1997 Ford Expedition technical service bulletins
373 technical service bulletins and manufacturer communications cover the 1997 Ford Expedition.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Rear axle noise repair
- Use of stainless steel exhaust studs in service for 5.4L 2V engine
- Rear axle noise repair
- General (PCM) power train control module programming procedures
- Customer maintenance reminder - literature program 04L19 - tie rod inspection procedure
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
- Air suspension compressor noise
- Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position
- Courtesy rail lamps do not operate correctly or cause a battery draw
- Broken exhaust manifold studs
- Remote keyless entry (RKE) - service tips
- Tie rod end inspection procedure
- Engine misfire or rough running condition with coil on plug (COP) ignition systems may be more accurately...
- New transmission cooler flusher - service tips
- Repeat air suspension compressor drier failures
- Malfunction indicator lamp (MIL) illumination with diagnostic trouble codes P0442, P0455, P0456, P0457,...
- Tie rod end inspection procedure
- False failure of the vapor management valve (VMV)
- Climate control a/c service tech tips
- Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient...
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some vehicles with air suspension may exhibit an initial or repeat compressor dryer failure
- Subject regarding driveline angle-related vibration at various speeds and load conditions
- This bulletin states that some 4.6L fqr engine assemblies may have a smaller or larger knock sensor...
- Concerns with speed body boom
- Some 4X2 vehicles equipped with P275/60/R17 continental-general tires may exhibit a highway speed tire...
- Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps
- Some vehicles may exhibit wheels that seize to the hubs and are difficult to remove during service
- Some 4X2 vehicles equipped with P275/60/R17 continental general tires may exhibit a highway speed tire...
- Some vehicles equipped with 4 wheel drive may exhibit a notchy or sticking feeling in slow speed turns...
- Some vehicles may exhibit driveability conditions and / or check engine lamp illuminated with a diagnostic...
- Some vehicles may exhibit a slow fuel fill condition and/or premature shutoff of the gas pump when the...
- Some vehicles equipped with air suspension may exhibit an air leak and/or overnight bleed down of the air...
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- Some vehicles may exhibit driveabilty conditions and/or check engine lamp illuminated with a diagnostic...
- Subject regarding exaggerated engine braking on deceleration
- Subject regarding inoperative running board lights
- Subject regarding air suspension compressor quality
- Information regarding pop/thump noise from power window
- Engine oil system priming procedures, service tips for reports of premature engine failure
- Some vehicles may exhibit a slow fuel fill condition and/or premature shutoff of the gas pump when the...
- Some vehicles may exhibit air suspension malfunction
- A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient...
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing...
- Brake shift interlock
- Information on idle vibration or engine droan on acceleration
- Some vehicles may exhibit water in the transfer case, this could cause low range 4X4 lamp to illuminate,...
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Some vehicles may exhibit a vibration at idle and/or engine droaning noise on acceleration from a stop
- Some vehicles may exhibit a driveline vibration at speeds between 60-70 mph
- Some vehicles may exhibit courtesy rail lamps above the 2ND row seats that do not operate properly or...
- Some vehicles may exhibit a check suspension lamp on with diagnostic trouble codes B2140 or C2140 even...
- Some vehicles may exhibit amber anti-lock brake system (ABS) lamp on with undefined diagnostic trouble...
- Vehicles equipped with passive anti-theft system (PATS) may not start or crank
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5W-20 motor oil
- Safety recall update to replace locking lug nuts
- Subject regarding high idle and/or check engine light condition
- Some vehicles equipped with a 4.6L, 5.4L, or 6.8L engine may exhibit a rough idle / miss after start-up in...
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Some vehicles may exhibit hesitation on acceleration or while turning
- Subject pertaining to air suspension leaks
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt
- Some vehicles may exhibit a slow fuel fill condition
- Transmission- E40D/4R100-1989-99-MAIN controls, separator plates and separator plate gaskets usage chart
- Steering -alignment-toe set procedure service tip
- Fuel may leak from the spring lock couplings
- Transmission fluid leaks at radiator
- Some vehicles with 4.6L fqr engine assemblies may have a smaller knock sensor threaded hole than that in...
- Some vehicles with 4.6L fqr engine assemblies may have a smaller knock sensor threaded hole than that in...
- Concerns with vehicles exhibiting a windshield creak / squeak
- Information regarding the new transmission cooler flusher- service tip
- Subject on the malfunction indicator lamp (MIL) may illuminate and diagnostic trouble codes may appear
- Vehicles equipped with electronic automatic temperature control (EATC) , may exerience the blower motor...
- Servicing trailer hitch.
