Recall 92v117000 concerning fuel pump failure. Anytime the consumer gets into the vehicle there is a strong odor of gasoline. Consumer is not sure if her vehicle is included in the recall.
1992 Ford Escort: fuel pump failure
9 of the 162 complaints about the 1992 Ford Escort describe fuel pump failure.
- owner complaints
- 9
- of this car's complaints
- 6%
- recalls
- 1
Is there a fix? There is 1 recall for this area of the car. See below
Fuel pump failure by model year
What owners say
Fuel is leaking from the top of the tank, the consumer can smell fuel inside the vehicle and the consumer noticed a puddle of fuel on the ground when exiting the vehicle, this problem only occurs when the rear tank is full, the manufacturer has been contacted. Nlm there is a recall 92v117000 to replace fuel pump sending unit. Consumer replaced 4/7/1994.
Cracks in joint between the fuel return and fuel pump sending unit. Leaks gas. Possible fire hazard.
Fuel tank and fuel pump are leaking fuel due to cracks. Please give any further details.
Gas guage on the dash console did not work, and vehicle would not start. The fuse to the guage blew out, causing the fuel pump to go bad. Dealer has been contacted.
I am reporting on a prior recall that "supposedly" did not affect my car. The federal safety agency campaign id # 92v117000. I had been having a fuel leak around the tank area for awhile and could not figure out where it was coming from. It would only do it when the tank was full or 3/4 full. I then came across recall # 92s54 which described my problem. I took my car into a ford garage and they told me that my VIN # was not included in the recall. I then called the ford home office and was told that since my car wasn't included, that there was nothing wrong with my car. I examined the codes on the fuel pump and verified that it was indeed the defective one. I then replaced the assy (which cured the problem). I viewed the old one (which I still have) confirmed that there was a crack in the solder joint between the fuel pump mounting plate and the fuel return tube. I then registered a complain by phone to your office and was told that I would receive a copy of my complaint by mail in approx. Two weeks. It's been about two months and I haven't received anything. I would appriciate a response. Thank you.
Owner was never notified of recalls concerning the offset toe adjusting pin or the fuel pump sending assembly.
Fuel tank and fuel pump failed causing fumes.
Heat gauge over gasket deteriorated on fuel pump. Causing leakage under back seat, eating coating off wiring and shorted out.
Related recalls
Fuel system, gasoline
- What is wrong
- Fatigue cracks can develop in the solder joint between the fuel return tube and the fuel pump sending unit located at the top of the fuel tank.
- Risk
- Should a crack develop, fuel vapor can escape from thetank when the tank is full, and a small amount of fuel can leak from the crack.fuel leaks can result in fire when exposed to a source of ignition.
- Remedy
- Install a new fuel pump sending assembly.
Recall number 92V117000 · Recall details
Questions about the 1992 Ford Escort fuel pump
Is fuel pump failure a common problem on the 1992 Ford Escort?
9 of 162 owner complaints about the 1992 Ford Escort (6%) mention fuel pump failure. The model year with the most reports is 1991.
Is there a recall or service bulletin for this on the 1992 Ford Escort?
There is 1 recall and 0 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 1992 Ford Escort
Seat belt 10Fuel leak 9Fire or smoke 6Fuel smell 5Stalling 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 1992 Ford Escort?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history