When checking the oil, realized that there was no antifreeze in the reservoir. I went ahead and filled it to the max line, as the antifreeze didn't even come up to the minimum line of the reservoir tank. My gut was telling me that I need to every so often check the antifreeze, there was no apparent leak, there was nothing on my garage floor to indicate that there was a leak. Every time I checked the antifreeze, it was below the minimum line. I had also been noticing that my car was shifting hard. the rpms were randomly jumping higher than normal when I was maintaining a normal speed. When I go to start my car, the whole car shakes as though the engine is misfiring. When I took the car in to a mechanic, they looked it over and I was told that I needed to replace the long engine block due to a coolant intrusion into the cylinder. The car will sometimes show the check engine light and sometimes it just goes off. I had the check engine light come up before and was told after having it hooked up at Auto Zone that I just needed a tune up.
2018 Ford Escape engine complaints
Page 6 of 50: complaints 131 to 160 of 1,458, newest first, as owners wrote them.
The contact owns a 2018 Ford Escape. The contact stated that while his wife was driving on two occasions at approximately 50 MPH, the Check Engine warning light illuminated. During the second failure, there was white smoke coming from the engine compartment. The vehicle was pulled over to the side of the road each time, turned off, and restarted; however, the check engine warning light remained illuminated. The vehicle was taken to the residence. The vehicle was then taken to an independent mechanic where it was diagnosed that there was an issue with the engine block causing coolant intrusion into the engine, and that the engine block or engine needed to be replaced. The contact stated that two spark plugs were replaced; however, the failure reoccurred a month later. The vehicle was then taken to a dealer where it was diagnosed with coolant intrusion into the engine and the engine long block needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
2018 Ford Escape: engine coolant intrusion resulting in a completely failed engine. Took it to a local Ford dealership for evaluation. Confirmed this was the issued. Quoted over $14,000 to replace with a re-manufactured engine. This issue causes misfire, smoke and could catch on fire. Contacted Ford and was told while we qualify for mileage for the customer service program 21N12, it does not qualify based on expiration despite knowing this is a faulty part.
2018 Ford Escape SE 1.5L 4 cylinder EcoBoost engine. I was driving on a major 2 lane state road going 65 miles an hour when the warning light came on that the engine was overheating and pull over immediately. There was no prior warning. As soon as I stopped I looked at the temperature indicator and it returned to a normal level. I tried to drive again and got the same urgent message to stop. There was very little grass on the side of the road where I had to pull off and cars and trucks were passing us going 60-70 miles per hour. I had to call a tow truck to get the vehicle towed to the local Ford dealership. 3 hours sitting on the side of the road and did not get picked up for 3 hours in the dark. Ford ran a diagnostic test the next day and informed me in writing that the engine needed to be replaced due to coolant leakage into the engine block. I would also need the cabin coolant heater pump and the sparkplugs replaced. The total would be over $8,200. I had the vehicle in for service three months ago due to a check engine light and did the requested repair. The informed me now that it was for a different issue. Ford is not taking any responsibility for this known problem. I was the original owner and was never informed of the issue.
My 2018 Ford Escape developed a severe engine problem at fewer than 30,000 miles. The Check Engine Light illuminated and diagnostic trouble code P0302 (cylinder #2 misfire) was present. The vehicle was also losing coolant without any visible external leak, and white smoke was observed from the exhaust. The engine now misfires so severely that I do not consider the vehicle safe to operate. The vehicle has not been driven for more than 60 days because of concerns about further engine damage and safety. Due to the severity of the misfire, the vehicle cannot safely accelerate or reach normal traffic speeds. The symptoms are consistent with coolant intrusion into cylinder #2, where coolant enters the combustion chamber through an internal engine defect. The combination of coolant loss, cylinder #2 misfire, and white exhaust smoke indicates an internal engine failure rather than a routine maintenance issue. This condition occurred at under 30,000 miles and has effectively rendered the vehicle unusable. The potential for loss of power, inability to accelerate with traffic, and possible engine failure while driving creates a significant safety concern. I am submitting this complaint because I believe this may be related to a broader defect pattern involving coolant intrusion in certain Ford EcoBoost engines and because the condition creates a risk of loss of power during vehicle operation.
Engine fault warning flashed upon start for a few weeks, then check engine light came on and did not shut off. Took to shop and they said that it was leaking coolant and coolant intrusion was occurring requiring a new engine.
