2019 Ford Escape lights problems

Filed Dec 22, 2025 · Lights · OH

To Whom It May Concern, I am submitting this complaint to report a design defect affecting serviceability and safety on my 2019 Ford Escape. On this vehicle, replacement of a standard headlight bulb requires removal of the fender assembly in order to access the headlight housing. This design transforms a routine, safety-critical maintenance item into an excessively complex and costly repair. I have had to replace a headlight twice within the past two years. The most recent replacement cost approximately $800, with the majority of the cost attributable to labor required solely because of the vehicle’s design, not due to damage or abnormal conditions. The headlight bulb itself represents only a small portion of the total cost. Headlights are a required safety component that must be replaced periodically. A design that makes replacement prohibitively expensive discourages timely maintenance and may result in vehicles being operated with failed lighting, creating a potential safety risk. I believe this represents a failure to design for serviceability and places an unreasonable maintenance burden on consumers for a basic safety function. I respectfully request that the federal safety agency review this design as a potential defect. Thank you for your attention to this matter.

Filed Dec 16, 2025 · Electrical, Engine · CA · crash

he freeway I notified future ford of concord and I was told I would receive a call back but as I recall I didn’t receive a call back. The car started acting as if nothing was wrong about a week or so later then two days ago December 13,2025 first my head lights went out and a message saying there’s a bulb outage or electrical issue appeared and also the hill assist unavailable warning light appeared , following the 911 calling assistance is unavailable as well, and I also noticed my radio is no longer producing sound so I believe the engine ( block , head gasket etc) component also electrical system, sync 3 system has also failed or malfunctioned. During the second occurrence I was driving as I was before which led to The safety of my children, my husband and myself put at risk being it was night time and I could no longer see the road the car acted as if it was turning off and slowing down.. yes there was warning lamps, messages or other symptoms of the problem during the failures, and they first appeared at the exact time of the failures . Also below are photos captured from the ford vehicle app alerting me about issues for the car

Filed Mar 30, 2025 · Lights · WI

Simply put, the headlights repeatedly blow out with no apparent reason found. Bulbs have been changed multiple times personally and by professionals -- both headlights went out nearly simultaneously in September of 2024 and I replaced the bulbs myself, assuming it was a fluke or the bulbs had simply aged out. At the beginning of March, 2025, the passenger-side bulb went out again and I brought it to my dealership to get checked out. They couldn't find anything wrong, and I had them replace the bulb again. Now, for the third time since I bought the vehicle in April or May of 2024, I have to replace the passenger-side bulb again. I'm returning to the dealership to see if there's anything else to look for, but a quick internet search shows that there are lots of others experiencing this same problem without any kind of solution in sight. This is obviously not normal.

Filed Feb 25, 2025 · Lights · AL

There is something wrong with either the bcm, headlight assembly, or headlight wiring harnesses. My low beam headlight bulbs only last about 6 months and then they go bad. I have tried using OEM bulbs, sylanvia bulbs, and led bulbs and have the same result = replacing within 6 months! This causes a severe safety issue as I lose visibility from a headlight. This issue is well documented all over the Internet and no one has been able to find any answers, except for a couple people being able to just use OEM bulbs and replace yearly.

Filed Dec 11, 2024 · Lights · NY

I have a 2019 Ford escape. I’ve replaced the lightbulbs on both sides several times. The housing has burned out several times not just the bulbs. Twice they have burned out at the same time. The 2019 and the 2017 have the same light fixtures. The 2017 headlights were recalled. I contend that my car should be covered under the recall. I’ve called two local Ford dealers both are familiar with my problem and have told me there’s recall “yet”.

Filed Jul 19, 2024 · Lights · 70,000 miles · MO

The contact's brother owns a 2019 Ford Escape. The contact stated while driving 70 MPH at night, the headlights became inoperable. There was no warning light illuminated. The contact stated that the headlight module failed to operate as needed and the contact was forced to drive to the residence without headlights. The contact had taken the vehicle to a dealer on three separate occasions to be repaired. On the first visit, the dealer replaced the battery and the headlight bulbs. The second visit, the dealer replaced the BCM (Body Control Module) and two other light bulbs that were not initially replaced. On the third visit, the headlight switch was replaced. Despite each repair, the headlight failure persisted. The contact was recently informed by the dealer that the wiring harness needed to be replaced; however, the dealer could not guarantee that the repair would fix the headlight failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000. The VIN was not available.

Filed Mar 2, 2024 · Lights · 108,965 miles · AL

Low beam headlight bulbs keep burning out, literally replacing bulbs at least once a year

Filed Nov 30, 2022 · Electrical, Lights · NY

Vehicle has 32K miles on it and both low beam headlight bulbs failed at the exact same time. My daughter had just left her house and as soon as she got away from street lights she realized this. The odd part is that the in-dash indicators showed everything working normally with NO FAULTS, so we assumed it was an electrical issue. We got it to a Ford dealer (she has an extended warranty), and they "fixed a connection that had corroded, causing both bulbs to fail." NOT covered under warranty, $250 to replace two bulbs and clean sockets. There are numerous Ford forums with the same complaints. Just felt that you folks should be made aware...

Filed Mar 26, 2022 · Lights · MI

2019 Ford Escape SEL. Left and right front headlamps simultaneously stopped working during nighttime freeway driving. Dangerous safety issue. Dashboard headlamp green symbol continued to display headlamps were functioning properly. There was no warning symbol. Vehicle electrical issue was repaired at dealership at no charge. I am aware of an identical problem occurring on a similar 2019 Ford Escape SEL. My belief is the headlamp failure is not a random issue and is a serious safety defect that has not been addressed by Ford Motor Company.

Filed Mar 26, 2022 · Lights · MI

2019 Ford Escape SEL. Left and right front headlamps simultaneously stopped working during nighttime driving. Dangerous safety issue. Dashboard headlamp green symbol continued to display headlamps were functioning properly. There was no warning symbol. Vehicle electrical issue was repaired at dealership at no charge. I am aware of an identical problem occurring on a similar 2019 Ford Escape SEL. My belief is the headlamp failure is not a random issue and is a serious safety defect that has not been addressed by Ford Motor Company.