My vehicle has to have a new motor. It only has 127,154 miles on it. I have sent Ford a letter to respond with in 30 days and they have not done that. Please advise the next steps.
2019 Ford Escape engine complaints
Page 2 of 14: complaints 11 to 40 of 399, newest first, as owners wrote them.
My 2019 Ford Escape Se was smoking during start up. Dealer says it needs a whole new engine due to coolant intrusion. I have been seeing there are many issues with this.
I am reporting a potential safety defect involving the 1.5L EcoBoost engine in my 2019 Ford Escape, which has approximately 39,000 miles. Beginning in August 2026, the vehicle developed repeated check-engine lights, misfires, and severe shaking while driving. Ignition coils and a spark plug were replaced, but the problems continued. The vehicle then began displaying overheating warnings and repeatedly losing coolant. On one occasion, the coolant reservoir was found completely empty. Coolant was added, but the overheating continued. On September 3, 2026, the thermostat assembly and temperature sensor were replaced. On September 5, after about 15 minutes of driving, the vehicle began smoking and overheating. After it cooled, the coolant reservoir was again empty. Coolant was added, but the vehicle continued to overheat. I scheduled a Ford dealer diagnostic appointment for September 23 because I believed something was seriously wrong, but the vehicle was not diagnosed because the check-engine light was not illuminated at that time. The engine later suffered a major failure. An independent repair shop performed compression testing and reported extremely low readings of approximately 20-40 PSI on the cylinders tested, indicating severe internal engine damage. Ford has previously documented coolant intrusion on certain 2017-2019 Escape 1.5L EcoBoost engines, with symptoms including coolant loss, smoke, rough running/misfires, and possible engine damage. Ford confirmed that Customer Satisfaction Program 19B37 was completed on my vehicle in 2020, but says my VIN was not included in 21N12. Coolant intrusion has not yet been conclusively diagnosed, but the failure pattern is concerning and occurred at only about 39,000 miles. I am asking the federal safety agency to review this complaint for a possible safety-related defect trend.
The check engine light has repeatedly came on and been brought to the mechanics numerous times throughout the year. It was determined that the cause of issue is due to engine coolant leaking into the engine.
I am reporting a dangerous manufacturing defect regarding internal engine coolant intrusion on my 2019 Ford Escape SEL at less than 70,000 miles. Upon starting the vehicle after it sat parked overnight, a massive cloud of heavy white smoke erupted from the exhaust system and both sides of the vehicle, clearing after 1–2 minutes. The vehicle also exhibits a severe structural shudder and a mechanical groaning noise when shifting gears due to engine misfires caused by this leak. A physical inspection confirmed that the engine cooling system is losing fluid (which was just topped off again last night), which is leaking directly into the combustion cylinders overnight. This is a well-documented factory design flaw involving the engine block casting on Ford EcoBoost engines (referenced in Ford Customer Satisfaction Program 21N12 and multiple Technical Service Bulletins). Ford Corporate and local dealerships have refused to assist with repairs because my specific VIN was excluded from their limited voluntary campaign parameters. This defect presents an immediate, severe safety risk to myself and others, as internal coolant leaks cause sudden cylinder misfires, severe engine shuddering, engine stalling without warning in traffic, and the sudden eruption of heavy white exhaust smoke blinds drivers driving behind my car...not to mention catastrophic engine failure. Ford should be forced to issue a mandatory safety recall for all affected model years regardless of VIN exclusion lists.
The contact owns a 2019 Ford Escape. The contact stated that while depressing the accelerator, the vehicle hesitated and was idling rough. During initial start-up there was a backfire coming from the engine with white smoke coming from the exhaust pipe. The maintenance warning light was illuminated. The vehicle was taken to a certified mechanic and DTC: P0302 was retrieved. The cylinder was replaced. The contact stated that approximately 2 weeks later, the failure reoccurred. The vehicle was taken to the dealer and DTC: P0302 (Cylinder #2 misfire); was retrieved. The manufacturer was informed of the issue, and a case was opened. The failure mileage was 53,967.
The contact owns a 2019 Ford Escape. The contact stated that at cold starts, the vehicle vibrated significantly with heavy white smoke coming from the exhaust. The check engine light was intermittently illuminated, accompanied by a noticeable coolant odor. A diagnostic test by the dealer confirmed that there was coolant leaking between cylinders #1 and #2, leading to total engine failure. The vehicle remained with the dealer unrepaired. The dealer submitted a goodwill request to the manufacturer for the repair. The failure mileage was approximately 43,800.
Vehicle has coolant intrusion into cylinders verified by Ford dealer
The contact owns a 2019 Ford Escape. The contact stated that while driving 20 MPH, the vehicle was shaking and vibrating abnormally. The check engine warning light remained illuminated with the message "Engine Overheating - Pull Over Immediately" displayed. The vehicle was taken to a local dealer, where it was diagnosed with engine failure due to coolant intrusion. The manufacturer was notified of the failure. The failure mileage was 85,818.
