2011 Ford Expedition engine problems

Filed Dec 5, 2025 · Engine · MO

I bought this vehicle early 2023. From the moment I bought it I’ve had a loud ticking sound come from the dash or the motor when I start the car also when it’s really hot out. It also didn’t blow cold air. So I had to save up enough money to replace the AC components in my 2011 expedition. After I got it “repaired” It only lasted about six months and that’s being conservative. $2000 later and it’s blowing hot air and still making you loud ticking sound. I pretty much replaced all the components that deal with the AC and the blower. I don’t know what to do anymore, but it makes a loud ticking sound when I’m driving, when I start the car, anytime. And I also don’t have cold air anymore.

Filed Apr 20, 2023 · Engine · VA

The engine is blown at 125k miles when all servicing and maintenance was done at the dealership. Somewhere around 50k to 60k miles, I complained to the dealership about a ticking noise from the engine and was told multiple times it was "normal with this engine". Well this engine blew while I was on my way to take the kids to school. I was on the interstate/bypass and was by some miracle able to get the 7-11. I was driving and all of a sudden, it sounded like there was squirrel under the hood. I had to have it towed to the dealership because it was not driveable and they told me the engine was no longer good and was blown. They said it would cost me $10k and I would be better off buying a new vehicle. There was no engine light or anything that came on until it blew. The only "warning" I had was the slight ticking noise that came from the engine, but when mentioned to the dealership, I was told that it was normal with this engine.

Filed Jan 16, 2020 · Engine · 92,807 miles · UT

Camshaft roller bearings seized and scored the camshaft, requiring a top end replacement. The vehicle had less than 95000 miles. This the second expedition requiring this engine work. My first expedition required a complete engine replacement due to the same issue

Filed Apr 13, 2019 · Engine · 279,500 miles · TX

Upon engaging the cruise control while in motion at 65mph (highway) and going up a bridge the vehicle accelerated with accelerator being stuck on the floor (bottomed out) braking became ineffective at that speed. After a major effort was able to pull over. Putting in neutral made the vehicle idle at very high RPM, did not disengage the accelerator. Only after shutting the engine off in n and putting the vehicle in p followed by restarting solved the issue. Second time this occurred was at 55mph (local highway) flat road, same observations. Briefly disconnecting and reconnecting contact did not solve the problem. Very high idle in n and only after putting the vehicle in p after shutting down, the phenomenon was resolved. Only observed while using cruise control. In both conditions road was dry with no precipitation

Filed Feb 6, 2019 · Electrical, Engine · 152,204 miles · CA

Tl* the contact owns a 2011 ford expedition. While driving 30 MPH, the contact lost control of all functionality except the brakes. The contact stopped the vehicle, kept the engine running, and waited a few seconds before attempting to drive home. There were no warning indicators illuminated. The vehicle was taken to future ford lincoln (650 automall dr, roseville, ca 95661, (888) 656-7577) and they refereed the contact to the manufacturer. The manufacturer referred the contact to the federal safety agency to file a complaint. The vehicle was not diagnosed or repaired. The failure mileage was 152,204. The VIN was unknown.

Filed Sep 7, 2018 · Acceleration, Engine · 150,000 miles · TX

I was driving 70mph on hwy 290 when my car suddenly downshifted to first gear and then the wheels totally locked up. This caused me to start sliding sideways down the road until I came to a stop. It turned out that a computer module regulating shifting had gone bad. This also caused my transmission to go out and need replacing.

Filed Aug 3, 2017 · Engine, Transmission · 84,000 miles · TX

Upon hard acceleration over 3000 RPM a burnt exhaust odor enters the cabin. At all times

Filed Oct 14, 2015 · Engine · 131,476 miles · IN

Tl* the contact owns a 2011 ford expedition. While driving at various speeds, the engine shook uncontrollably without warning. The failure occurred whenever the brake pedal was depressed. The dealer stated that the vehicle was built with a faulty engine. The manufacturer was notified, but offered no remedy. The VIN was unavailable. The failure mileage was 131,476. Updated 02/05/16

Filed Feb 12, 2015 · Engine · 110,000 miles · WV

Tl* the contact owns a 2011 ford expedition. The contact stated that while coming to a stop, the vehicle jerked and made an abnormal noise coming from the engine. The failure recurred several times. The vehicle was taken to the dealer where the failure was not determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 110,000.

Filed Sep 10, 2014 · Engine, Fuel system · 60,000 miles · OH

Tl* the contact owns a 2011 ford expedition. The contact smelled a strong fuel odor inside the vehicle. The contact also stated that the fan made an intermittent clicking noise on multiple occasions when the vehicle was being driven. The vehicle was not diagnosed or repaired. The manufacturer was notified. The approximate failure mileage was 60,000.