My truck is rattling bad and its the timing chain ford should have recalled this because it is a known problem. The oil seals on the tensioners start leaking causing them to not keep the chain tight like it should be and also fails to push oil around to the right side cam which causes it to fail. This should be recalled it is dangerous and could cause injuries if the truck stalls out. Also the spark plugs blow out of the heads causing very high repair bills. This also could cause a accident resulting in death. Ford has known about this problem but yet has done nothing to make it right. Ford should stand behind there mistake and make it right fix or replace the engine no matter what the mileage is because they knew about it. My truck repairs will cost over $7000 dollars to fix because ford would fix the problem they knew about. I change my oil every 3000 miles with val oil and lucus oil stabilizer because of this issue it seems to help the rattle alittle but its just going to get worse and I cant afford $7000 to replace an engine.
2005 Ford F-150 engine complaints
Page 2 of 9: complaints 11 to 40 of 228, newest first, as owners wrote them.
Engine tapping when warm only at idle doesn't do it while cold or while driving I had a mechanic look at it and he said it's due to a design flaw with ford 5.7 engines.
While driving 75 MPH on interstate 40, vehicle went into fail safe mode (happened a couple of times). Subsequently, engine began with a ticking noise with ever increasing rattling/shaking to a point that the engine had to be turned off. This happened numerous times while stopping or idling in city traffic. Local ford dealership replaced all coils & plugs, throttle body, fuel filter, etc. Vehicle ran fine for six months, however the rattling, knocking, shaking, surging, stalling have returned two fold. Vehicle is now experiencing a massive oil leak from the engine. Had it checked by an independent mechanic who could not make the repairs (but did complete an oil change). Ford motor company is totally responsible for these issues. These issues are not just inconvenient and expensive but mortally dangerous to the passengers of the vehicle as well as to anyone in close proximity. Step up ford!
1. Brake dot 3 is running out after several months. When I apply the brakes, the vehicle keeps going. In order to keep the vehicle running, I must push down the brake very hard to stop the vehicle. I have to constantly refill the oil tank. 2. When driving on the highway and the speed reaches at around 45-65 MPH, the vehicle automatically loses power and hit at 3-5 MPH before stopping. After I completely turn off and reset the battery, the vehicle starts normal again. The vehicle happened from 2009 to current time, but the odb scan does not detect any code or errors.
Tl* the contact owns a 2005 ford f-150. Upon starting the vehicle, it idled and the contact heard a rattling noise coming from the engine. The contact also stated that the vehicle had an oil leak and the check engine indicator illuminated. The contact took the vehicle to an independent mechanic to have the ignition coils replaced; however, the failures continued. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 184,994.
Letter from the office of the attorney general state of illinois on behalf of constituent regarding his 2005 ford f150 ford truck and a faulty engine which was not disclosed by the company. *ld
Tl* the contact owns a 2005 ford f-150. While the vehicle was stationary and while driving various speeds, it shook while idling at a red light and stalled without warning. In addition, the contact stated that the vehicle would not restart when prompted. An independent mechanic diagnosed that the head gasket was faulty and needed to be replaced. The vehicle was not repaired. A dealer and the manufacturer were not made aware of the failure. The failure mileage was approximately 94,000.
Tl* the contact owns a 2005 ford f-150. While driving approximately 30 MPH, the exhaust pipe detached from the vehicle. The vehicle was taken to an independent mechanic and it was discovered that the entire subframe of the vehicle was rusted and corroded, including the damaged exhaust pipe. The exhaust pipe was repaired, but the subframe was not. The manufacturer was notified of the failure, but the local dealer was not. The VIN was not available. The failure mileage was 70,000.
Vehicle stalls and or surges and has dead spots. After many attempts to solve the issue it still persists. Looking on line it is a common problem with this vehicle.2005 -2008 f 150 5.4. It is especially dangerous when towing a trailer my wife has almost got into accidents a couple of times while towing a horse trailer and is now afraid to drive the truck. Spoke to ford but no real response. I think this issue needs to be looked at further especially when considering people do tow with their trucks and it amplifies this issue. Thanks mario .
Ford had an extended warranty on their 2005 5.4l engines in the f-150 trucks. The extended warranty was for customer satisfaction program 07m08. The extended warranty covered fuel injector failures but failed to cover the result of those failures. I lost several injectors which resulted in "damage to other powertrain components." those component were the catalytic converters. Both of my catalytic converters failed. The vehicle would hesitate when accelerating and fuel consumption increased as the catalytic converters continued to fail. Emission testing was never performed of this vehicle. I can be assumed that emission testing would have failed while the vehicle was still under the 07m08 coverage.