- Diagnostic information for compact disc player probles, no disc or cd will not eject
- Diagnostic information for compact disc player problems.
- Subject regarding the servicing of trailer hitches on vehicles
- Information regarding vehicles that experience the radios that display no dj-no disc or cd will not eject
- Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range
- Information for compact disc player problems, radio may display no dj- no dusc or cd will not eject
- Some vehicles may exhibit a body boom while driving highway speeds
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble...
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks
- Some vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
- All 4X4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite...
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Some vehicles may exhibit an engine knock at initial cold startup
- Vehicles with 2.4L, 4.6L, and 5.4L engines may exhibit an a/c moan at idle
- Emission recall for vehicles that were built with a fuel filler-valve which could leak while the vehicle...
- Vehicles equipped with windsor engines only may exhibit an engine knock at initial cold startup
- Some vehicles equipped with engines produced by windsor engine plant may exhibit an engine knock at...
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Service information for musty and mildew type odors coming from the air conditioning / heating system
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4R70W transmissions may experience delayed or no...
- Information regarding transmission trouble codes
- Experiencing engine knock at initial cold startup
- Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder
- This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal /...
- Information pertaining to conditions with red staining (SPOTS) on the front bumper wing ends
- Experiencing windnoise at the top of the door glass seal / weatherstrip molding area
- On some vehicles the front bumpers may exhibit red staining (SPOTS) on the bumer wing ends
- Information on the new flush and fill tool available through rotunda
- Some vehicles may exhibit vibration, shimmy and body boom at speeds above 72 km/h (45 mph)
- Some 4X4 vehicles built with center disconnect front axles may exhibit a moaning noise from the front...
- Subject regarding air conditioner vacuum reservoir / check valve location
- Exhibiting an air bag lamp on intermittently with lamp fault code (LFC) 24, or diagnostic trouble code...
- Subject regarding a/c vacuum reservoir / check valve location for the air conditioning system
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Subject regarding anti-lock brake lamp illumination, increased break pedal effort and / or false anti-lock...
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (NVH)...
- Some vehicles may exhibit a whistling noise while driving with a/c in the off position at speeds above 64...
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Conditions with door trim panel having loose or broken pull handles
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making...
- Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford...
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Experiencing a engine knock at cold start-up
- Information on using 1999 procedures manual for side mirror replacement
- Experiencing front differential noise
- Concerns with front differential noise
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal...
- Some vehicles may experience an idle vibration
- Exhibiting malfunction indicator lamp (MIL) with diagnostic trouble codes (dtc(s) PO351 and / or P0356...
- Exhibiting a vibration that may be interpreted as an nvh condition
- Information regarding new service steering gear
- Conditions on brokent door pull handles
- Addressing concerns of a low speed (under 35 mph) clicking noise caused by a cage nut rocking on the...
- Owner notification for replacement of engine cylinder heads
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal...
- Some vehicles may exhibit a idle vibration.
- On some vehicles, the door trim panels may have loose or broken pull handles
- Information regarding reprogramming powertrain control modules (PCMS)
- Concerns with transmission fluid leaking at radiator
- Vehicles experiencing increased brake pedal effort and / or false ABS cycling at low speeds, or ABS lamp...
- Information on replacing multifunction switch
- Vehicles exhibiting intermittent illumination of air bag light with diagnostic trouble code B1924
- Vehicles may exhibit a high speed driveline vibration
- Some vehicles may exhibit an air bag light on intermittently with diagnostic trouble code B1924
- Concerns with transmission fluid leaking at the radiator
- Some vehicles equipped with air suspension may exhibit an intermittent check suspension lamp on and...
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent,...
- Concerns of breakage of the exhaust system between the muffler and tailpipe may occur on some vehicles
- Diagnostic service tips on passive anti theft system ( pats )
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Rear wiper arm installation
- Some vehicles equipped with 5.4L engines may exhibit a cold start engine knock concern until warmed up
- Some vehicles with electronic shift on the fly 4X4 systems may stick in 4X4 low
- Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern
- For certain vehicles the octane shorting bar located on the passenger side of engine compartment near the...
- Information on vehicles exhibiting cold engine knock
- Information on vehicles exhibiting vibration at cruise over 50 mph
- Some vehicles may exhibit a rear wiper that does not function properly (jammed)
- This bulletin mentions that for all vehicles with antilock brake module concerns that require a module...
- For all vehicles with generic electronic module (GEM) concerns that require a module replacement, the...
- Experiencing no or intermittent auxillary a/c mode / blower control on some vehicles
- Mass air flow (maf)- sensor contamination- service tip
- Information regarding replacement and / or repairs on any lock component
- The malfucntion indicator lamp ( MIL ) may illuminate and diagnostic trouble code (DTC) P0455 may be...