We purchased a 2019 Ford Escape 1.5L new from the dealer. We've put only 25,000 miles on it, but are now facing a well known issue (coolant intrusion) that they failed to inform us about. This is despite our vehicle meeting literally every requirement to be included in their Customer Service Program, they told us it is not tied to our VIN and are out of luck. Our car is now worthless. If we had been notified we would have taken the necessary precautions. Again, this is a known issue, with a current Class Action lawsuit in place, that Ford failed to notify us of. We are now out tens of thousands of dollars in replacing a car we have barely driven.
The vehicle had a transmission shutter and shakes the car. It also had a hard shift at 38mph. It happens daily, was not a one time Incentent
Slow coolant leak that is a known issue with engine. This caused the water pump to go bad and engine to risk overheating. Has been looked at by 3 independent mechanics all confirmed this is a known issue causing major concerns. No warning! Just suddenly lost all coolant! No engine needs replaced!
I recently bought a 2019 Ford Escape from Superior Mazda in Bentonville, Arkansas for my daughter going off to college. Soon after purchasing the vehicle a giant puff of smoke started coming out the exhaust when starting. We took it to a Ford dealership and they said the coolant is leaking into the engine block and apparently this is a known issue with 2017-2019 ford escapes. Superior Mazda said it's not their problem. The cost to fix is $12,700. We've only had this car for 38 days. Ford has issued 2 statements about this defect in these cars: Ford issued TSB 19-2375 for 2017–2019 Escapes with the 1.5L EcoBoost. It specifically says coolant can intrude into the cylinders and calls for short-block and head-gasket replacement when the condition is confirmed. There is also Ford Customer Satisfaction Program 21N12, titled “Short Block Replacement After Coolant Intrusion.” Why is this not a recall? I have since read/heard that this is an issue all over. I spoke to a mechanic in my town and they stated they currently have a 2017 escape that they are working on with this exact problem. An investigation needs to made into Ford regarding 2017-2019 Ford Escapes. Since this is a known defect and Ford is well aware of this engine flaw in this model car they need to do the right thing and issue a recall. My daughter could have been stranded on the highway heading to college.
The transmission had to be replaced in 2024 and now the engine needs to be replaced in 2026. Ford customer service will not help with any of the repairs.
The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact connected a portable diagnostic tester to the vehicle and retrieved DTC: P0301 displayed. In addition, the check engine warning light flashed on and off. The vehicle was taken to an independent mechanic. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact referenced Customer Satisfaction Program: 21N12; however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to proceed with the repair and wait for approval of the VIN to be added to the Customer Satisfaction Program: 21N12. The failure mileage was approximately 64,000.
Vehicle was losing coolant, running rough and check engine light was on. We took it to a Ford dealer who told us: Stored Codes P1299 and P0302 for the cylinder 2 misfire due to the coolant intrusion in the cylinder. The fix is to replace the entire engine at a cost of $15,735.95!! This is a 2019 Ford Escape. We've owned it for six years. We had planned on keeping it another six years, at least. A car should not need an engine replacement within six years. We're retired, living on social security and a very small pension. We can't afford a $15,000 repair. On top of a diagnostic fee of $435 and close to $500 to rent a car (so far.) We contacted Ford and they said there was nothing they could do for us.
Vehicle began losing engine coolant. No external leaks visible. Took to Ford dealership for inspection and diagnostics. They found coolant intrusion in cylinders 1 and 2. They say that TSB 22-2322 applies to this issue. Vehicle has 86,896 miles and warranty started on February 16, 2019.
We bought the 2019 Ford escape sel in 2023 with 29918. We had the oil changed at 33000 and then we took it to Ford because it was slow starting. Their was coolant in the cylinders requiring us to pay 12000 dollars for a new engine when this only had 36000 miles on it. Ford refused goodwill case and now we acquired an attorney. This is a known engine problem with this Ford. Class action lawsuit Miller vs Ford motor company. Never heard of an engine failure with only 36000 miles.
When I originally attempted to start the car, white smoke was pouring from the exhaust pipe. We came to the conclusion that my head gasket on the car blew. We came to this conclusion because it was misfiring and when you try to open the coolant lid there’s suction.
Ford Coolant Leak & Engine Overheating Engine overheating caused by an internal engine coolant leak in Ford Ecoboost engines Coolant leak that allows coolant to enter into the cylinders of the engine. This caused total engine failure and to require replacement of the engine block.
Bad engine reports on 2019 Escape. Engine light problems beginning at 56k. I understand Ford has had many complaints about this engine. New water pump at 56k, new purge valve at 58k.
