2024 Ford F-150 Lightning Complete instrument cluster blackout while driving. Screen goes entirely black intermittently, lasting up to 30 minutes. Occurs while vehicle is in motion. Issue persists even after stopping and restarting vehicle. Loss of speedometer, battery state of charge, warning lights, and all driver information. This creates unsafe driving conditions with no way to monitor speed or critical vehicle systems.
2023 Ford F-150 electrical complaints
Page 2 of 4: complaints 11 to 40 of 85, newest first, as owners wrote them.
Rear light bar has water inside. Recall has not been fix since October 2025. Rear light flickering on and off. Been pulled over by the police
I contacted the local ford dealer, Seekins in Fairbanks Alaska. The dealership wanted to make an appointment to address the recalls next DECEMBER -- this April 2026. What's the point of a safety recall if they won't timely address them?
The contact owns a 2023 Ford F-150. The contact received notifications of the federal safety agency Campaign Numbers : 25V512000 (Power Train) and 26V104000 (Electrical System, Exterior Lighting); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer where it was diagnosed and determined that the rear axle shaft assemblies had failed and needed to be replaced. The vehicle was not repaired. The dealer confirmed that parts were not yet available for the repairs. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The failure mileage was unavailable.
After a crash into a tree on the passenger side the airbags deployed and the truck immediately caught fire and the doors locked and would not open for any reason. The only way I was able to exit was busting through the front windshield. had I been severely injured or knocked unconscious the outcome of this would have been much different. The truck burned to the ground in 11 minutes. It has been inspected by the police and awaiting insurance representative to inspect. There were no warning no recalls regarding a crash that would lock the doors and not allow me to exit.
The contact owns a 2023 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 23V896000 (Power Train) and 26V104000 (Electrical System, Exterior Lighting); however, the parts to do the recall repairs were not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact was informed that parts needed to be ordered and was later informed that parts were on back order. The manufacturer was made aware of the issue and confirmed that parts were expected to be available in the third quarter of 2026. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
I am reporting a serious safety defect in my 2023 Ford F-150 Platinum SuperCrew (EcoBoost engine. The oil pressure warning light suddenly illuminated, indicating a loss of oil pressure. Immediately after, the engine suffered catastrophic failure (it "blew the engine"). At the same moment, with no input from me, the gear shifter automatically shifted from Drive into Park. This caused the transmission to lock up, resulting in violent skidding and the truck veering off the road. I was able to regain control and avoid a collision or rollover, but the incident created an imminent risk of serious injury or fatality, especially while towing. I have maintained it properly, never missed a payment on the $74,000 truck, and drove it cross-country from Arizona to Florida without prior issues. Ford Motor Company has claimed there were "70 warnings" prior to the failure, but I received **zero** dashboard warnings, lights, messages, or indications at any point leading up to or during the event. This is the second Ford F-150 I have owned with unexplained powertrain problems. I traded a 2018 F-150 for the platinum & it repeatedly stalled without reason & required the engine to cool before restarting; dealerships (FL & TN) could not fully diagnose it, with one suggesting an oil-pump-related overheating issue despite no warning lights. Repair estimates are extremely high: Gator Ford quoted $17,000, Brandon Ford quoted $14,000, Veterans Ford quoted $12,000, and an independent shop quoted $12,000 (notably, the independent shop knew the dealership quotes without me providing them). I believe this points to a potential defect in the EcoBoost engine's oil pump system (possibly excessive pressure or failure under load/towing) combined with an unintended shift-to-Park function in the transmission/shifter electronics, creating a dangerous loss of control at highway speeds while towing. This combination of sudden engine seizure and automatic shift to Park poses an unreasonable risk of crash.
The contact owns a 2023 Ford F-150. The contact received notifications of the federal safety agency Campaign Numbers: 25V512000 (Power Train) and 26V104000 (Exterior Lighting, Electrical System); however, the parts for the recall repairs were not yet available. The vehicle was taken to the dealer for an oil change. The contact was informed by the dealer that a hub bolt had detached from the vehicle. The contact was informed by the dealer that the hub bolt had failed and needed to be replaced. The vehicle was not repaired. The contact was informed that parts were not available and were on backorder. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure.
The contact owns a 2023 Ford F-150. When the vehicle was purchased, the contact requested the Retrofit/Activate Heated Steering Wheel option. When the vehicle was delivered, the contact realized that the option was missing from the vehicle. The vehicle was taken to the dealer, and the dealer suggested that the contact read the manual to learn how to turn on the Retrofit/Activate Heated Steering Wheel. The vehicle was taken back to the dealer, and the contact explained that the option was missing from the vehicle. The dealer refused to assist. The manufacturer was made aware of the issue but provided no assistance. Upon further investigation, the contact became aware of Customer Satisfaction Program: 22G06, which was associated with Ford and Lincoln vehicles with the Retrofit/Activate Heated Steering Wheel option deleted during production due to supply shortages. The contact took the vehicle back to the dealer and mentioned specifically that the vehicle needed the Customer Satisfaction Program: 22G06 "Heated Steering Wheel Performance Upgrade". The dealer refused and informed the contact that the vehicle could no longer be taken to the dealer. The vehicle was not repaired. The failure mileage was approximately 40.
