2004 Ford Excursion: engine stalls while driving

Filed May 2, 2019 · Electrical, Engine · 59,000 miles · CA

Tl* the contact owns a 2004 ford excursion. While driving, the vehicle stalled without warning. The contact placed the gear into neutral, while in traffic, and restarted the vehicle. Afterwards, the vehicle was able to drive normally. The vehicle was taken to future ford lincoln (located at 650 automall dr, roseville, ca 95661, (888) 656-7577) where a wiggle test was performed because a failure code could not be found. The injection control pressure was replaced with a used part. The contact stated that the vehicle was worse after the replacement of the used part and the steering wheel became difficult to steer. The vehicle was taken back to the same dealer who stated that a wire harness was needed to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the federal safety agency campaign number: 05v270000 (electrical system). The approximate failure mileage was 59,000.

Filed Apr 9, 2014 · Fuel system, Visibility · 94,000 miles · NV

Tl* the contact owns a 2004 ford excursion. The contact stated while driving approximately 60 MPH the engine stalled without prior warning. The engine was able to be restarted after ten minutes and resumed normally, however all of the power windows failed to operate. The failure recurred twice. The vehicle was taken to an independent mechanic where the fuel injection control module was replaced. The manufacturer was notified of the problem. The approximate failure mileage was 94,000. Updated 6/24/14*cn updated 06/26/2014

Filed Jun 27, 2013 · Steering · 80,000 miles · FL

Tl* the contact owns a 2004 ford excursion. The contact stated that while driving approximately 40 MPH, the engine stalled without warning and failed to restart. The steering wheel was turned and a loud pop was heard. The vehicle was towed to an independent mechanic, who informed the contact that a component of the steering box was fractured. The vehicle was scheduled for repairs. The manufacturer was notified of the problem. The approximate failure mileage was 80,000.

Filed Mar 4, 2013 · Electrical, Engine · 101,000 miles · IN

While driving the vehicle, it will go into a reduce power mode or sometimes stall. This has happened at various speeds, from around town to highway driving. Very dangerous condition when trying to make left turns and power is lost or engine stalls. Also engine fails to start or starts and stalls right away on occasion. Call ford customer relations and dealer and they tell me my VIN is not covered under the recall. I am experiencing the same symptoms but I am not covered. Don't want to spend more money at dealer if they don't know what is happening and how to fix it.

Filed Feb 7, 2013 · Engine · 89,000 miles · CA

Tl* the contact owns a 2004 ford excursion. The contact stated that while driving approximately 30 to 45 MPH, the vehicle stalled without any warning. The vehicle was later towed to a dealer. After diagnosis, the contact was informed that the problem may be the fuse near the transmission. The vehicle was repaired. Approximately three months later, the failure recurred. The vehicle was taken back to the dealer. After diagnosis, they advised her that the fuse failed again due to the bracket chafing the wires. The vehicle was repaired. The manufacturer was contacted and they offered no assistance. The failure mileage was approximately 89,000. The current mileage was approximately 90,000. The VIN was unavailable.

Filed Jun 9, 2011 · Electrical · 97,000 miles · OR

Tl*the contact owns a 2004 ford excursion. The contact was driving approximately 25 MPH, the engine stalled without any warning lights illuminating on the instrument panel. The engine restarted momentarily and the vehicle resumed as normal. The vehicle was taken to an authorized dealer and diagnosed. The failure was related to the injection control sensor. There was a recall related to the defect under the federal safety agency campaign id number 05v270000 (electrical system: wiring). The VIN was not included in the recall. The vehicle was currently being repaired. The manufacturer was made aware that the failure occurred intermittently. The failure mileage was 97,000. The VIN was unavailable. Updated 09/07/2011 *ln

Filed Aug 4, 2010 · Engine · 100,000 miles · CA

Tl* the contact owns a 2004 ford excursion. The contact stated when driving at 50 MPH, the vehicle would sporadically stall without warning. The contact was able to restart the vehicle after several attempts. The dealer was unable to duplicate the failure. The manufacturer advised the vehicle was not under recall and would not provide any further assistance. The failure and current mileages were 100,000.

Filed Nov 23, 2009 · Electrical · 138,883 miles · TN

Tl* the contact owns a 2004 ford excursion. When making left turns the vehicle will stall. The vehicle was taken to the dealer, and the computer and sensor were replaced at an expense of $1100. The vehicle was previously repaired according to recall # 05v270000 (electrical system:wiring). The failure mileage was 138,883.

Filed Nov 4, 2009 · Electrical · 96,000 miles · CO

Tl* the contact owns a 2004 ford excursion. The fuel injection control module failed, which caused the engine to stall without warning. The manufacturer was notified, and he was advised that he vehicle identification number was excluded from recall #05v270000 (electrical system:wiring). He was not eligible for a free remedy. The failure mileage was 96,000. Updated 12/09/09 *bf updated 12/11/09.

Filed Jun 21, 2009 · Fuel system · 120,000 miles · WI

Vehicle will not get fuel. Attempt to accelerate and car either will not move or dies. Fourth time vehicle has been in for repairs. Occurs every three to six months. Vehicle is 6.0 2004 xlt diesel excursion. Egr valve and ficm module, right bank of injectors replaced february 2009. May 2009 vehicle towed again and egr valve replaced again and ficm reprogrammed again. Vehicle is working for the time being. However, both banks of injectors, ficm module, egr valve x 3, high pressure oil pump, ipr valve, fuel pump regulator all replaced. Car continues to have safety issues regarding stalling and lack of acceleration. Almost gotten hot multiple times due to car stalling and not running. Safety is very much compromised. To my knowledge no parts are available that were replaced. Car runs well for short time and then needs to be fixed once again.

Filed Sep 25, 2008 · Electrical · CO

2004 ford excursion has a problem with stalling. *nj the consumer stated the recall was not being honored. Recall # 05v270000. The consumer also stated the alternator was replaced less than a year ago.

Filed Sep 16, 2008 · Electrical · 150,000 miles · MO

Vehicle would stall while driving and surge while stopped. This happened due to the wiring harness being burned and the fuel injection control modulator wiring harness as well as the icp sensor has to be replaced. This is a recall issue for my year and make but not my VIN. The mechanics said it will happen again, it is not safe to drive with this risk.