2007 Ford F-150 suspension problems

Filed Dec 29, 2017 · Suspension · VA

The fram is eat up on my truck and ford wont fix it at alli call and they keep giving me the run around I think that the truck will break into and cause a serious wreck because of it

Filed May 2, 2017 · Engine, Suspension · 88,000 miles · CA

Tl* the contact owns a 2007 ford f-150. While driving 45 MPH, the vehicle decelerated and the check engine warning indicator illuminated. The failure recurred numerous times. The vehicle was taken to the dealer where it was diagnosed that the spark plugs and the coil springs needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer advised the contact to call the federal safety agency to check for any open recalls. The failure mileage was 88,000.

Filed Aug 30, 2016 · Suspension · 76,000 miles · MS · 1 injury

Tl* the contact owned a 2007 ford f-150. The contact stated that while driving at 65 MPH, the passenger's side front axle fractured and caused the wheel to separate from the vehicle. The contact stated that the air bags deployed. The vehicle was towed to an independent mechanic. A police report was filed. The contact sustained bruises that did not require medical attention. The manufacturer was notified of the failure. The approximate failure mileage was 76,000. The vehicle was destroyed.

Filed Aug 10, 2016 · Suspension · 140,000 miles · TX

Another incident of a "death wobble" in the front end. Going down the hwy there is a significant wobble. Front end of truck shakes dangerously. Slowing to 20 MPH resolves wobble but hitting a bump in the rd initiates this wobble again. This wobble has actually caused my truck to pull into another lane. I have had the alignment checked as well as new tires and balancing. Ball joints and other parts replaced. This is a factory issue and ford has failed to address with owners. Deaths are a certain outcome if not finally addressed. Latest episode was last night but has been going on for years.

Filed Dec 22, 2015 · Suspension · 97,000 miles · OH

The coil spring on the driver's side strut broke which appears to be a well documented reliability problem on the f150 trucks. The mechanic said that this failure always happens on the drivers side and the spring breakage is always in the same spot. The id tag on the part was u 4l34 5310- but the rest was not legible.

Filed Sep 17, 2014 · Suspension · 109,000 miles · PA

Tl* the contact owns a 2007 ford f-150. The contact noticed that the front passenger coil spring fractured. The vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 109,000.

Filed Aug 12, 2014 · Suspension · 84,500 miles · MA

Both front suspension springs found to be broken during routine inspection, heard one break a month ago but didn't identify the source of the break until recently. One broken spring was hanging below the shock, which could have caused a complete failure of the suspension on the right hand side.

Filed Mar 25, 2014 · Engine, Suspension · 48,880 miles · FL

Had a bad miss at highway speeds and limped home 15 miles. Replaced spark plugs and in the process broke two in the head. One did not break completely off (#4) and I needed to borrow a prototype tool from lisle tool corp. Removed and replaced plugs following ford procedures. Truck still had a miss. Replaced all eight coil packs which fixed the problem. Total cost$380.00. Truck down for 6 days awaiting tools and parts. Developed a vibration at highway speeds. Original tires(pirelli) were separating. Replaced tires(976.00), much better. Still have slight vibration at highway speeeds. Found left front hub bearing seeping grease and feels stiff. Awaiting parts to do repairs. (98.00) had a transmission shudder at light load in overdrive. Flushed transmission with bg products and flush machine. Added new trans fluid and conditioner. Transmission now shudders at all speeds when hot. Will order new filter and replace. Will add friction modifier and try again. Have to tow another vehicle this weekend and am afraid to do so. I am completely blown away that these problems could happen to any vehicle starting at 48,000 miles. All maintenance has been performed with top of the line products. Have been a ford owner all my life and am completely dis-satisfied with the performance of this supposed number one selling truck. The sticker prices of these trucks should be a bunch less since cheaply produced chinese parts are so prevalently used. Not happy.

Filed Mar 20, 2012 · Suspension, Tires · 100,000 miles · NC

Tl* the contact owns a 2007 ford f-150 with michelin ltx m/s2 size p275 /65 r18. The contact stated that all four tires were wearing down in the middle abnormally. The contact took the vehicle to the dealer and was told that the tires were not covered under recall and they could only provide a 20 percent discount. The contact stated that the tires had a 75,000 mile warranty and the tires were only at 45,000 miles of usage. The dot number and VIN were not available. The tire failure mileage was 45,000. The vehicle failure mileage was 100,000. Updated 5/7/12

Filed Aug 21, 2011 · Brakes, Suspension · 55,800 miles · TX

2007 ford f150 @54,000 miles rotors, brakes, top ball joints, bottom ball joints upper lever arm, and now my front brakes locked up lucky there was no accident , and several times I have pressed on gas and brake pedal at same time because they are so close together. Both the locking up of the brakes and sudden acceleration are very dangerous. The mileage is 54,000 and have had all these problems. Is ford not telling the customer of these dangerous problems.