COMPONENTS FAILED & AVAILABILITY:Engine and transmission failed concurrently at 45,893 miles. Engine suffered internal coolant intrusion per Ford TSB 19-2139 . Transmission failed mechanically. Components are available for inspection. SAFETY RISK:Defects create severe roadway hazards. Transmission causes dangerous lack of acceleration on inclines and highway merging, risking rear-end collisions. Coolant intrusion causes severe shaking, rough running, and sudden stalling. Sudden loss of motive power at highway speeds heavily increases crash risks. CONFIRMATION & INSPECTION:An independent service center confirmed failures on August 4, 2026. Technician documented a cylinder misfire, active coolant leak, shaking on startup, and inability to accelerate uphill. Ford corporate customer service rejected all assistance and declined to physically inspect the car. WARNING LAMPS & PRIOR SYMPTOMS:Symptoms began with an illuminated check engine warning lamp, followed immediately by severe vehicle shaking and a violent shudder during engine startup just prior to the physical diagnosis.
2018 Ford Escape engine complaints
Page 4 of 50: complaints 71 to 100 of 1,458, newest first, as owners wrote them.
I read the recent article about the recalls for the ford fusion, focus and eco sport. The exact same issue happened to my 2018 escape with about 85000 miles. The oil light and engine light came on and the car lost power. It would only go about 30 miles an hour. This occurred when my son was traveling home from college from [XXX] to [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Escape. The contact stated that while driving approximately 65 MPH, the vehicle stalled. No warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed with fuel injector failure and coolant intrusion into the engine. The mechanic determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 122,000.
Water pump, thermostat, coolant temp sensors, heater core vehicle over heats causing vehicle to smoke and make loud noise. After fixing, vehicle still cause check engine to come and vehicle is sluggish not wanting to shift gears. Indepent service center. Check engine no previous warning.
Coolant intrusion in the engine block. The engine only has 45,000 miles on it.
We brought the car in spring of 2025 for our daughter, She as driving from school and engine light came on, car was overheating and car started shaking on the freeway. She pulled the car over to check it out on the freeway, she started the vehicle back on and got the car back to her apartment and parked it. She called Expert Automotive to have them tow it to their shop to find out what happen. They check the vehicle to find coolant dripping in between block and head from the cylinders and the engine had to be replaced ( $12,127.82).
Coolant intrusion into the cylinders causing engine failure. This is a repeat of the known 1.5L EcoBoost defect. The engine was previously replaced in 2021 under TSB 21-2269. The repair order shows Ford installed the original defective open-deck short block (part number DS7Z-6009-G) instead of the updated closed-deck design. The same failure has now returned. This defect can cause sudden loss of power and overheating while driving, creating a safety risk.
I have a 2918 ford escape se with what I am now finding has a known flawed 1.5l ecoboost that ford only put a service notice out on long ago. The engine has a know issue with cylinder coolant intrusion problems. I had engine misfire and powertrain code show up and put the car into limp mode while driving at 70 on the interstate. When the limp mode started I came close to being in an accident due to sudden deceleration. I have replaced parts for the misfire and even more codes show up. The motor is now overheating and blowing white smoke when starting due to the coolant intrusion in cylinder one. Please make ford finally responsible for this issue and coverup. There needs to be a recall.
2018 Ford escape ecoboost coolant leak and engine overheating. If not repaired, will destroy the entire engine.
engine light on solid. replaced per code solenoid purge sensor. after a month light back on. Replaced per code solenoid purge sensor. Light came back on after 3 wks. Went to Ford dealership. Says coolant leaked into cylinders. Out of warranty 91,000 miles. Over 7 yrs, 84,000 miles. Need to replace engine at my expense. Seems unfair. I'm elderly and like most people these days on fixed budget.
My 2018 Ford Escape SE 1.5L EcoBoost has recently experienced catastrophic engine failure with no prior warning by any of the vehicles sensors nor a notice from the manufacturer that this is a potential/known issue. I have come to understand that this is a widely known issue that has been wholly uncommunicated by the Manufacturer. My vehicle, as confirmed by an independent service center, has experienced a coolant incursion in the engine block specifically in cylinder 3. The symptoms of this failure first occurred on the highway while traveling at speed, with the engine experiencing severe vibration and shaking the entire vehicle. This put myself and those around me at serious risk due to the vibration interfering with the operation of the vehicle. Several seconds after the physical symptoms began, the engine light flashed on momentarily (~10 seconds) without a message, and then turned itself off. Note, the engine temperature gauge did not display elevated engine temperature as would be expected from a vehicle losing coolant. Fortunately the vehicle was able to make it to its destination without injury or accident. The symptoms did not return on 2 subsequent test trips of the vehicle, again without any warning lights, messages, or elevated gauge readings. Then on a 3rd trip, after the cause was determined to be 'unknown', the symptoms returned. The engine vibration was so substantial that the vehicle was undrivable, the engine light only illuminated approximately 10 seconds after the physical symptoms and without any message. Again, the engine temperature reading or other warnings did not indicate there was any loss of coolant.