Exhaust manifolds are leaking and causing exhust fumes to enter the vehicle. Truck has aprox 120,000, issue started at around 80,000. It's at the point now where it makes people in the truck sick and it won't pass state inspection. Cam phasers make noises as well. Wo know when this engine will fail. Common problems with the 5.4 v8 engine. Well documented on the internet.
Purchased ford f150 from old saybrook ford, feb. 16. The truck has the 5.4 engine which has numerous complaints of engine failure. Driving on route 1 when truck eccelorates or loses power. When we bought the truck the chain guide was broke and eating through the case. Spark plugs get stuck in engine or propel them selves through the truck hood. Dangerous engine to have on road. I owe 8000.00 on a truck that now needs 4-6000 worth of work.
Tl* the contact owns a 2005 ford f-150. While operating the vehicle, the odor of exhaust fumes was present inside the vehicle. Also, when the engine was started, a ticking type noise was heard under the hood on the passenger side. The cause of the failures was not diagnosed. The vehicle was not repaired. The manufacturer and local unknown dealer were notified, but no assistance was offered. The failure mileage was 130,600.
Following purchase from a ford dealership with a tune up and milage related service completed my 2005 ford f150 ran for less than 6000 miles before a stuck fuel injector caused a failure of the engine. At the time I was coming to a stop under normal conditions following a 18 mile commute from my previous stop. A metallic sound was heard and the drive became shaky and weak in accelaration. I proceeded 4 blocks to the dealership to assess the problem.the faulty fuel injector which was undetected until complete failure and resulting damage to engine components. This problem is well documented by other ford owners online will cost my family over $6000 without a recall on the parts known to fail widely in these vehicles.
I am the second owner of my 2005 ford f-150 xlt 5.4l 3v 4x4 crew cab (VIN# available on request) and there is a loud knocking noise coming from the engine. I can hear the noise while idling in drive, idling in reverse, idling in neutral, idling in park and traveling under low throttle and/or power in any gear(it is especially loud when the echoes bounce off of a hard-sided building, such as a drive-through restaurant). The events leading to my breakdown on a busy acceleration ramp are as follows: my vehicle lost almost all power on an acceleration ramp, slowing me down to a crawl. It also caused massive oil leaking from the engine compartment, which resulted in road spillage, causing unsafe driving conditions for me and the people around me. I've done some independent research and have personally had this issue fixed once. I've had it fixed at a mechanic, the resulting repair costs ended up being ~$3500. Full diagnostic and repair receipt is available upon request, but the main issues were the cam phaser, and timing chain. I have seen multiple upon multiple complaints about this issue, and I am formally requesting the nhsta to investigate and hold the ford motor company (hereafter referred to as "ford") responsible for this poor design choice. I would like to see a recall for every ford f-150 reported with this issue, as well as reimbursement for any documented repairs conducted by mechanics from ford. This may be an outlandish request that may not even be in the nhsta's cumulative power, but, as a taxpayer, a working man, and most importantly, a husband, I would like to see action taken by the people I put my faith in, to rectify this situation. Thank you for your time, and good day.
Vehicle went into "failsafe" mode on two separate occasions within the last year! And most recently, two weeks ago! Both at highway speed on two different interstates in florida! Very dangerous, and hard to control vehicle to "limp" to a safe place to stop! Many possible causes from electrical, fuel, or engine issues that are well documented on many internet sites and f150 forums! Also rust issues on roof of vehicle in rain channels! Very common,and very poor design!
My 2005 f150 xlt 4.6l engine blew out the #3 spark plug. This is a terrible inconvenience and frightening to think that it could happen at any time and leave you stranded in the middle of "no where", a very dangerous situation, could even be life threatening and yet ford will not own up and take responsibility for their inadequate design. To think that this could happen at any time and leave me stranded in the middle of "no where" is very frightening and could be dangerous and life threatening. This could prove very costly at $280 a plug..
I was driving in my 2005 ford f-150 5.4 when the engine shut off on its own. It was not the first time. It has happened while I'm driving in the middle of traffic. Just recently I was driving when I started to loose power, but this time started hear a loud banging coming from the engine. I drove the truck with almost no power to the mechanic. There I was told that it a cam shaft issue. As they uncovered the engine ii was told I would a new engine at the cost of $7500. As I later went online I found many people complaining about the same thing with ford 5.4 engines. It seems to me ford knows about the problem but are not willing to stand by their problem. I have kept up with the maintanance since have been the only owner of the truck. I love the truck but I'm very disappointed with ford not taking responsibility for having engineered a bad engine. I the single provider of my family and don't have money to be throwing away on new vechical. I also believe the truck stalling out in the middle of a highway was completely dangerous and I was lucky not be hit by anyone else. Please help.