The contact owns a 2019 Ford Escape. The contact received notification of the federal safety agency Campaign Number: 26V011000 (Equipment); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated while driving. Upon inspection, the contact's husband became aware that the coolant level was abnormally low. Additionally, a diagnostic scan retrieved Diagnostic Trouble Code: P0302; indicating a misfire in cylinder #2. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 95,000.
Our 2019 Ford Escape began shaking upon starting the vehicle. We took it in for diagnostics to the Ford Dealership. This car has less than 40k miles on it after 7 years of ownership. We were told we would need to completely replace the engine due to a coolant leak. Upon further research, a recall for our exact make and model was identified that described the exact same issue that was identified by Ford. For some reason, our VIN was NOT eligible for the OASIS program that was offered to other FORD owners with the EXACT same problem. The dealership has not been helpful at all in putting me in contact with a Ford Representative that can tell me WHY my particular vehicle did not qualify for the assistance program. After contacting Ford corporate (or tried several times to get someone on the phone instead of a automatic prompt system) I was told that they would send my complaint to the Auto Safety Office BUT they could NOT guarantee I would receive a call back. NOW, the Ford dealership is saying that we have been DENIED assistance and that our case is with the Auto Safety Office and they will not be able to provide an update about our complaint. During this time, the dealership provided us with a loaner vehicle while trying to address the issue. They are now demanding that we return the loaner vehicle. This is also the dealership that services the 2019 Ford Escape in question. It was recalled previously for improper bushings which we complied with the recall and had it repaired accordingly. For an American made vehicle with less than 40k miles this is incredibly disappointing that Ford is unwilling to assist in the complete and total engine replacement that is being offered to others with the EXACT SAME issues that FORD identified. I have purchased 3 Ford vehicles from 2017-2019 and this will be the last. Customer service has been piss poor even when I was able to get someone on the phone. I do not feel safe driving the car after the issue was identified.
Was driving and a loud pop happened when pulling onto the hwy and lost power. Immediately pulled into parking lot and tried to restart but would not start. My son came over that evening and towed back to my house and the discovered the oil pan was cracked along with block and piston shattered. There are parts inside the oil pan. This has not been inspected by a dealer or service center. No warning or check engine lights came on indicating a problem. My build date is June of 2019 and the tsb is for May of 2019, indicating that this engine still had a coolant problem as there was no coolant left and had all came out in the pan with the oil. I am asking for assistance in getting this covered . Please let me know what steps can be taken. Thanks
Defect in engine block causing coolant intrusion.
Ford only showed one code P0403 tuneup with a written statement I asked for wanting 15k for a new engine and verbal;y stating I need a whole new engine. The 2019 Ford escape began to smoke heavily while driving. I put over had the car towed to Ford dealer in sandy springs. As Ford is stating that this car needs a new engine the old recall existed from years ago has expired on the VIN number 2022. Just because I made a purchase from 2024 doesn't mean the the issues have been resolved and you should be aware and know about the mechanical issues and list them remained as a recall. The 2020 model also shows major concerns in fact from 2012 to 2020 models Ford escape complaints are listed on your website repetitive recall mechanical issues unfixed or part not available should be all listed as a recalls safety of drivers. Some referred to as problematics when driving but other diagnostics showed engine transmission, now showing on Ford website is Block heater element replacement, Powertrain control module reprograming and Transmission shifter cable bushing
I was driving my Escape, and the vehicle quit acceleratoring. I had to have vehicle towed to a shop. I was informed that I need a new engine. The Escape only has 78,000 miles on it. I am being quoted $8,000.00. This was an unsafe situation for both myself, and my 20 year old autistic so who was with me.
car suddenly overheated leaving myself and two children stranded on the interstate. it's a confirmed cylinder 3 coolant intrusion that is a well known documented issue. diagnosed and confirmed by the dealership. I was unaware of this issue, I thought buying a certified pre owned car meant it was in perfect shape, not a ticking time bomb.
Flywheel cracked. There is a service bulletin on how to fix when there is an issue which to me indicates a known issue.
The engine block and cylinder head assembly failed due to a manufacturing design flaw that causes engine coolant to intrude into the cylinder bores. This defect was officially reproduced, tested, and confirmed by factory-certified technicians at AutoNation Ford Katy in Katy, Texas. The vehicle is currently parked at my residence and is fully available for inspection upon request. Prior to the failure, the vehicle exhibited a glowing Check Engine Light on the dashboard, low coolant levels, and rough engine idling upon startup, which first appeared immediately prior to the formal dealership diagnosis at 81,085 miles. Coolant intrusion into the combustion chambers causes sudden engine misfires, severe overheating, and white smoke emission. This defect risks a sudden, unpredictable loss of motive power while driving at highway speeds, creating a severe, immediate collision hazard for myself and other motorists on the road.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history