The contact owns a 2018 Ford F-150. The contact while parked and attempting to start the vehicle, there was an abnormal knocking sound coming from the engine. There was no warning light illuminated. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the valves inside the engine needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 68,000.
2018 Ford F-150 engine complaints
Page 5 of 21: complaints 101 to 130 of 591, newest first, as owners wrote them.
cam phaser rattle, water pump & thermostat
While driving the vehicle it often shifts out of gear. It will hard shift change and not drive, which causes people behind you to have to unexpectedly stop or speed up on you because truck shifts out of gear. Very dangerous situation, and online people often complain about it
The contact owns a 2018 Ford F-150. The contact stated that the vehicle was making an abnormal revving sound and other unknown sounds while the accelerator pedal was depressed. Additionally, the contact stated that the door and A/C and heating system actuator had failed. The contact stated that the rearview was inoperable. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was determined that the turbo, the air compressor and the 4-Wheel Drive system needed to be replaced. The contact stated that the actuator was unrepairable and was rigged by the mechanic. The vehicle was repaired; however, the failure recurred. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 100,003.
The contact owns a 2018 Ford F-150. The contact stated that while the vehicle was being serviced at an unknown location, the contact was informed that the cam phasers and timing chain were defective. Additionally, the contact stated that the engine made an abnormal sound upon starting the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N03. The manufacturer was made aware of the failure but no assistance was provided. The failure mileage was approximately 69,500.
In November, dealership sends out a tech to perform a PCM Recall on my truck. 110,000 miles and never had a problem with it. After recall, check engine light comes on after less than 10 miles of driving. Tech returns, runs his program and says maybe this will fix it. Less than 200 miles of driving, check engine light comes on again. Third attempt with tech, runs program, says there is nothing he can do. Dealership says there is nothing they can do except run diagnostics for a fee. Contact Ford corporate, they give the same nothing they can do except run diagnostics for a fee. I refuse. No problems at all with my truck until they performed the PCM recall issued by Ford. Just so happens this problem is being reported on Reddit app by several other Ford owners, but “there’s nothing Ford can do.”
The contact owns a 2018 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that there was a knocking sound coming from the vehicle before the vehicle stalled. There were no warning lights illuminated. In addition, the contact stated the vehicle was consuming an excessive amount of engine oil. The vehicle was towed to an independent mechanic where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the federal safety agency Hotline to report the failure. The contact referenced an unknown recall; however, the VIN was not included. The manufacturer declined to reimburse the contact for the repair. The failure mileage was approximately 136,000.
The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormally loud rattling sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer and the contact was informed that the cam phasers were defective. The contact stated that a previous campaign (21B10) was performed on the vehicle to repair the cam phasers; however, the dealer acknowledged that the campaign had failed to repair the failure. The contact was then referred to the manufacturer for assistance. The contact was informed that there was no recall or warranty on vehicle. The contact was then referred to the federal safety agency Hotline to report the failure. The vehicle was not repaired. The failure mileage was 48,641.
The contact owns a 2018 Ford F-150. The contact stated that the vehicle was repaired under an unstated recall; however, the contact stated that while the vehicle was parked and running, the vehicle shuddered and there was an abnormal sound coming from the engine compartment. There were no warning lights illuminated. The vehicle was taken back to the residence, and a dealer was contacted. The contact stated that the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 90,000.
The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, the vehicle shuddered violently and made an abnormally loud rattling sound. The vehicle was taken to the dealer while it was under warranty coverage; however, the dealer informed the contact that the failure could not be duplicated. The contact stated that the failure had gotten progressively worse. The contact stated that the vehicle failed to start and became undrivable. The vehicle was not diagnosed or repaired. The contact stated that the warranty coverage had expired. The contact related the failure to Ford Campaign Number: 21N03. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 70,000. The VIN was not available.
The contact owns a 2018 Ford F-150. The contact stated while driving uphill with the cruise control activated, the transmission downshifted into first gear and the contact depressed the brake pedal, and the transmission shifted back into tenth gear. No warning light was illuminated. The contact stated that a dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. Additionally, the contact was informed that the engine oil level was low. The vehicle was not repaired. The contact had not decided whether to pay for the repair. The manufacturer was notified on the failure and informed the contact that the warranty had expired. The contact was referred by the federal safety agency Hotline to report the failure. The approximate failure mileage was 93,000.
Oil pan leak. I was informed that this is a chronic issue with this engine due to material and sealant used during manufacturing.
The contact owns a 2018 Ford F-150. The contact stated that when the vehicle was started, the contact noticed a rattling sound coming from the vehicle. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with cam phaser failure. The contact was informed that the cam phaser and the camshaft needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact referenced Customer Satisfaction Programs: 21N03 and 21B10; however, the contact was informed that both programs had expired. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 131,550.
Cam phaser rattling sounds starting the engine
The contact owns a 2018 Ford F-150. The contact stated that while the vehicle was parked, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The contact stated that the cam phasers had previously been replaced; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 45,486.
We were driving on the highway when the truck starting jerking/shuttering and losing power. The wrench light came on, we put on the hazard lights and limped off the nearest exit.
