The contact owns a 2015 Ford Explorer. The contact stated that while driving at various speeds, the steering wheel became inoperable. The power steering assist and advance track warning indicator lights were illuminated. The vehicle was taken to the local dealer where it was diagnosed that the steering needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The approximate failure mileage was 69,053.
2015 Ford Explorer steering complaints
Page 5 of 13: complaints 101 to 130 of 348, newest first, as owners wrote them.
The contact owns a 2015 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel seized. The steering fault message was displayed while the advanced traction control warning light was illuminated. The vehicle was towed to the residence. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 70,000.
I was driving up north to spend the weekend camping with family and 2 hours into our trip two light went off one being the steering wheel check light a d the other being the advance trac light. I had to pull over completely because i was unable to drive the vehicle.
Every since I bought this vehicle I have intermittent power steering failure while driving. I was assured in the past that the toe link recall took care of this problem but I still continue to have this problem, although not as frequent as was before. While drive when it goes out I get the following errors flash: Service Advan Trac, Steering Assit Fault, and Hill start assist not available. These are the warnings that flashes. As of now, if I can get pulled over and turn off the vehicle and let it sit. Everything runs normal. But what is strange this last time I also got a Power Steering Low error flash up. This is dangerous and I can not believe FORD has not recalled my vehicle for the module when all the years and some of my years have been recalled for it. This is a $$$$ repair.
This has been an intermittent issue for approximately a year. The vehicle experiences binding popping when turning. The steering sticks and takes a second to return to function. I have almost missed curves because of the malfunction. It has not been examined by a dealership, but by a few independent mechanics. Sometimes it cannot be duplicated and in other instances it happens so quickly the tech cannot assess the issue properly. I have not had any warning lights or alerts other than the activity. I am scared to drive my vehicle especially with my kids inside. I have read several forums and this is clearly an issue that Ford is aware of, but has chosen to do nothing about. Please help.
I purchased this vehicle in May 2021. Within a week after purchasing, the power steering went out completely. When this happened, an indicator came on the dash that said "Steering Assist Fault-Service required". Another indicator came on as well that said "Service Advancetrac". Not only did the power steering go completely out, but the selector that allows me to change modes from grass, snow, sand, normal conditions was not working either. It was no longer lit up and would not respond when I tried to change it. This exact same scenario has actually HAPPENED 6 TIMES NOW in the past year, with the most recent happening on June 21, 2022. Each time, it happens when I am going to a relatively slow speed (under 25 mph) and it is VERY difficult to get it off the road due to the power steering being out. I am only reporting now because I didnt' know how to report it, or that it would do any good at all to do so. When this happened that very first time a week after I purchased it, the dealership said that I would need to have something with the steering replaced. I complained that I had only had the vehicle for 1 week, so they took it back to repair it. The repair apparently didn't fix it becuase it keeps happening. I transport my children in this vehicle daily. If the power steering fails again at a higher speed, a collision is very likely. I do not know why the Advancetrac selector goes out as well when this happens, but it happens every time. Each time this happens, I have to get it to the side of the road, turn off the vehicle, let it sit for a few minutes, and it is usually back to normal when I start it back up. When this happens, there are no indications prior to it that something might be wrong. It is completely random when it happens.
Driving 65-70 mph on highway headed home steering seemed a little stiff going into a curve then cleared up. 10 miles further down the road the steering seems a little hard to keep in my lane and then felt normal again. Coming into town slowing down to about 35-40 mph Service Advancetrac soon light came on. I slowed down as there was no where safe to pull over safely and turned on hazard lights until I could look for a spot to pull over and call my husband. Drove a couple more miles and pulled into a parking lot just as the steering loss light came on and all steering capability was lost. I’ve seen many complaints from owners of same make and model with this problem. Makes me curious why there is no recall on this year model when there are calls for this on previous year models
The contact owns a 2015 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel seized. The contact manually steered the vehicle. The vehicle was taken to an independent mechanic and diagnosed with power steering module failure. The mechanic informed the contact that the power steering module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 81,000.
Steering locks up while driving, no warnings or anything just cannot steer the vehicle.