- When installing a rear wiper arm on some vehicles, be sure to follow the procedure in the 1999 workshop...
- During high idle speeds throttle sticks after steady state driving in cold ambient temperatures
- A new parking brake control rubber bumper stop is now available for service
- Some vehicles equipped with 4.6L or 6.8L engines may exhibit a cold start engine noise until warmed up
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys...
- Experiencing cold engine knock (repeat / revised message)
- Subject regarding idle vibration (repeat message)
- Subject regarding vehicles exhibiting vibration at cruise over 50 mph
- Information concerning the octane shorting bar located on the passenger side of engine compartment near...
- Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern
- Some vehicles with electronic shift on the fly 4X4 systems may stick in 4X4 low
- Cold start engine noise
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
- Concerns with the power seat control button ( knob ) may detach from the switch actuator
- Vibration at cruise over 50 mph
- Cold engine knock 5.4L action
- Information on procedures to follow when installing a rear wiper arm
- Some 1997-1998 explorer/mountaineer/expedition or navigator vehicles with 4-WD 4X4 system may exhibit both
- Locks failed
- A direct replacement part for the evaporative emission canister and bracket assembly
- A clunking noise heard from front endcaused by front stabilizer bar contacting the frame
- Some vehicles may exhibit malfunction indicator light on with evaporative diagnostic trouble codes P0442,...
- Information on vehicles exhibiting and o/d off lamp flashing with diagnostic trouble code 62 / 628 / 1728
- Some vehicles may exhibit rear axle noise
- Brief information on vehicles exhibit vibration at cruise over 50 mph
- Malfunction indicator lamp on, with P0300 - P0308 misfire diagnostic trouble codes with a 4.6L engine
- This bulletin states that for certain vehicles it is not possible to set the check engine light and set...
- On some vehicles, the rubber stop bumper may be missing from the parking brake control, a replacement...
- Information on setting the check engine light and setting diagnostic trouble code P0455 (evaporative...
- Subject regarding a missing rubber stop bumper from the parking brake cotnrol
- Some components of the frame may require servicing due to collision damage
- Information on a new transmission fluid usage chart
- Information on tire company telephone numbers for customer assistance
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio
- A new silicone gasket and sealant
- Experiencing vibration at cruise over 50 mph
- Symptoms regarding P0300-P0308 misfire dtcs with 4.6L engines
- Some motor home vehicles equipped with E4OD transmissions may experience hydraulic system malfunctions...
- Important service instructions for onp 97-B-17, expedition only
- Brief information giving the correct part number for TSB 98-3-12
- If you encounter a vehicle with a missing wheel hub o-ring, do not install a new o-ring
- Concerns of engine checklight on and DTC P1506 ( idle air control over speed error ) and/or fast idle
- Vehicles with the E4OD are added to the fqr ( ford quality renewal ) assembly program
- Some vehicles may exhibit a low speed ( under 35MPH ) clicking noise
- Concerns of squeaky / noisy pitman arm
- When diagnosing crank / no start on certain vehicles equipped with passive anti-theft (PATS) check the...
- Concerns with hesitation, stumble, surge, miss, rough idle, stall at idle
- Subject regarding cold air felt on the floor while in heat mode
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Service tip information regarding elimination of sanding rotors and drums
- The malfunction indicator lamp (MIL) may illuminate and diagnostic trouble code (DTC) P0503 may be stored...
- Availability of hub-mount brake rotor machining equipment
- Cold air may be felt on the floor while in heat mode on some vehicles
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers
- Concerns with codes P0500, P0503, P1501 or P1503 which may be caused my a loose speedometer drive gear
- Repairs to vinyl covered surfaces
- Service tips for surface defect removal without repainting
- Some vehicles may experience an audible 50 hz body boom
- This bulletin mentions how some hub o-rings may be cut during the installation of the wheels
- Information on removing the radio chassis from some vehicles
- Some vehicles may exhibit loose lugnuts and / or broken wheel studs
- Subject regarding the availability of hub-mount brake rotor machining equipment
- Subject regarding passive anti theft system (PATS) diagnostic service tips
- Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Information regarding programming / diagnosing passive anti-theft system (PATS) related issues
- Subject regarding vehicles exhibiting erratic and / or inaccurate fuel gauge readings
- Erratic and / or inaccurate fuel gauge readings
- Subject pertaining to radio inoperative conditions
- MIL light on with evaporative DTC P0442, P0455
- Information on programming / diagnosing any passive anti-theft system (PATS) related issues
- Some engines may exhibit oil leakage
- Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds
- A new design transmission case and extension housing has been released
- Experiencing difficulty diagnosing vehicles with evaporative fuel system diagnostic trouble codes
- Experiencing difficulties with the malfunction indicator lamp (MIL)
- Some vehicles may stall when the transmission is placed into gear
- Concerns with "squeaking" and/or "rattling" noises may occur during different driving characteristics and...