Plastic two piece oil pan installed by factory with insufficient RTV resulting in a significant oil leak and possible fire potential as run back of oil reaches exhaust components. Vehicle is well kept and serviced regularly with less than 100k miles. Vehicle is out of warranty and down time is several days for a fix that results in using the same plastic oil pan with an estimate of $1200. Unfortunately this same oil pan will result in a similar leak in the future if fixed. Aftermarket aluminum options are available which result in a much better sealing surface. FORD please fix this issue. Oil leaking from pan first noticed during stops at red lights while idling and smelling burning oil thru vents. Ford dealer confirmed oil pan leak and suggested immediate replacement.
The contact owns a 2018 Ford F-150. The contact stated while idling and while driving on several occasions, there was an abnormal rattling sound coming from the engine compartment. The vehicle was taken to an unknown dealer, where the contact was informed that the rattling sound was normal. The vehicle was then taken to a independent mechanic, where it was diagnosed that the timing chain assembly needed to be replaced due to a cam sensor failure, and the cam phasers needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 45,000.
The vehicle will cut off or shut down unexpectedly. This is a safety issue because I could be in traffic with other vehicles when this happens. The vehicle is currently at the dealership and they have quoted $6,000-$8,000 for repairs. No warning, it occured last week. I almost wrecked when it happened. The vehicle was riding rough and then it cut off.
The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the front of the vehicle. The contact stated that while driving at various speeds, the transmission was slipping. There was no warning light illuminated. The vehicle was taken to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 193,000.
The car has very bad cam phasers that are a manufacturing issue from ford. This is causing a lot of damage to the engine and also it has put me in very dangerous situations because of the huge decrease in power when I am exiting into a highway or changing lanes. I have spoke to ford and they did not want to help me especially when they have had multiple recalls for this in the past and even extended recalls. Please help me with this, because it's a big issue and it's a manufacturing problem from ford.
The contact owns a 2018 Ford F-150. The contact stated that the engine was consuming an excessive amount of oil per week. The contact stated that one quart of oil was added per week. The contact was unaware of any oil leaks. The contact had taken the vehicle to a local dealer who diagnosed the vehicle and determined that a longer oil dip stick and an engine software update was needed. The vehicle was repaired; however, the oil consumption persisted. The contact took the vehicle back to the same dealer who diagnosed the vehicle and determined that there was damage to cylinder #2. The engine was replaced, and the vehicle was repaired. The contact stated that much later while start the vehicle in the morning and shifting to drive (D), the transmission remained stuck in 1st gear. The contact stated that while depressing the accelerator pedal, the transmission struggled while shifting into, and out of 2nd gear. The contact stated that once the vehicle hard warmed up, the transmission was shifting normally. The contact stated that there were no warning lights illuminated. The contact had taken the vehicle back to the same dealer. The vehicle was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 77,000.
The contact owns a 2018 Ford F-150. The contact stated that while the vehicle was parked and occupied, while attempting to start the vehicle, the contact heard an abnormal rattling coming from the engine. The contact stated that a dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed and determined that the cam phasers needed to be replaced. The vehicle was not yet repaired, but was in the process of being repaired. The contact stated that the cam phasers were replaced several years ago under warranty. The contact related to the failure of the Customer Satisfaction Program: 21N03 (Engine Cam Phaser Replacement); however, the vehicle was not included in the Customer Satisfaction Program. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 60,000.
The 2018 F-150 has a huge oil consumption problem, constantly having to add oil after several hundred miles driving the truck, at a minimum a qt at a time. The F-150 10speed transmisson also has a hard shift and jerks while shifting gears, after it warms up it the harshness of the hard shift goes away but still has the hard shifts. There is no warning lights on the dash, and it can be reproduced. Have on several occasions with the hard shifting almost caused several accidents being rear ended due to the truck not shifting out of gears as it should. Along with several times on the interstate after having to stop for other accidents and the truck not getting back up up to speed as it should.
The contact owns a 2018 Ford F-150. The contact stated that while attempting to start the vehicle, there was an abnormal rattling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The contact referenced Customer Satisfaction Program: 21B10; as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 62,000.
The contact owns a 2018 Ford F-150. The contact stated that while attempting to start the vehicle, the vehicle hesitated while starting. The check engine warning light was illuminated. The vehicle was taken to a local independent mechanic where it was diagnosed, and it was determined that the valve body and transmission drum needed to be replaced. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 25V164000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.
The contact owns a 2018 Ford F-150. The contact stated that while starting the vehicle, the vehicle hesitated while starting. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 127,220.
The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine compartment. After the engine had reached normal operating temperatures, the rattling sound ceased; however, the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the cam phasers. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N03. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 44,000.
The contact owns a 2018 Ford F-150. The contact stated that there was an abnormal rattling sound coming from the vehicle. Additionally, the vehicle was difficult to start. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the cam phasers needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and opened a case. The failure mileage was approximately 63,000.
The contact owns a 2018 Ford F-150. The contact stated while driving at an undisclosed speed, there was a misfire coming from the engine and several unknown warning lights were illuminated. The vehicle was taken to an independent mechanic where it was unofficially diagnosed with failed catalytic convertor sensors, which provided false failure codes. The vehicle was taken to the dealer where it was diagnosed with catalytic convertor failure. The contact was informed that the catalytic convertor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 113,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history