The contact owns a 2015 Ford Explorer. The contact stated while driving 25 MPH, the vehicle lost power steering functionality. The Power Steering Assist Fault and Service Advance Tract messages were displayed. The contact veered to the side of the road and waited. The contact continued driving the vehicle using extra effort to steer the vehicle. The vehicle was taken to the dealer where it was diagnosed that the steering rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 106,000.
The Ford electronic rack and pinion system just failed. No warning light, no advance notification. Driving vehicle down road and abs ability to steer vehicle becomes impossible. Stopped vehicle and brought to dealership. In any other circumstance this could have led to a crash with injuries or death. Googled problem, and innumerable instances of this happening with Ford vehicles. Surprised this isn’t a recall item already!!
The contact owns a 2015 Ford Explorer. The contact stated that while his wife was driving approximately 25 MPH and making right turn, the steering wheel suddenly malfunctioned and became difficult to turn causing the vehicle to drive off the road. The vehicle was taken to the local dealer who diagnosed that the steering rack needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 163,000.
Electronic power steering failure, no warnings no lights on dash, steering completely bound up was unable to control vehicle, vehicle came to a halt on side of road narrowly missing a service pole, powered off vehicle and started again, steering was active but decided not to risk driving and called a tow
The contact owns a 2015 Ford Explorer. The contact stated that while driving approximately 55 MPH, the power steering failed to operate while the power steering system and advance track warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the steering rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000. The VIN was not included.
Electric power steering rack and pinion failure -- no communication to steering module. Currently available for inspection but may require immediate repair or sale of vehicle due to requirement of drivable vehicle. Inability to steer may have resulted in damage to person, vehicle and/or property if not immediately realized and car parked. Problem confirmed by independent service center (AAA Carolinas service center). No inspection of vehicle or component by the manufacturer, police, insurance representatives or others. No warning lamps, messages or other symptoms of the problem prior to the failure, although irregular but continuous issues with sensor re: putting transmission in park for 2+ years.
Rack and pinion failure while driving vehicle at speed. Unable to turn steering wheel without strenuous effort. Terrain Management fault, Advance Trac fault and Steering Assist fault lights/warnings indicated on dashboard.
The steering system failed twice without notice. The car would not steer while running, nearly causing an accident. The problem had been reproduced and confirmed by the dealer. Uknown if the component was inspected by the manufacturer. There were no warning lamps or messages, the steering simply stopped responding and locked up.
When making a right hand turn I noticed that the car began making knocking/thumping noises. Shortly after those noises began, when I attempted to turn left the steering wheel got stuck in the left turn position. I had to jerk the steering wheel hard to get it to straighten out. If I had not been able to get it straightened out I could have driven off the road or into oncoming traffic. Ford had to replace the entire steering rack and the dealership acknowledged that this is a known issue for 2015 Explorers.
I was driving and my power steering failed. The following messades appeared on my dash: Terrain Management System Fault Service AdvanceTrac Hill Assist Fault Electric Power Steering Failure. I was able to turn off the car and turn it back on again and the messages went away and my power steering worked again. A few days later, same issue occurred and the power steering never came back. Very hard to turn currebtly. I did some research and found that Ford had issued a recall for the same issue in previous years for the Explorer. I also found thousands of other owners had the same issue with the 2015 Explorer. Ford needs to step up and issue a recall on the 2015 Explorer for the power steering issue gefore someone is injured or killed.
The steering on my 2015 Explorer, the rack and pinion, is broken. My SUV has only 55K miles and has never been driven off-road. For repairing this issue, the cost is $3300. I called Sheehy of Gaithersburg, from whom I purchased the SUV, and told them the problem after finding out that this was a known issue. According to them, they are aware of it, but there is no remedy at this time. I was a bit bewildered because there was a remedy, i.e., fix the rack and pinion. Nevertheless, I was told that it was okay to drive with faulty steering despite the safety issue; furthermore, I won't be reimbursed if I decide to fix it. I am just so disappointed that Ford is okay with taking such a position, especially since it is a known safety issue.
I was driving my Ford Explorer and pulling a trailer behind it. I was about half way through a left hand turn at a major intersection when the power steering stopped working and my vehicle jerked hard to the right. Myself and my family were put at risk due to me barely being able to control the vehicle enough to avoid a collision with another vehicle, a telephone pole, and a curb after the steering system failed. The vehicle was taken to the dealership where the entire steering system was replaced at the cost of $2,500 to my family. There were no indications of any problem before this occurred.
