2012 Ford F-150 steering problems

Filed Aug 31, 2026 · Steering · NC

While Driving power steering failed, in addtion this complaint is noted on numerous Ford formums and websites for my year and model truck.

Filed Apr 9, 2026 · Steering · NV

The component involved is the Electronic Power Assisted Steering (EPAS) system. It intermittently fails and returns unexpectedly, causing sudden changes in steering effort and jerking of the steering wheel. This creates a serious safety risk because vehicle control can change without warning, especially at highway speeds. The steering system (rack and pinion/EPAS assembly) has been replaced twice, but the issue persists. Replaced parts are not available for inspection. No manufacturer inspection has confirmed a permanent fix. This failure puts my safety and others at risk due to unpredictable steering behavior and potential loss of control. Other owners have reported similar EPAS failures, including sudden loss of steering assist, near-collision events, and accidents documented in public complaint records. The vehicle has received repeated repairs for this issue, including two rack and pinion replacements, without resolution. No police or insurance inspection has occurred. Warning symptoms include intermittent steering assist loss, sudden changes in steering resistance, and inconsistent steering feel. These occur without consistent warning, making the failure unpredictable and dangerous. This appears to be a recurring defect in the EPAS system that has not been reliably resolved through repair attempts or existing recall actions.

Filed Mar 7, 2026 · Electrical, Steering · AL

Rear wheel and steering lock up while traveling at 70mph on interstate causing broken controls on steering wheel . Vehicle is unsafe to drive. Truck was taken to Rivertown Ford 1680 Whittlesey Rd Columbus Ga 31904 for recall repair. Truck was released to me with no signals no wipers. The steering is very loose and hard to control

Filed Dec 27, 2025 · Steering · CT

Vehicle: 2012 Ford F-150 Incident Description: While driving straight under normal conditions, the “Service Power Steering Service Now” warning message suddenly appeared on the dashboard, accompanied by an audible warning alarm. Immediately after this warning, the steering wheel became extremely stiff and difficult to turn, with a sudden loss of power steering assistance. This failure occurred At the time, traffic was heavy, making it very difficult and dangerous to safely maneuver the vehicle and pull over. The sudden loss of steering assistance created a serious safety risk for myself and other drivers and could have resulted in a crash. I was eventually able to pull over to a safe location, This appears to be a sudden steering system failure and represents a significant safety concern

Filed Nov 19, 2025 · Driver assistance, Engine · WI

- what component or system failed or malfunctioned, and is it available for inspection upon request? Ignition switch, traction control, ABS, steering angle sensor, steering angle module, misfire cylinder 3, TPMS sensor light with no TPMS failures, shifter will not move without force or having to try and engauge that gear multiple times before going into gear and blinkers in-op. "service advance trac" warning on display. - how was your safety or the safety of others put at risk? Vehicle no start, loss of traction control, loss of ABS system, transmission will not go into gear on first try and intermittent directional function. - has the problem been reproduced or confirmed by a dealer or independent service center? Problems can be easliy reproduced - issues produce mil/ dtc even after codes have been cleared intermittently. Operation of directionals varies on each start up. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, multiple ase certified technicians - were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Mil's include but not limited to: b10f1:14-0a, p0303:00af, p0316:00-2f, c1963-20, u0428-f0, b1b48:01-8a, u0401:68-08, c1b00:62-0b, u0428:20, c1278:20 and b1596:20. Dash warnings displayed: "service advanced trac", "tire pressure low", "check 4x4", traction control dash light stays illuminated, TPMS light flashes and stays illuminated, truck must roll to engage parking gear, brake light will stay intermittently illuminated, rough idle, vehicle will no start intermittently, intermittent loss of traction control, intermittent loss of ABS, intermittent loss of directionals, key fob and door lock switch will intermittently not trigger or trigger locking mechanism. The doors will open but ecu/PCM thinks the vehicle is locked but doors open and triggers alarm. Lock button on fob and door lock switch will not operate.

Filed Aug 18, 2025 · Steering · VA

I had several instances where my electronic power assist steering (EPAS) has failed resulting in advance trac and other errorson my information screen.This has resulted in effectively NO steering. Thank goodness I was in a parking lot or going slow otherwise may have resulted in severe injury or death. This appears to be a problem with my make and model of truck based on what I have read on the internet and my personal experiences. I am in shock that there has not been a proper recall as of this date. I am having dealer put in a second EPAS unit in less than 2 years and considerable cost to me.

Filed Aug 11, 2025 · Acceleration, Steering · SC · crash · 1 injury

I was proceed up to 45mph, when back tires started sliding. I rolled the truck and damage my ribs, was pined for 1.5hrs lost a $80k+

Filed Jun 30, 2025 · Steering · DE

My truck started to skid as I was making a left turn. I wasn't going fast enough to skid. I then noticed the idiot light was on so I took it in for an estimate. I was told that the truck needed a power steering rack and the cost would be around $3000.00 I arranged for the repair. Truck mileage was 101051.

Filed Sep 27, 2024 · Electrical, Steering · NJ

I started getting a notification on my dash about a issue with the charging system. I checked system and it is fine. Now I am getting other lights on my dash and head lights flashing. Come to find out, it's a bad Body control module. I also have a steering issue, from time to time the truck is hard to steer and I been told it's signs of a bad rack and pinion. I also have had the same issues with my 2011 F-150. The bad body control module I fixed but the steering if bad. I have read on Ford forums that others across the country are have the same issues but of course no recall.

Filed Sep 2, 2024 · Electrical, Engine · VA

This truck is a safety hazard! The waterpump had to be replaced due to overheating, plus numerous other engine issues. it only has 137,000 miles on it But the REAL safety hazard is the power steering goes out at random times. and when this happens the dash goes blank. This has happened 4 times and each time we were lucky it was not on a busy highway, and close to home. The mechanic did everything he knew to do, and when we got it back....It did it again!!! Now, supposedly it is fixed, and we drove it home with no issues.....but...again, they are random, and I am scared to drive the truck. Will it take someone getting killed for this recall to happen? I have seen numerous post about this happening to others. I live on a winding back road, and if the power steering went out, I dont think it would end well. We are thinking of selling it, but I cant in my heart sell it to someone knowing these issues, and if we trade at a dealership, they will find numerous problems and never give us what it is worth, even though these problems are not from neglect