assembly. This repair would cost approximately $6 - 7000. No re-call was ever issued for this problem.
The engine design allows premature failure of the head gasket and allows coolant to leak into the cylinders. This is a known issue and I just had it happen to my car.
The contact owns a 2018 Ford Escape. The contact stated that while driving at 35 MPH, the vehicle hesitated, with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed, and determined that there was a misfire in cylinder #2 due to coolant intrusion. The contact was informed that the bottom of the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline for further assistance. The failure mileage was approximately 75,600.
Engine failure. No engine lights are on and vehicle is driving fine, but engine block could crack due to coolant intrusion problem. Coolant intrusion is a defect in the motor well know to Ford and mechanics.Ford customer satisfaction program:21N12 and 19B37.TSB tech. serv. bulleting 22-2134 and 19-2375. Problem has been confirmed by private mechanic shop and Ford dealer. No warning lights, no messages, no symptoms. Problem appeared scheduled maintenance & multipoint inspection.
Coolant leak into Cylinder 1 causing engine to overheat. Have to keep putting coolant in to drive it. Brought it to Park City Ford for evaluation. They confirmed it is coolant leaking into Cylinder 1. Engine replacement necessary to resolve issue. Called Ford customer service several times. Because it is over 60,000 miles its out of warranty and nothing can be done for me.
Coolant leak into the engine
Check engine light came on, Ford Dealership told me I need to have the engine replaced at my cost $10,000 I am the second owner and it only has 45,000 miles Please help!
Coolant intrusion . Coolant leak caused the vehicle to overheat and thus making it unable to drive . Had to tow to a repair facility and they confirmed that it’s a coolant intrusion, a common issue with Ford Escape .Engine warning light came up and there were mis fires in engine. In a week , got an engine overheat warning in the morning when I started the car .
The contact owns a 2018 Ford Escape. The contact stated that while starting the vehicle, the engine was slow to turn over, and after restarting the vehicle, the vehicle stalled. The contact stated that coolant was leaking into the engine, but there were no warning lights illuminated. The contact related the failure to the Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The vehicle was taken to an independent mechanic who confirmed the coolant intrusion into the engine. The vehicle was taken to the local dealer, who diagnosed the vehicle and verified the failure. However, it was determined that there was no warranty or recall coverage for the failure. The vehicle remained unrepaired. The manufacturer was contacted and informed the contact that a manager would respond soon. The failure mileage was approximately 88,000.
The contact owns a 2018 Ford Escape. The contact stated that while driving at 65 MPH, the steering wheel was shaking abnormally. The check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the engine and the cylinders, and the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to the Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the VIN was not included in the program. The manufacturer was notified of the failure and agreed to pay a portion of the cost for the repair. The approximate failure mileage was 96,000.
Car in shop for the 4th engine. First was coolant going into the oil-cracked block. 2nd was cracked cylinder wall- coolant leaking in to cylinder 4 now coolant leaking into the cylinder again. They can't find the leak but can see the inside there is coolant. All have been covered under warranty for now. And taken to Ford dealerships. But there has to be an issue, why it keeps happening. The service light only went on for the second engine. It was labeled as a misfire, and i had reduced engine power. So i went straight in knowing I had just gotten it replaced 3 months prior. Car bought- 40k miles 11/2021. taken in 3/2022, 6/2022 for coolant intrusion. taken in 11/2023 for thick white smoke. They told me it was just condensation. taken in 8/2025 for persistent thick white smoke, and oil/coolant build up on turbo case. Dealership is ordering a 'long block' vs the short block its been replaced with.
The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where failure persisted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined there was coolant intrusion into various cylinders, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was not notified of the failure. The failure mileage was 82,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history