2013 Ford Expedition engine problems

Filed Aug 23, 2025 · Engine · IN

2013 Ford Expedition Limited 5.4 engine. The vehicle was purchased new with an extended warranty with all services performed by Ford dealer. On or about [XXX], with no warning or indication of problem the vehicle experienced what was determined to be a catastrophic internal engine failure, with only 93840 miles. The engine problems were known by Ford Motor Company as replacement engines had design changes and modifications. The engine failure resulted in an immediate stop, which occurred on a 4-lane state road with a fifty-five MPH limit. Fortunately, no vehicles were in close proximity at the time. Dense traffic, at speed, could have resulted in a multivehicle accident. The vehicle required flatbed towing to a service center. Ford Motor Company has not taken action (recall) to address the engine problems, nor has Ford offered reimbursement to customers for replacement engine cost. Ford Motor Company receives the defective engine back when a replacement engine is purchased. The cost was near $8K. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 26, 2023 · Engine · 95,833 miles · MD

The contact owns a 2013 Ford Expedition. The contact stated that while driving at various speeds, there was an abnormal tapping sound coming from the passenger’s side of the engine compartment. The vehicle was taken to the local dealer who replaced twelve rocker arms from the passenger’s side of the engine, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 95,833.

Filed Jul 20, 2022 · Engine · 49,127 miles · SC

The contact owns a 2013 Ford Expedition. The contact stated while driving 20 MPH, the vehicle stalled and lost motive power without warning. The vehicle was towed to an independent mechanic to be diagnosed. The contact stated that the short block was replaced however, the failure persisted. The contact stated that during the failure the vehicle failed to accelerate as needed with abnormal sounds coming from the engine. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the long block needed to be replaced. The manufacturer was contacted and notified of the failure. The contact was then referred to the federal safety agency for assistance. The failure mileage was 49,127.

Filed Aug 19, 2021 · Acceleration, Engine · OH

Vehicle suddenly loses power the wrench light comes on and the vehicle will not go when pushing the accelerator. The vehicle has to be turned off and restarted before it becomes mobile again.

Filed Jan 31, 2020 · Engine, Transmission · 90,000 miles · UT

While driving at a high speed (highways, interstate, etc) the vehicle stutters - almost like an extreme downshift. Dealer performed a lead frame recall repair to the transmission but the vehicle continues to do it. It causes extreme anxiety to the driver and passenger, especially when it happens in the "middle of nowhere".

Filed Jan 16, 2020 · Brakes, Engine · 102,000 miles · TX

Several stalls followed by crank no start conditions over several months with no associated check engine light, code p0627 while vehicle in motion. 4m auto service center abilene tx performed fuse 27 relocation to fuse 73 accomplished. Vehicle returned to service. Several stalls followed by crank no start conditions over several months with no associated check engine light, code p0627 while vehicle in motion. Code cleared, vehicle returned to service. Stalled followed by crank no start conditions with check engine light, codes p025a, u0109 and p0627 while vehicle stationary. 4m auto service center abilene tx replaced fuel pump control module. Vehicle returned to service. Several stalls followed by crank no start conditions over several months with no associated check engine light no codes. Vehicle owner replaced fuel pump due to burnt wire (see attached photo). Vehicle returned to service. Contacted 4m auto service center, arrow ford abilenetx aand ford motor company customer service.

Filed Aug 9, 2019 · Engine · 118,000 miles · MA

Exhaust manifold leak caused by broken manifold stud. Vehicle had approximately 118,000 miles at time of failure.

Filed Jul 12, 2019 · Engine · 85,000 miles · IL

The number four spark plug issue with the 5.4l v8 engine and phaser caused my engine to fail. This is the second ford vehicle that I have owned that this happened to and ford has done nothing to resolve this long known issue with the phasers and number four spark plugs. Please help small business owners who depend on vehicles. Ford needs to either pay for replacement motors or something. I spent $5000 on a new motor and ford told me it is a known issue and to contact your agency as it is under investigation.

Filed May 22, 2017 · Engine · 72,000 miles · MT

While in motion on an oregon coastal highway at about 35 MPH vehicle hesitated made a loud noise and quit. At the time vehicle had about 72000 miles on it, and never gave a warning indicator, showing anything was wrong. As a result the engine had to be replaced. The only indicator the servicing dealer provided regarding the failure was a misfire in number 3. The product is defective either in construction or software as non warning was giving that anything was wrong. Previously on 2 different occasions at 2 different locations I took vehicle in because it seemed to be idling low and both dealers stated nothing wrong.

Filed Feb 22, 2017 · Engine · 32,000 miles · ND

Tl* the contact owns a 2013 ford expedition. While driving approximately 73 MPH with the cruise control activated, the service indicator suddenly illuminated and the vehicle lost power and reduced speed. The driver coasted to the side of the road and stopped the vehicle. The vehicle was towed to the dealer where it was diagnosed that the throttle body was faulty and needed to be replaced. The vehicle was repaired and the failure was remedied. The manufacturer was notified of the failure. The failure mileage was 32,000.