- Brief information regarding cylinder head temperature (CHT) and fail safe cooling
- Rattle or clunk noise in rear of vehicle caused by the bushing falling out of the sway bar link
- Servicing tip - transmission - there are two different size direct clutch steel plates when servicing...
- Instructions for enabling/disabling the automatic lock feature
- Vehicles may experience an intermittent visor vanity mirror light operation
- Loss of some accessories such as driver's power window function when the transmission is shifted out of...
- The only authorized repair for a front frame bumper mounting bracket needing replacement is to replace the...
- Vehicles built before 3/24/97 may experience wind noise at the a-pillar
- Vehicles may experience a staining of the anodized aluminum trim with the use of some car washes which...
- Revision to the technical instructions when performing recall 96S60
- Some expeditions may experience an intermittent visor vanity mirror light operation
- Vehicles with premium radios will be equipped with volume control/on-off switch
- Vehicles built before 4/11/97 may experience a rattle or clunk
- Instructions on how to enable and disable the auto lock feature
- Rattle or buzz in tailgate trim panel after removal if the retaining clips are not replaced after repair
- Stress cracks on windshields
- Request for information on concerns of leather seat covers wrinkling, folding,leather wear or cracking
- Newly designed volume knob, incorporating a momentary on/off switch
- Noise- "buzzing"- underhood when air suspension is in operation
- Fuel economy- customer expectations versus vehicle usage
- Steering column- high speed vibration- 4X2 vehicles equipped with 5.4L engine
- Malfunction indicator lamp (MIL) - illuminated- diagnostic trouble code (DTC) P0446 stored in continuous...
- Engine- checking engine oil level in owner's guide incorrect
- Revised technical instructions concerning recall 96S60
- Interior- leather seat cleaning procedure- service tip
- Fluid- transmission fluid usage charts
- Instructions for resetting the trip computer
- Illumination of check engine light with DTC P0446 may be due to contaminated cannister, evap lines or vent...
- Concerns of condensate forming on outside of evaporator case
- Vehicles with a rough running/miss symptom with a misfire DTC on a particular cylinder where normal...
- Inoperative cd changer may be due to loose 66 pin connector
- Vehicles built with running boards after 1/30/97 will not have seals on the lower edge of the front and...
- Inoperative or erratic cruise control operation along with harsh transmission shifts
- Transmission- E4OD- cooler bypass valve service during transmission overhaul- service tip
- Check engine light - DTC P0446 - check for mold flashing in the 90 degree elbow evap line conming out of...
- Vehicles are equipped with passive anti-theft system (PATS) - vehicle will not start without the correct...
- Vehicles equipped with 4-WHEEL drive, roof rack and base suspension may experience clearance difficulties...
- Gem concern - check for more than one gem controlled component that is inoperative or for a string of...
- Air conditioning- R-134A tracer dye installed in a/c system and three o-ring spring lock couplers- service tip
- Front drive axle fluid leak
- Condensate forming on the outside of the evaporator
- Resetting of the tripcomputer on expedition & navigator where the information is not contained in the...
- Illumination of the check engine light
- The fuel gage may swing erratically on steep slopes
- Fuel pump sender, in areas with steep slopes, the low fuel warning light may prematurely activate
- Some 1995 and all 1996 and 1997 vehicles with E4OD transmissions have been built with a reusable...
- Some vehicles with air conditioning CAN exhibit a cold start accessory drive belt noise (CHIRP) concern
- Front drive axle fluid leak
- Some 5.4L front end serpetntine belts may make some noise between temperatures fo 30 F-50 f
- Inoperative floor mode concerns may be due to the panel/floor door vacuum actuator linkage disconnecting...
- The ngs displays incorrect date for the ing gem pid on the vehicles
- Looking for more definition of vibration concerns on 4X2 vehicles
- Check engine light on with DTC P0455 in continuous memory on 1997 5.4L vehicle applications
- Air suspension vehicles are shipped with the air suspension switch in the off position
- Parking brake pedal travel and effort on expeditions
- If 4X4 front axle is leaking through the vent tube, order the new front axle tube assembly from the...
- Parking brake pedal travel and effort on expeditions brought into the dealership with customer complaints...