My Ford Escape recently had the check engine light on. I took it to a Ford service center, and they confirmed it was coolant intrusion that damaged the engine and requires a replacement. It was confirmed with multiple people at Ford that this is a known issue, but no recalls have been made. I use this car to drive my 2 year old son to and from daycare, and my family's safety has been put at risk by the car seizing while driving it and having to pull over to the side of the road. The vehicle is now undrivable due to the issue.
the coolant is leaking in the cylinder and white smoke coming from exaust
I have a coolant intrusion into my engine. It is a well known issue among the 2017-2019 ford escape 1.5L ecoboost engines. ford is refusing to assist me with financial assistance because it has fallen outside of their customer satisfaction program 21N12. they are punishing me for their faulty engine because i took care of my vehicle and it lasted longer than their program terms. i took it into a ford dealership who confirmed it is the exact issue explained in their TSB 22-2134, yet i am going to have to pay $8787 for a short block replacement, when had this happened a few years ago, they would have covered it for free. this NEEDS to be a recall. there have been enough people report this exact issue for cause to become a recall.
Car overheated and losing coolant. I just purchased this car on 6/22/2026 and having issues already. The check engine light is on and giving a p0301 code. I’m having to add coolant everyday to keep the car from running hot.
My 2018 Ford Escape SE temp gauge went to the red with warning lights to pull over and get engine serviced immediately. I refilled the coolant revisor and with in a few days the same instance occurred paired with misfiring while this situation happened. I immediately stopped driving the car and it is going to get dropped off at the dealership we purchased from on thursday 7/16/26. I believe this motor is faulty due to coolant intrusion. Zero leaks of coolant only issue is stated above. i believe the coolant is leaking into the cylinders.
Started overheating, spark plug code and coolant code. Now they believe coolant is leaking into cylinder in motor because of design flaw.
Vehicle showed "Engine Fault/Service Now". Drove to dealer. Told needed new engine as coolant had leaked into the third engine cyclinder. The cost would be $16,000. Research showed that Ford had had a program in place to fix this issue, but it had expired. Further research showed this was a known fault, even at the time of purchasing the car new, but that no recalls had been issued, and that there is a class action lawsuit against Ford for this problem. Have been advised to report to the federal safety agency.
Noticeable engine shudder upon startup for 2018 Ford Escape. Engine light turned on for cylinder misfire. Took to Ford dealer, and a certified technician investigated the issue as: "REPLACE ENGINE SHORT BLOCK AND TRANSFER PARTS (ENGINE LOW ON COOLANT, LEAKING INTO CYLINDER 3". This is a known manufacturing defect at this point. Ford knows these engines are defective due to a design flaw, and there's even ongoing class action lawsuits related to this exact issue for the same make/model. the federal safety agency needs to step in and force a mandatory safety recall from Ford due to the increasing reports and before this causes severe accidents.
I am writing to report a severe and dangerous manufacturing defect regarding engine coolant intrusion on my 2018 Ford Escape. Engine coolant has leaked into the engine cylinders, causing immediate engine misfires, white smoke from the exhaust, a rapid loss of coolant, and severe engine overheating.This is a well-documented manufacturing flaw in Ford's EcoBoost engine blocks (specifically involving the cylinder block design). This defect creates a critical safety hazard: the engine can stall suddenly, lose power while driving at highway speeds, or suffer complete catastrophic failure, greatly increasing the risk of an accident or an engine fire.Ford previously issued Technical Service Bulletin (TSB) 19-2346 and Customer Satisfaction Program 21N12 for this exact issue, acknowledging the design flaw. However, my vehicle is now experiencing this catastrophic failure, and the dealer is demanding thousands of dollars for a complete engine block replacement. I am requesting that the federal safety agency fully investigate this persistent safety defect to force a safety recall so affected consumers are not left driving hazardous vehicles or forced to pay for Ford's engineering failure.
