2020 Ford F-150 body problems

Filed Mar 6, 2026 · Body · WI

Drivers side door does not unlock in cold temperatures (physical key, fob button, keypad, and handle lock do not work).To unlock I have to enter through the passenger side door and use the interior handle. Seems to be an ongoing issue and there are "recalls/TSB" for the same issue happening on 2015-2019, 2021-22 models but not 2020. "The major frozen door latch recalls (such as 17S33) officially covered 2015-2019 F-150s and other Super Duty trucks." Reddit forums are full of others complaining of the same issues. What component or system failed or malfunctioned, and is it available for inspection upon request? - Driver side door handle. Yes How was your safety or the safety of others put at risk? - Must enter through the passenger side door to unlock the vehicle. In an emergency I would not be able to enter my vehicle quickly. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no.

Filed Jun 12, 2025 · Body, Tires · 65,000 miles · NC

The contact owns a 2020 Ford F-150. The contact stated upon attempting to replace a flat tire with the spare tire, the contact noticed that there was a hole in the spare tire. The contact determined that the mufflers had burned the spare tire due to the spare tire location in the vehicle. The dealer and the manufacturer were notified of the failure, but no assistance was provided. The manufacturer informed the contact that the VIN was not included in a related recall. The vehicle was not diagnosed or repaired. The vehicle remained in a parking lot. The tire had not been replaced. The failure mileage was approximately 65,000.

Filed Feb 11, 2025 · Body · 100,963 miles · TX

The contact owns a 2020 Ford F-150. The contact stated while driving at an undisclosed speed, the contact noticed water leaking from the top of the vehicle located near the microphone and the sunroof control area. The contact noticed water leaking from the area while it was raining. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 100,963.

Filed Jan 16, 2025 · Body, Engine · 81,557 miles · FL

The contact called for her partner who owned a 2020 Ford F-150. The contact stated that the dashboard had warped near the passenger side's glove compartment when purchased. The dealer had been informed of the failure and informed the owner that the dashboard needed to be replaced. The vehicle was not repaired. The contact stated that while the vehicle was stopped and idling at a traffic light, the vehicle lunged forward causing the contact to aggressively depress the brake pedal, causing the vehicle to jerk abnormally. The contact stated that the engine was revving abnormally while stopped at a traffic light. Additionally, while shifting into reverse or drive, there was an abnormal clicking sound coming from underneath the vehicle. The contact stated that the failure had occurred approximately 5 times. The vehicle was taken to the dealer, and a computer reset was performed. The contact was unaware of the diagnostic results, or the repairs performed on the vehicle. The contact stated that the failure persisted, and the steering wheel intermittently loosened, there was oil leaking underneath the vehicle, and there was an abnormal burning oil odor coming from the vehicle. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 81,557.

Filed Jan 10, 2025 · Body, Locks · 40,000 miles · OH

The contact owns a 2020 Ford F-150. The contact stated that upon attempting to enter the vehicle he found the driver's side door nearly impossible to open. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the driver-side door actuator. The vehicle was repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 17V331000 (Latches/Locks/Linkages, Structure), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency hotline for assistance. The failure mileage was 40,000.

Filed Jan 8, 2025 · Body, Electrical · OR

On [XXX] I took the truck to Ford dealer after noticing the front floor passenger side carpet was wet and door locks and electronic tire pressure indicator failed to operate correctly. Ford service dept found a/c drain was letting water back into passenger compartment and caused body control module (bcm) failure. Bcm was replaced after 2 1/2 months in the service dept. Returned on 8/26/24, 9/18/24, and 10/22/24 for same water intrusion problem. Different repair done on 10/22/24 to remedy problem. Service dept contacted Ford national office and learned this was considered a design flaw by Ford. Expected a recall will be issued. Remedial treatment for mold was applied because I had been smelling a vinegar smell in the truck cab which is typical smell for presence of mold. This is the primary safety issue I believe exists, but failure of body control module could cause other safety problems. . No recall issued yet.

Filed Sep 17, 2024 · Body · WA

Right door lock actuator/latch not able to lock or unlock. Similar to current recall for f150 raptors same generation model but 1-4 years older.

Filed May 17, 2024 · Body · 40,000 miles · CA

The contact owns a 2020 Ford F-150. The contact stated that while her child was attempting to enter the vehicle, the door handle detached, nearly resulting in injury. The vehicle was taken to the dealer, who determined that the handle had detached due to being made of plastic. The vehicle was repaired, but the failure reoccurred three additional times. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 40,000. The VIN was not available.

Filed Mar 10, 2024 · Body · MN

My 2020 ford truck driver side door locks freeze when temperatures get below freezing. When this happens the door does not open and when I open it from the inside the door doesn’t latch. I have to use a bungee cord to hold the door closed if I’m going to use the vehicle. Also the rest of the doors don’t lock when driving the vehicle. I believe other year ford trucks have had this issue and they also were recalled for a fix. I have had the truck to the dealer several times with no luck. The last time when the truck was under warranty they replaced the door lock actuator which didn’t help. I believe this is very much a safety issue and I shouldn’t even be driving this truck but I need it.

Filed Jan 23, 2024 · Body · 30,000 miles · MI

The contact owns a 2020 Ford F-150. The contact stated that while driving 50–55 MPH, the fiberboard cover and fiber shield detached from underneath the vehicle. There were no warning lights illuminated. The contact was able to reattach the fiber shield and cover. The vehicle was taken to a local dealer but was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was 30,000. The VIN was not available.