I have taken my truck to ford and it happens when I,m pulling in to park or backing up in a space to park, the trucks engine starts to shake and than stall, when ford put the thing to attach under your steering wheel it did not show on the screen, I had a private mech. Do the same thing and he could not find it either. I do think this is a safety problem because my truck has also gone dead in the road waiting for the light to change and stall...now it is happening a lot , I talk to the ford dealer a states that it is now out of warranty . The problem started even when the warranty was still good on the truck.
2009 Ford F-150 fuel system complaints
Page 2 of 2: complaints 11 to 22 of 22, newest first, as owners wrote them.
Tl - the contact owns a 2009 ford f-150. The contact stated that upon refueling the vehicle, fuel would spew from the filler neck without warning. The vehicle was taken to a dealer where the failure was unable to replicated. The manufacturer was notified of the failure. The vehicle was not repaired. The approximate failure mileage was 46,000. The current mileage was 51,335. Rk
On or about aug & 2013 the vehicle mention above would start and then stall . I took the ford f150 to palm bay ford in palm bay fl. I was visiting my stepson at the time. I am form ga. The ford dealer had it for 3 days and said that there was nothing wrong. On feb 7 2014 the same thing happen. This time they towed the ford to there place from my stepsons home. They had the vehicle for 3 days. And finally said that the fuel pump driver module had failed. I cannot believe that they would not know the first time this happen. They charged me 652.09 for the repair. I know that I am not the first person this has happen to. What would have happen if this module failed when I was on interstate 95. This could have caused and accident or worse. Ford should recall this device because of the failure of the module and where is placed(under the spare tire) and the two different metals that cause corrosion.
First, the fuel door fell off the truck. Later that evening I heard a weird suction sound coming from the fuel door area. It began to idle rough, then would not want to start after fill ups. When you would stick the gas nozzle in the tank a loud "whoosh" sound would emit as it relieved pressure. My gas gauge stopped functioning and all of these issues eventually leading to the tank imploding/collapsing on itself. This bent the fuel pump and gas gauge inside the tank. I paid out of pocket to have it fixed because the ford dealership told me the warranty only "covered moving parts". I asked if the fuel gauge float and fuel pump moved. They enjoyed my rhetoric, but declined to fix the problem. They only replaced a sensor that threw a lean bank one code and caused the check engine light to come on. I drove it for the next year or so using the odometer to tell me when to fill up as my gas gauge no longer worked.. Fast forward a year and a half, and running out of gas 3 or 4 times, and it has done the same thing to me again. I just paid $972.19 to a private garage to replace the fuel pump, but I only got a 90 day warranty on the work and no guarantee that this issue will not happen again. When I googled the make and model of the truck I found all kinds of information about people having the same problem, yet ford acted like they have never heard of this before. I understand I am responsible for keeping the truck running, but nothing about the way I operate the vehicle made it do this. If I get in a wreck, I should pay to fix it. This is a design flaw and should be recalled. Btw I was doing 70 MPH on the interstate when it shut down most recently and traffic had me boxed in. It nearly caused a collision just getting it off the road. Had I died, no one would have questioned what caused the accident.
My engine light came on the code read bad fuel pump module.
I was pulling my boat, when coming to a stop, to park the truck, it suddenly accelerated. I had to turn off the key to stop it. I restarted the vehicle and drove around to block and come back to make another stop and it happened again. I again turned off the key. I let the truck set for about an hour and restarted it with no other incidents. I am very afraid it will happen again. Took it back to the ford dealer when I got home and they say they cannot find any problem.
No problems until about 60,000 miles. Then one day, while stopped, the truck suddenly died, the check engine light came on, and the gas gauge would indicated a quarter tank when the tank was actually full. All of this happened at the same time. I had two oxygen sensors replaced (about $400) to clear the check engine light and the fuel pump replaced (about $700) on the recommendation of the ford service department to cure the gas gauge problem. While turning across oncoming traffic, the vehicle has died and was hard to steer. Oncoming cars had to brake rapidly as I have had a hard time steering with no power. This has now happened numerous times. The truck dies or runs very rough and nearly stalls almost every time I drive it more than a mile or so. There is no check engine code and the dealer stated it could not be duplicated when I took it in for evaluation. This has the potential for creating a dangerous situation. I would fix this issue if it could be identified.
Tl* the contact owns a 2009 ford f-150. The contact stated that while driving 40 MPH the vehicle stalled without warning. The vehicle was taken to the dealer who diagnosed that the battery was defective and that the vehicle ran out of fuel. The vehicle was taken to another dealer who diagnosed that the fuel tank had collapsed. The manufacturer was made aware of the failure who stated that they would contact him back at a later date. The vehicle was repaired. The failure and the current mileage was 52,000.
The fan blower speed control stuck on high only and was replaced 09/2011. The vehicle kept stalling out upon deceleration going down the road. With loss of power steering and power brakes when this happens. Could be going 30 MPH or 60 MPH. When get motor is started again it usually runs rough. The left oxygen sensor code was on so this was replaced. 11/2011 the fuel gauge also stopped reading fuel in the tank when this happens. Replaced fuel pump in tank, fuel filter, fuel power module, all was fine for three weeks. Truck dies 8 times today and all the same problems are back. Engine light on, fuel gauge stopped working, truck runs rough for awhile when restarted then clears up. Engine light now stays on and fuel gauge will read 1/2 tank when it is full. 36 gal tank. 11/22/2011.
**catastrophic fuel tank failure** two days ago my 2009 f150 died in my driveway, it acted as if out of fuel even though the gage read over half a tank. I had it towed to a ford dealer and was initially informed that the truck was out of gas and the fuel gage wasn't working. A new unit was ordered and once the tank was removed from the truck it was discovered that the issue was exceedingly more severe. The mechanic and a ford engineer concluded that the charcoal purge valve failed and the fuel pump created such a strong vacuum that the fuel tank collapsed on itself and crushed the fuel pump.although the truck has only 15,000 miles it is not a warranty repair due to a salvage title on the vehicle. After the inspection it was concluded that the fuel tank unit was not damage or effected by any incident and was in standard operating condition when the event occurred.I also understand that since this is not a warranty repair, ford will not be collecting the parts for further evaluation. I believe this to be a mistake! I have asked to keep these parts and will provide them to ford if need be. As an engineer I believe this to be a design flaw that could present a severe safety hazard.
My 2009 ford f150 suffers engine stall when stopping in traffic. There are no diagnostic indications (engine light, codes stored). It has a "lifetime" fuel filter, so it cannot be changed. When the engine stalls, power steering and power brakes are lost, resulting in possibility of rolling into oncoming traffic. I have suffered 3 near misses in the past 3 days. Ford will not accommodate my schedule for service.
I stopped at the mobil kanagroo express gas station in gainesville to fill my 2009 ford f150 up with gas. I used the handle lock on the gas nozzle to fill the tank. I also held it with my hand. When it was not yet full the nozzle flew out of the filler tube spraying gasoline all over me and the ground. I pulled the truck away from the gas pumps because I was worried about a fire. I went into the store explain to the clerk what happened and told him that he had a problem out at the pump because there was a puddle of gasoline still on the ground. I had a change of clothes with me and the clerk gave me a bar of soap to wash up with. The clerk said the gas at the pump would just evaporate. I also reported the incident to the gainesville fire department who said they would check the stations pumps. I don't know whether it was the fault of the truck or the gas pump but I was afraid of dying because I was covered in gasoline.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history