Ford expedition caught fire while parked at walmart store, it started at driver side on engine and it took a few minutes to burn whole SUV.
1998 Ford Expedition engine complaints
Page 2 of 6: complaints 11 to 40 of 144, newest first, as owners wrote them.
While driving down the road, my 98 ford expedition spark plug blew out and caused a small fire in the engine compartment.
I have the 5.4 triton v8 engine. I just had my 3rd spark plug blow out in the last year.they need to recall these heads. Luckily it hasn't resulted in an engine fire like it has for others.
Spark plug keeps coming out and if you don't stop and pull over immediately it can cause a fire due to ges coming out of the hole and getting on a hot engine.
Driving down the road in our town and #3 spark plug blew out of cylinder head, had to be trailered to a ford mechanic to fix the problem - new spark plug, coil and cylinder head work - and I found out this a very common problem with the 5.4 triton motor!!
The sparks plugs burnt out they were ruined and I just had a tune up.
Coil and spark plug blow out of engine when truck was started (1998). The expedition has been known to have this issues as well as other issues. Why is ford not taking responsibility; so far accident avoided. I had to replace one coil pack each year so far but this was the worse. I needed the cinder retreaded to fit the spark plug in.
#6 spark plug blew out of cyl head. Reinstalled and replaced coil since it broke mount. Put back in service and next plug in bank (#7) blew within 10 miles at approx same speed. When searching the internet this is a common problem with fords modular engine prior to 04. When they make special tools and inserts to address the problem, ford should pony up and have the inserts installed at least for the normal life expectancy of the engine.
Spark plug blew out while driving on highway -- very dangerous. Had children in car. Had to be towed. My mechanic told me this is a recurring problem with this engine--5.4l-- in other fords as well. He had another ford with same problem come in the previous week, and has seen several others recently (this is just one small town/rural mechanic). Please take action -- it's a costly repair.
Plastic intake manifold failure resulting in repairs in excess of $1500.
Our 1998 ford expedition with the 5.4 v8 triton engine had another spark plug blow out of the cylinder head. The last time this happened was about 3 years ago, it was the #3 cylinder plug then and last week it was the #6 cylinder plug, I searched the internet concerning this problem and found hundreds if not more of the same issues, and no one is making ford do anything about this, just thought my voice in this matter might help. Please if there was ever an instance of a recall this is surely one. This is getting very expensive for the auto owner, the first time we had it fixed by ford and it was $250 and this time it was over $1,000. Thank you for addressing this issue. *tr
April 2011 ford 5.4 liter triton blew out yet another spark plug.
3rd time we have had a spark plug ejection from the passenger engine head of our 1998 ford expedition with a triton 5.4 liter engine. I owned a ford f150 and had this same problem twice. I did research and called a few ase master mechanics that are rated as america's #1 and #4 mechanics in the nation, and was told it is the most common problem fords triton engines have ever had, and they see these problems on a daily basis, yet ford does not acknowledge the problem. Ford desperately needs to recall these engines, they are a hazard, and the spark plug ejects with explosive power damaging nearby components on it's way out of the engine. Ford refuses to acknowledge this common manufacture defect. To fix this problem new heads need to be installed on the engine. The quick helical style sleeve into the stripped spark plug threads has a failure rate of 100%. Again this is a major problem and the magnitude can be seen all over the internet by searching fords spark plug blowouts. Literally 10's of thousands of forums, and insight in this problem is available online, except support from ford motor company.
I was driving @ 70mph down interstate 10 in seguine texas when the sparkplug on my 1998 ford expedition blew out of the head, destroying the coil, plug and wire. The vehicle interior filled with gas fumes and the vehicle started to knock very loudly. I was able to stop the vehicle prior to the fuel vapors igniting, however this was extremely dangerous as my wife and children were in the vehicle with me. After researching I have found that this problem is common with the ford 5.4 triton engines. The mechanic I took the vehicle to explained that the aluminum heads do not mesh with the steel spark plugs and eventually tear all the threads out of the head and shoot the plug out of the hole. The head of the vehicle had to be removed and machined at a cost of 1400$.
1998 ford expedition the spark plug blow out.
Tl*the contact owns a 1998 ford expedition. The contact stated that the spark plugs blew out of the engine while traveling 65 MPH; the contact smelled something burning under the hood. In march of 2009 one spark plug blew out, but in august of 2010 2 additional spark plugs blew out. The vehicle was not repaired. The dealer confirmed the failure. The failure mileage was 150000 and current mileage was 160000.
A spark plug was ejected from the cylinder head. Interior of the SUV filled with gas fumes. There was nothing noticeable prior to this occurring. This is the first time this occurred. The mechanic obtained the repair kit to rethread the cylinder head at a cost of $360.00. The work is not guaranteed...if it happens again, the head will need to be replaced at a cost of thousands of dollars.
1998 ford expedition 4x4 4.6l, the poor quality steel used for the exhaust manifolds and bolts rust very fast. Mine resulted in the driverside bolts rusting away causing exhaust coming directly out of the engine, also the egr tube rusted off the drivers manifold causing hot exhaust to blow toward the top of the engine. On the passenger side the manifold bolts/studs also rusted away causing exhaust to disperse in the engine bay. Also on the passenger side the manifold cracked about 3 inches long on the top of the manifold causing hot exhaust to blow upward to the upper engine bay. I corrected this problem by replacing the bad manifolds/studs with pacesetter shorty headers and bolts, it was the cheapest fix. The pacesetter shorty header kit was $150 from www.summitracing.com . The truck was extremely loud before I fixed this problem and I was pulled over for it by the police 4 times, they let me go if I promised to fix the problem. Since I fixed the problem the truck is very quiet and I don't get threatened with $75 tickets anymore plus I have the peace of mind the truck wont burn to the ground with my family in it from hot leaking exhaust manifolds or rusty failed studs/bolts.