- Check engine light on with DTC P0455 in continuous memory on vehicle applications
- All air suspnesion expedtions are shipped with the air suspension switch in the off position
- Engineering is looking for more definition of vibration concerns on 4X2 vehicles
- The ngs displays incorrect data for the ign gem pid on the vehicles
- Passive anti-theft system
- Vehicles equipped with 4-WHEEL drive, roof rack and base suspension may experience clearance difficulties...
- Some 1995 and all 1996 and 1997 vehicles with E40D transmissions have been built with a reusable...
- Some expeditions may experience some belt chirp at cold start up in ambient temperatures of 30-50 degrees f
- Driveline rattle over bumps
- Engine overheating- water pump concern due to free spinning water pump impeller
- 4X4 front axle is leaking through the vent tube
- Fead belt squeal, cold only
- Overheating on 4.6/5.4L vehicles may be caused by possible water pump concern due to free spinning water...
- Belt chirp at cold start up in ambient temperatures of 30-50 degrees f
- Vehicles with E4OD transmissions have been built with a reusable elastomeric transmission fluid pan gasket
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning...
- Powertrain control module -reprogram powertrain control module (PCM) - service procedures - service tip
- Door - power point access door breaks - vehicles built through 8/31/96
- Runs rough - malfunction indicator lamp (MIL) on - diagnostic trouble codes (DTCS) P0300 through P0308...
- Some front end serpentine belts may make noise when between 30 and 50 degrees fahrenheit
- Certain 1997 vehciles may have been built with the 240 second misfire delay
- Torque converter - leak test procedure - service tip
- Transmission - E40D - 4R70W - 4R44E - 5R55E - new digital transmission range sensor - diagnosis service tip
- Transmission - E40D - revised design forward planet thrust washer - service tip
- Long travel of parking brake pedal
- Engineering is investigating dealership concerns with fouled or cracked spark plugs
- Fead belt squeal, cold only
- Accelerator cable contacting the power steering reservoir may causing accelerator pedal vibration
- Soft parking brake pedal or long parking brake pedal feel
- Vehicles may have been built with a 240 second misfire delay
- 4X4 front axle leaking through vent tube
- Vehicles may experience fluid leaks out of the front axle vent tube
- Information when electronic/hydraulic control unit (EHCU) malfunctions
- High or irregular gauge movement or irregular low fuel light below 1/4 full
- Information for recreational towing (all wheels on the ground)
- Concerns of check engine light (MIL) w/ codes P0300 thru P0308 & eng runes rough/misses
- Mass air flow sensor - replacement as an assembly - service tip
- Windnoise - front window run lip hanging out - vehicles built through 8/14/96
- Procedure when air suspension light is on
- Concern of starter staying engaged, look at chafed wire at the rear bracket for the right front upper...
- 4X4 vehicles may exhibit a grinding noise while shifting into 4L
- Concerns of check engine light 'on'
- Information on replacing the compass assy for erratic/non-operation
- E4OD trans may emit a tick/rattle noise when driving at light loads in 1ST gear at 1100 to 1800 RPM RPM
- Reattachment of heater hose fittings for concern of no heat, overheat, or coolant loss may occur due to...
- For misfire concerns on 4.2L/4.6L/5.4L/6.8L engines
- Procedure for resolving the concern of water entry into the transfer case
- Information for concerns os speedometer, speed control inop & vss (vehicle speed sensor) dtc's
- Revised switch bezel is available that will minimize cargo contact w/ the switch
- Firestone P235 tires may exhibit a high frequency vibration at 65-75 mph
- Concern of starter staying engaged
- Information for high or irregular fuel gauge movement or irregular low fuel fuel light below 1/4 full
- Concern for vehicles exhibiting lean codes P0171 & P0174 (vacuum leak)
- Push connection between the flexible fuel vapor line at the carbon canister & the metal fuel vapor line...
- Procedure for brake warning indicator stays on red in cluster
- Procedure for brake exterior lights stay on (tail & high mount stop light)
- Light to moderate axle noise (axle whine) at 50 to 65 mph (80 to 105 kph) during accels, decels or cruise...
- Improper rtv application at the front/rear lower intake manifold end seals & side gaskets may cause an...
- Concern where the door glass drops when cycled down on vehicles with the power door option
- Concerns for the labor time standard in tbs 96-19-02 (steering - grunt noise during steering wheel return...
- Information for when diagnosing concerns w/ factory installed cellular phones
- Information on vehicles that may exhibit a slight delay in the first drive away after the vehicle has been...
- Electronic automatic temperature control (EATC) invalid diagnostic codes U1235 & 155 may be stored if the...
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history