Explorer has approximately 69k miles. Rack and pinion has to be replaced. Rubbing sound when wheel is turned and steering wheel 'sticks' when turned. Power steering power is also affected. Not under warranty. Checked by independent repair shop.
Was driving at a speed of 45 mph. Suddenly my power steering went out. Could barely steer it. A steering assist fault service required and advance trac system lights came on. My 4 wheel drive did not work. I have had this vehicle for 3 years and only put 20,000 miles on it. It has a little over 100.000 miles on it. It is gonna cost me 2400.00 to have this issue fixed. I noticed a lot of 2015 Ford Explorer Sport vehicles are having this concern! Please help us!! Thank you so much!
The rack and pinion is bad and grinds when turning. Yes vehicle is available for inspection if needed. no warning lamped have shown up to date other than major grinding when turning.
The contact owns a 2015 Ford Explorer. The contact stated that while his son-in-law was driving, the power steering assists error message was displayed however, the vehicle was still drivable. The contact stated that the turn signal failed to stay in place while signaling left or right turn. The turn signal switch failed to operate. The contact stated that several days later while driving the steering wheel was difficult to maneuver. The vehicle was taken to the dealer a month later where the failure was diagnosed as the rack and pinion needed to be replaced. The vehicle was currently at the dealer for repairs. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 60,000.
My son-in-law was driving our car with his family and the power steering went out while on the highway. The error message on the car was “Steering Assist Fault Service Required’. He could barely control the car to get it off the highway and back home. My husband took it to the dealership the next day but the error message had disappeared. The dealer was unable to diagnose the problem because they couldn’t get the diagnosis code for the issue. Then I was out with my step daughter driving the car and the power steering went out, same error message along with a new error message that read “Steering Fault Service Now”. This has happened several times so we took the car back up to the dealership and they have told us that they can’t replicate the problem and can’t get the diagnosis code so they can’t fix anything. The car has been with them for five days. I explained to the service writer that this issue keeps happening and the car keeps giving us the error message. Are we supposed to just wait until it goes out again and we end up in a horrific car accident? I have read incidents on this site with the same year, make and model all talking about the same issue yet Ford hasn’t recalled the 2015 Explorer to fix this problem. We have photos of the error messages and showed the service writer yet as it stands now they can’t do anything.
The contact owns a 2015 Ford Explorer. The contact stated while driving 35 MPH, the steering wheel became difficult to maneuver. The "Steering Assist Fault Service Required" and "Service Advance Track" messages were displayed on the instrument panel. The contact pulled into a nearby parking lot. The contact stated she turned off the vehicle and when she restarted the vehicle, the steering wheel was easier to maneuver. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The contact stated that the failure had been reoccurring while driving. The dealer was made aware of the failure and advised the contact to take the vehicle in for diagnostic testing. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 60,000.
I drove to a soccer tournament with my wife and 3 small kids over 2 hours away from my home. about 5 mins away I received an alert that my advance trac system was disabled. When I was pulling in the hotel parking lot I received a warning that I had a steering system failure and to stop the vehicle. At this point it the power steering was totally disable and I barely missed hitting a parked car due to lack of steering control. I was able to guide the Explorer to an open space in the hotel parking lot. I was totally frustrated and terrified because if the failure had happened just two minutes earlier I would have likely crashed at highway speeds! So I was stranded in a new town 2 hours away from home with no idea how I was going to get home or how to get my Explorer diagnosed. I had the Explorer towed to a nearby dealership. (Midland Ford in Midland Michigan) to get it diagnosed. In the meantime I had to find away to get my kids and my wife back home 2 hours away before Monday morning (School & Work) without a car and on a Sunday. I was able to to find a way home but we arrived very early Monday morning. I am now facing a repair job of $2600. I surely do not think that I should pay for what is apparently a common and known defect for my Explorer. A clear safety issue that put me and my family at risk while leaving me stranded 2 hours from home.
Power steering assist light came on and I lost my power steering all of a sudden. Stopped car turned it off started again and it worked for a minute then came back on.
Electronic steering assist gear failed and complete loss of steering was experienced. Driver was traveling at 45 MPH at the time of failure which could have resulted in serious injury or death. Ford was contacted 72 hours ago and has failed to make contact.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history