First, the interior lights and running lights would not power off while all doors were closed, door ajar indicator was on. Took to dealer problem resolved for a month or so. Now need to spray wd40 on latches religiously. Dealer also replaced cruise control harness at this time. Then came the radio and heater running with the key out of the ignition. Beeps and clicks and bad smells coming from under dash. Again to the dealer, no codes found for the issues I was having. Battery draining occurring frequently now and no resolution. I now have to disconnect the battery everynight. Now when I drive down the road I get the many failure lights flashing on the dash, the windows won't work, speedometer fails, truck loses power and the transmisson shifts strangely. I was hours from home and doing 70mph on the highway when evidencing decided to not work at the same time. Then I realize that this is occurring only when it rains or is very wet out. And I was truly afraid for my life and the others that were on the road with me. I had to drift across a lane of traffic with no power to get to the side of the road. I put the truck in park and put my head down, whew, and the motor powered back up and all the failure lights were off. Only after investigating on the internet today do I find out this is a common problem. And the fix... Replace the windshield seal! And possible damaged fuse box and gem! Now why didn't the ford dealer help remedy this problem one of the many times I was in? This problem has been occurring for several years. New windshield $165 and they come to the house. I paid big money for "no codes match your issues, miss." tw*
1998 ford expedition sparkplug ejection.
Driving our 1998 ford expedition with a triton 5.4l v-8 home from a weekend camping trip, the engine blew a spark plug. We were on a very busy 5 lane highway with our three children under 6 years old. We spent nearly two hours on the side of the interstate waiting for a tow truck. I understand this is a fairly common malady; one in which the federal safety agency has investigated before. I understand that many outside ford motor corp feel this is a design flaw and creates unnecessary emergency events on the side of the road.
Number #4 coil pack, once air condition is turned on dripping water from lines into spark plug area, the #4 coil pack will through a code for a miss-fire. I have replaced the coil packs through out the entire engine recently again. I ran the air conditioning for about one hour and the next day I started the vehicle up and it had a rough idle. I drove approximately 6 miles when the check engine light came on. I hooked up my obd2 to see the problem found out the new #4 coil had misfired once again. I had the single coil pack replaced with 45,000 the first time then I replaced them all at 135,000. And now I had to replace the #4 coil pack again by itself at 143,000. It only throws a mis-fire once I have the air condition on.
1998 ford expedition with 5.4 l engine. #3 spark plug blew out of engine suddenly, causing severe noise, rough running, and loss of power. Mileage: 113,000 miles. Repair: $400 for retaping head, placing insert, replacing plug and coil.
1998 ford expedition blew spark plug out of the head with just a little over 85,000 miles. I was told by the dealer I bought it from that the factory recommends to replace the head at $2300.00. And they said this was the only fix. I traded the vehicle in for a huge loss. I only had it for less than a year. Because I found that this is a big problem with fords and no-one will do anything to stop this problem, I have vowed never to by another ford and will make as many people aware of this problem as possible. I now own an escalade and have put on over 90,000 miles without any problems, not like the fords expensive repairs. This happened to me a number of years ago and I didn't know there was a place to enter my gripe besides the ford motor company, and this was like talking to a wall. My family had bought fords since the 40's, when my grandfather owned dealerships. He would turn over in his grave to find out that ford is turning it's back on so many longtime faithful customers.
My 1998 ford expedition has blown out two spark plugs in the past 4 months. After doing research this is a common problem which ford does not repair on their warranty. Ford needs to be held responsible for their mistake!
The #4 spark plug ejected from the engine. This is the second time this has occurred within two years.
Plug blew out of head. Had someone look at the truck and they said that it's common for that truck to do that so I checked with another garage to see what they had to say and they told me the same thing .so why is there not a recall on this?
I was driving on the freeway at 10pm, and heard a loud pop, then what sounded like I had no muffler from the engine. I looked in the engine, and could not really see anything because it was dark. I had to the vehicle towed because I thought I blew a rod, or a head. Once at the mechanic's, they saw that I shot out 2 spark plugs- the no. 3 and 4 still attached to the wires, and that there were no threads left. I am having them pull the head, and have plugs put in, so far the cost to date is $1200. If the plugs do not hold, or other ones blow- which could happen at any time, I will have to replace the entire engine . This will about $3000 this is a very common problem with ford engines. Please do something about. Ford needs to take responsibility!!!!!
The engine in my 1998 ford expedition continues to have spark plug problems. The engine misfires, runs poorly, and is a hazard to have on the road. I have had several spark plugs blow out and have had to spend $4000 to have one of the heads replaced because ford did not include enough threads in their original design. They later changed the design in 2003 I am told. If someone there would visit the following site [http://www.consumeraffairs.com/automotive/ford_spark.html], they would see that these engines continue to blow out spark plugs as recently as yesterday, 9/16/08. When are you going to issue a recall? These engines have been dangerous and defective for years. I am not sure what it takes, but ford needs to step up an resolve this problem.
Ford exp eddie b. Blew out #3 spark plug. Striped the threads in the head. Cost is about 2 grand to repair and correct the 7 other plug holes to ensure it does not happen to others.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history