Car gave an Engine Overheat warning to pull over and turn off. Towed to Ford dealership where their diagnostics pointed to coolant intrusion - a known issue with 2018 ford escapes with similar specs to mine. I was then told that I would need to replace the engine due to the issue and Ford would not be willing to assist or cover the cost. I was told that my specific VIN was not covered by recall but that it is a very common issue and to report the issue to the federal safety agency.
Car has 105k can get specific if need be. But has had an intermittent misfire along with consuming coolant since about 95k miles. It now has had coolant intrusion and needs a complete engine overhaul or replacement
I am reporting a severe safety hazard regarding a complete powertrain failure on my 2018 Ford Escape Titanium AWD equipped with the 2.0L EcoBoost engine. This vehicle experienced a catastrophic internal failure due to a known factory design defect where engine coolant intrudes directly into the cylinder bores.This defect is thoroughly documented by the manufacturer in Ford Technical Service Bulletin TSB 19-2346. The sudden loss of engine compression and immediate coolant burning causes severe engine misfires, a sudden drop in vehicle power, and blinding white exhaust smoke. This creates an immediate traffic hazard, blinding drivers behind the vehicle and risking a high-speed rear-end collision on the highway.Furthermore, the rapid loss of engine coolant puts the vehicle at risk of sudden stalling in live traffic without warning, disabling power steering and power brakes, and introducing a severe risk of under-hood engine fires due to extreme overheating.Ford has re-engineered this engine block casting for production models built after mid-2019 to resolve this exact structural defect, proving that the original factory engine block installed in my vehicle was fundamentally defective from the factory.Because this design defect creates an immediate, dangerous operational failure on public roads, I am requesting that the federal safety agency escalate this investigation and force Ford Motor Company to issue a safety recall and provide retroactive financial reimbursement to affected vehicle owners, regardless of current vehicle mileage.
The engine failed because of coolant intrusion and the cylinders are messed up because of it. The engine could have died or locked up while driving,the car could have overheated and caught fire. Yes a ford dealer diagnosed the vehicle. Yes I had a check engine light come on for a misfire in cylinder 2 I also had low coolant and white smoke in my exhaust and rough idling. Ford is refusing to help replace the engine but this is an ongoing issue with the 1.5l ecoboost engines.
The check engine light came on. It would not go above 60 mph. The vehicle was blowing hot air and shaking.
I am reporting a severe, dangerous engine design defect in my 2018 Ford Escape Titanium (2.0L EcoBoost engine). The vehicle has suffered an internal cylinder head failure, allowing engine coolant to flood directly into the cylinders (coolant intrusion). This defect has rendered the vehicle completely disabled and undrivable. Prior to complete failure, the vehicle experienced severe hesitation, white smoke from the exhaust, and sudden drops in engine power while driving, creating an immediate traffic hazard and risk of a high-speed highway stall. Ford has issued Technical Service Bulletins (TSBs) for this exact issue, acknowledging that the block design allows coolant to pool and bypass the head gasket. Furthermore, a federal court certified a class action lawsuit regarding this exact 2.0L safety hazard on June 22, 2026 (Miller v. Ford Motor Co.). Because this defect causes sudden, unpredictable engine failure and stalls during active operation, it poses an unreasonable risk to motor vehicle safety. I request that the federal safety agency escalate its investigation into Ford's 2.0L EcoBoost engines to force a mandatory safety recall.
defective engine block coolant intrusion into the cylinders engine shuts off during highway use. check engine light comes on before. i have taken it to ford dealership, it is a know defect, and they will not help with cost
My 2018 Ford Escape with the 1.5 EcoBoost has a dealer confirmed coolant intrusion failure. This is what is addressed in the 21N12 program customer satisfaction program. But my vin is not listed. But my engine has the identical engine failure. They told me I needed a new engine. I reached out to Ford and to y'all I have waited almost a year for a response. I need help please.
Coolant intrusion I now need a new engine Known problem by Ford who refuses to fix it I now owe on a car that I cannot drive
The contact owns a 2018 Ford Escape. The contact stated that upon starting the vehicle, the check engine warning light illuminated. Additionally, the contact stated that the front driver-side vent failed. The vehicle was taken to a dealer, where it was diagnosed that the engine needed to be replaced due to coolant intrusion into the cylinder. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 78,200.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history