1991 Ford Escort fuel system problems

Filed Oct 30, 2009 · Fuel system · 151,000 miles · MN · fire

Tl* the contact owns a 1991 ford escort. Fatigue cracks have developed in the solder joint between the fuel return tube and the fuel pump sending unit located at the top of the fuel tank. There must have been an internal fire caused by the failure, because the wiring harness had melted. The vehicle identification number was excluded from recall # 92v117000 (fuel system, gasoline). The manufacturer and the dealer was notified, but no assistance was provided. No repairs were made. The failure and current mileages were 151000.

Filed Aug 11, 2008 · Fuel system · 83,000 miles · MS

1. My 1991 ford escort lx station wagon developed a fuel leak around the fuel tank. 2. It occurs every time I add fuel to the tank. 3. I reported the problem to ford, including the existence of a recall notice (the federal safety agency action number ea92012; the federal safety agency campaign id number: 92v117000)). Ford has ignored the recall letter, claiming there is no such recall letter, and ... In general giving me the runaround. Frankly, I'm mad as '!@#$%. This problem is a fire hazard, and ford is refusing to address it!!!!! What can I do?? Thanks! Kes

Filed Nov 21, 2005 · Fuel system · 133,000 miles · CO

Dt: the contact states there is a the federal safety agency recall campaign 92v117000 concerning fuel pump sending assembly. This consumer is experiencing the same problems as indicated in the recall, but is not included in the recall due to VIN. The contact repaired the vehicle at his own expense. *ak updatd 01/25/06.

Filed Jun 25, 2003 · Electrical, Fuel system · 132,000 miles · MO

Consumer states that the wiring assembly to the fuel pump has burned up 3x in the last month. Dealer diagnosed problem as incorrect specified 30amp fuse for fuel pump.

Filed Jun 3, 2003 · Fuel system · IN

Vehicle was having the same problem as mentioned in recall#92v17000 concerning fuel tank. Dealer will not repair vehicle because it is not covered under recall due to VIN.

Filed Nov 14, 2002 · Fuel system · 210,100 miles · OK

Consumer noticed fuel on the ground, the vehicle was taken to a mechanic, and it was discovered that gas had leaked out of the fuel line which connected to the tank. Please provide any further information. The fuel tank and pump was replaced.

Filed Jul 15, 2002 · Fuel system · PA

While driving the smell of gas is very strong.*ak consumer stated that the smell gets stronger when car was accelerating.

Filed Dec 11, 2001 · Electrical, Fuel system · MN

No summary listed for abov evehicle.

Filed Nov 12, 2001 · Fuel system, Lights · CO

Seatbelts: the motorized seat belt stick in the track, usually half way between open & close. Now they will not operate at all. I took one apart & the plastic covering the cable is deteriorating & causing the cable to stick. This is a safety issue that needs your attention immediately. You can have my seatbelt assemble for inspection, as I will have to purchase a new one for my spouse's safety. Fuel: this car was not covered under the recall #92s54, as the produduction date was too early, but it has the identical problem. I have already corrected this problem with a new fuel pump assembly. You may have access to this part for your inspection as well. Last but not least: headlight: cloudy, yellow, and do not allow light on the road. Very hazardous. I have noticed this is typical on a lot of different ford cars & trucks. I have purchased a set from the local wrecking yard, but do not have the headlight for you to inspect. I threw them away.

Filed Aug 16, 2001 · Fuel system · AZ

After filling fuel tank had noticed a fuel smell inside vehicle. Also, after driving for while could still smell fuel. Decided to check under vehicle, and found a fuel leak in tank that showed a crack above muffler. Consumer contacted dealer. Please provide more information.