Coolant intrusion a known flaw in the design of the 1.5 ecoboost yet no help from ford at all. When a failure is designed into a product and sold to customers this is not ok and should be made right by Ford.
Coolant Intrusion due to a design flaw leading to coolant entering the combustion chamber causing spark plugs to prematurely fail and in extreme cases cause the engine to hydrolock and bend piston rods. Symptoms are a rough idle, MIL illumination and DTC for Misfires P0300-P0304, Coolant loss and overheating
took to a shop to replace dead battery. shop did full inspection as this shop does for me. shop found oil dripping down cv boot and thought I needed new CV boot. I advised CV boot just replaced a few years ago. They thought it was leaking from my Turbo. I advised I should still have warranties from Ford. Took to my Ford dealership I leased from in Dec 2017, and purchased in Dec 2020 and regularly brought my vehicle to. They said you need a new engine, and your warranties expired 5 months ago. My Ford had 38K miles ONLY! Called warranty # for Ford, no help, dealership wouldn't help. 38K miles on a 2018 Ford Escape and it's now JUNK! 15K for a new engine on a car that's worth 8K. Great job FORD! Never again!
In 2025 I bought this vehicle used at a dealership with 84,000 miles on it. A year later, it’s at 118,000 miles and needs a new engine. Due to coolant leaking into my cylinders and into my engine and mixing with oil and water in my oil pan. The issue it is having is directly caused my ford and the way it has designed this engine. Coolant has leaked into my cylinders causing a check engine light coming on labeled cylinder 3 misfire. I called ford about this to see if they would help, but they told me because my car is over 84,000 miles, they cannot cover the cost of repairs. I am still paying on my car loan, and in addition now, I have to pay even more to buy an engine for 5,000 dollars. This is not okay. Other have this issue as well. It is well documented online. Ford should recall this issue.
Car started losing coolant and engine overheating on highway. Ford knows about this issue with coolant leaking into engine block but fails to mention to current owners. We have to figure it out ourselves once the engine is destroyed and damage is done and the expensive fix is in. This is dangerous!
Driving on highway, suddenly starts chugging and stalling, blowing white smoke and engine light comes on. On side of road won't restart. Ford dealer confirmed it was coolant intrusion from a known engine faulty design, dealer said Ford did not cover all VINS that this effected, (which mine was one) even though it met the other criteria. Has only been inspected and confirmed at Ford repair center. Engine lights on at same time engine began mis-firing during drive. No previous warnings or issues with the car.
Engine running rough on start; found coolant intrusion in cylinder 3; necessary to replace long block assembly
Coolant breach in engine block, Cylinder 3. Causing misfire and engine fault. TSB 22-2322
1.5 L eco boost engine FORD- COOLANT INTRUSION, cylinder 3 misfire, check engine light at 59,800 miles - known defect by Ford- needs new engine. Some models recalled but not this one (?? Why??). Cannot safely drive this vehicle. Problem diagnosed by dealer[ as well as by independent garage] and dealer acknowledged a recall should be done but they cannot help except to replace the engine at my expense. So many others having the same issue! Can you please help us get Ford to take responsibility for selling us vehicles with defective engines? Please?? Thank you for your attention to this urgent matter.
I purchased this vehicle used in 2024, and since I bought it have had a variety of issues. I have already invested over 5k in repairs. I have replaced the head gasket and now the water pump twice. This vehicle will not stop overheating. Ford has a known issue with these engines and should correct these issues. They are making working families go broke and we still owed 8k on the car loan.
Coolant intrusion in the engine which needs replacement. Car was misfiring and white smoke coming out took the auto shop for service. Its about $9400 to fix the car which is now more than the car is worth. Dealership never warned me that this was a potential issue.
The contact owns a 2018 Ford Escape. The contact stated while driving 35 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to an independent mechanic where it was diagnosed that the coolant had leaked into cylinder two and engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure, and they offered no assistance. The approximate failure mileage was 48,000.
2018 Ford Escape 105K miles. Check engine light came on, car ran rough, white smoke coming out of tail pipe. I took it to a third party mechanic, they ruled out coolant intrusion (or so they said) replaced a coil and spark plug and cleared check engine light. One week later after I had driven maybe 100 miles it had a very rough start in the morning and the check engine light came on again. I noticed white smoke coming out of the tail pipe. I had it towed back to the mechanic that first worked on it. They found coolant intrusion. This creates a safety concern because the vehicle can misfire, overheat, lose power, enter limp mode, or stall while driving, including at highway speeds or in traffic. A sudden loss of engine power could prevent me from accelerating, merging, clearing an intersection, or safely pulling off the roadway. Ford has acknowledged coolant intrusion on certain 2017–2019 Escape 1.5L engines through Customer Satisfaction Program 21N12, which provided short-block repair coverage for coolant intrusion, but my vehicle is now outside coverage and requires an engine replacement. Up to this point Ford has refused to provide any assistance.