Tl* the contact owns a 2005 ford f-150. While driving various speeds or while the vehicle was parked, a loud noise could be heard coming from the engine. There were no warning indicators illuminated. The vehicle was taken to a dealer where it was diagnosed with a cam phaser issue. The contact stated that the cam phaser, solenoid, and tensioner needed replacement. The vehicle was repaired, but the issue persisted with an even louder noise. The manufacturer was made aware of the issue. The failure mileage was approximately 88,000.
Tl* the contact owns a 2005 ford f-150. While driving various speeds, the vehicle lost power and misfired, and smoke could be seen coming from the rear of the vehicle. The vehicle was taken to an independent mechanic who initially diagnosed a fuel leak from the exhaust. Upon further investigation, the mechanic stated that injector number 7 was not closing correctly and causing the fuel to enter the cylinder. As a result, the motor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The dealer stated that the VIN was excluded from a recall on the injectors. The recall details were not provided. The failure mileage was approximately 76,000.
I needed a new transmission last year. Just blew out of no where. This year alone I needed new hubs, all8 cylinders have a miss fire my truck dropped from 60 to ten in seconds so scary
Bought truck new, has an engine ticking that continues to get louder. Properly serviced as per owners manual. Engine needs replaced per mechanic.
Cpsc;2005 ford f-150 transmission and motor went out at 89446 miles. A diagnostic was performed. *bf the consumer stated after the transmission was replaced, the vehicles performance was not indicative of having been at a repair shop. The consumer returned to the dealer and another diagnostic was performed. The consumer was then informed the engine needed to be replaced. It was also determined the initial repairs were completed with salvaged/used parts.
Tl* the contact owns a 2005 ford f-150. The contact stated that while driving the vehicle at 65 MPH, the vehicle began stalling intimittently then the engine and maintanenence warning light illuminated. The contact took the vehicle to a mechanic where it was diagnosed that the air filter was outdated and needed to be replaced. The vehicle was not repaired. The failure mileage was 108,000.
Truck was bought and I replaced all spark plugs and even had to replace a clinoid because was told that was the problem. Its not... There is a ball valve in the transmission that keeps the truck from building enough pressure to be able to shift which throws a code and says misfire on 6 been replaced twice now so clearly not the problem. This is a major issue.. Truck feels as if fixing to fie then check engine light will come on start flashing but throw no codes and you cant speed back up because it feels like your truck is about to die and you don't want to blow your motor.
Bought the truck used at 150000 miles. After 5000 miles the loud ticking that these trucks are known for became louder. At 161000 miles the engine died. I started it up in my driveway one morning and instead of just ticking, it was knocking 100x louder. The truck began shaking violently. Then it just died. All this happened in a matter of minutes. Had it towed to a shop, and they said I need a whole new engine. I can't help but think if I was driving and this happened, what the outcome would be. I have read hundreds of complaints from people online saying similar things. Ford is aware of the problem, but no recall was issued. That is irresponsible, and very dangerous on ford's part.
#8 cylinder spark plug blew out while driving. Replaced all spark plugs and torqued. Four days later #8 plug blew out again while driving.
Brake booster vacuum supply metal stand pipe ruptured. This was while driving. Loss of vacuum and loss of engine performance and brakes were sluggish. Have to push all way to floor.
While driving 75 on a toll road the engine went into engine fail safe mode, I lost all power and almost wrecked into oncoming traffic trying to get to the shoulder, I went to a mechanic and they replaced the throttle body, 3 days later same thing, I was told this is a common problem on this motor 5.4, why is there not a recall on this ??
5.4 3v triton. When the truck is at idle at a normal operating temp, it has a horrible knocking noise on the passenger side of the engine. From what I am reading this engine has major problems with the cam phasers and timing components. It sounds like the timing chain is about to fly out of the engine. I hope my truck doesn't give out on me because this is my only transportation to work and cannot afford to have it fixed. I bought a ford for reliability, but until this is fixed I feel it's unreliable. I have used a full syn oil and the right motorcraft 820s filter. This is a major problem and ford needs to pay for this and everyone else who has had this problem over and over! Recall this ford!
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history