Componet System that Failed: Engine and engine cooling Complaint Description:The vehicle experienced a sudden internal engine failure due to a manufacturer design defect causing coolant intrusion into the engine cylinders. A professional mechanic diagnosed the issue with Diagnostic Trouble Code (DTC) P0303, confirming a Cylinder 3 misfire caused by coolant leaking into the block. The vehicle requires a total engine replacement at just 48,406 miles. This internal coolant leak poses a severe safety hazard, including sudden engine stalling, loss of motive power while driving, and potential thermal runaway/engine fire risks. The vehicle is currently rendered unsafe to drive and is parked at my residence.
Check engine light came on and took to shop and determined that coolant intrusion in cylinder #2 this was a recall on other 2018 Ford Escape but not this VIN number.
I have not even had this car for a year spent 10,000 on it it had less than 100,000 miles sounded great no noises or engine lights first it was the canister purge valve issue even tho I got the oil changed and everything wen I first got this car I have a work car so I literally bearly drive this car then the transmission went out less than a year into owning it it needs rotors In the front n mind u I paid cash so I can’t even complain to them can’t believe there are no recalls on this model im literally starting a facebook group about this car just to see how many ppl had this problem so far every person that had problems with this model transmission went out or both had my 2010 Kia for 12 years this car is a 2018 this is ridiculous
The contact owns a 2018 Ford Escape. The contact stated that while driving the vehicle misfiring, white some, hesitation. The engine light illuminated. antifreeze leaking into the cylinder. The vehicle was taken to an independent mechanic where the diagnostic code P0300 was read and an antifreeze leak into the cylinder and a design flaw in the Eco boost. The manufacturer was not notified of the issue. The approximate mileage was unavailable.
The contact's wife owns a 2018 Ford Escape. The contact stated that while driving at various speeds, water would intrude into the engine compartment and the vehicle would independently shift into Limp Mode. The check engine warning light illuminated. The vehicle was taken to a local independent mechanic, where the ignition coils and spark plugs were replaced at the consumer's expense; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed with water intrusion into the engine. The vehicle was not repaired due to the costs. Upon further investigation, the contact related the failure to Ford's Customer Satisfaction Program: 21N12; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.
Engine coolant intrusion. Known issue with these cars apparently that Ford needs to step up and fix/replace their design flaw. The fact car dealerships sell these ticking time bombs to unknowing customers is ridiculous.
I was driving doing errands when suddenly a warning popped up that my engine needed to shut down for cooling. I pulled over and shut down. After about 30 minutes, I started up again and the engine ran very rough and after a short distance, warned again. I took the vehicle to the shop and was told there was an engine defect known to ford causing coolant intrusion into the cylinders. Because my vehicle was out of warranty, I had to pay the entire repair out of pocket ($7500), plus be without my vehicle for about 2 weeks. After, doing some research, I learned that had the incident happened 6 months sooner, the repair would have been covered in full by a CSR. I would like to know if there is anything that can be done to reimburse my expenses regarding this repair.
Bought the vehicle used and two months later engine and transmission needed replacement after several transmission faults and check engine light stayed on due to coolant intrusion in the cylinders and the known transmission defects in this model.
Car exhibited white smoke, overheated and engine stopped. Left me stranded in middle of extremely busy road, 90° temps and I’m [XXX] with no one to help me. I had car towed to Autonation (Ford Dealership, Jacksonville, Fl, where car was purchased in 2022 and Dealership was aware of defect but failed to divulge at time of sale. Autonation has confirmed Coolant Intrusion EcoBoost engine defect, they deny any responsibility quoting a cost of $11,000 to have Ford correct their defect; I do not have this kind of money. No early warning INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Escape. The contact stated that after driving her vehicle, she notices that her coolant levels drain very quickly, causing her to fill up after every trip, and stated her vehicle was overheating at times. The vehicle was taken to a independent mechanic where it was diagnosed to have coolant leaking into cylinder two, needing a new engine replacement. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 119,000.
3rd cylinder coolant intrusion and blown head gasket diagnosis. Car needs new engine.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history