My vehicle is experiencing all of the systems of the current ford recall. "Trailer lighting module fault. " rapid blinker. Etc. for whatever reason it is not listed in the vehicles to be recalled. Thus making it very difficult to get fixed at the dealership. Need this taken care of asap!
The 12v battery on these vehicles are severely strained or defective AGM batteries have been used since vehicle inception in 2022. Dozens of reports from owners show "system off to save battery" error codes and 12v symptoms such as inoperable multi-function displays, especially in cold weather. After replacing the OEM 12v battery, i have pictures showing the bulging the battery has suffered. Again, these errors are experienced by dozens, if not hundreds of owners and could lead to serious injury because the 12v battery operates all electronics in the vehicle.
While driving my 2023 Ford F-150 Raptor, the vehicle suddenly lost throttle response. The accelerator pedal produced no response and the engine would not rev even though the vehicle remained powered on. A battery warning light briefly illuminated at the time of the incident. I was able to bring the vehicle to a stop, but during the event the steering wheel became locked or extremely stiff and the vehicle did not respond normally to inputs. After stopping, I placed the truck in park and was unable to shift the transmission back out of park. The vehicle appeared to remain powered on but multiple systems were not responding. After pressing the start/stop button and cycling the vehicle, the issue cleared and the truck began operating normally again. Prior to this incident, the vehicle had already been scheduled to go to the dealership because it had been displaying numerous warning lights and diagnostic codes across multiple systems, totaling approximately 30 alerts. The vehicle was taken to a Ford dealership for diagnosis. The dealership reported codes indicating a network communication issue between vehicle modules but stated they were unable to reproduce the failure and no repair was performed. The dealership has requested that I take possession of the vehicle despite the unresolved cause of this failure. Given the loss of throttle response and steering function while the vehicle was in motion, I currently feel the vehicle is unsafe to operate until the underlying issue is identified and corrected. A sudden loss of throttle response and steering control while the vehicle is in motion creates a significant risk of collision, particularly in traffic or at highway speeds. The fact that the failure temporarily cleared after cycling the vehicle suggests a potential intermittent electronic or communication failure affecting critical vehicle control systems.
The contact owns a 2023 Ford F-150. The contact stated that while driving approximately 50 MPH and hauling a trailer, the rear brake lights failed to illuminate. There were several messages displayed related to the trailer connection and brake lights. The contact stated that while driving at an undisclosed speed, the trailer was difficult to control, and the display screen inside the vehicle was flashing off and on. The vehicle was driven back to a storage facility. While reversing and attempting to park the trailer, the message that the trailer was disconnected from the vehicle was displayed. The cause of the failure was not yet determined. The local dealer was contacted and informed that the VIN was not included in the federal safety agency Campaign Number: 26V104000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was approximately 30,000.
The contact owns a 2023 Ford F-150. The contact stated while driving at an undisclosed speed, several unknown warning lights intermittently illuminated. The contact stated that since the purchase of the vehicle, the warning lights had been illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. On a separate occasion while driving at an undisclosed speed, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The vehicle failed to accelerate or exceed 30 MPH. In addition, an abnormal rattling sound was coming from the bottom of the vehicle. The vehicle was taken to the dealer. The vehicle was not inspected or diagnosed; however, the contact was informed that the failure might be associated with the front differential. The vehicle remained at the dealer unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,000.
⸻ Highlight Summary: My 2023 Ford F-150 (VIN: [XXX] ) has intermittent rear tail lamps, brake lights, turn signals, and backup lights failure due to water intrusion. The right side has completely failed; the left side is beginning to fail, creating a serious safety hazard at night or in low visibility. Both the dealership and Ford Customer Assistance have avoided returning calls and are denying responsibility, and this is a common problem nationwide. ⸻ Complaint – 2023 Ford F-150 Rear Lighting Failure •Vehicle: 2023 Ford F-150, VIN [XXX] , ~73,000 miles •Issue: Intermittent rear tail lamps, brake lights, turn signals, and backup lights failure due to water intrusion •Right side: completely failed; left side: starting to fail •Safety Risk: Creates serious hazard at night/low visibility, increasing risk of rear-end collisions •Dealership: D-Patrick Ford Superstore, Evansville, Indiana, E. Walnut St. •Initially could not duplicate issue •Feb 7, 2026: confirmed problem, quoted ~$3,000 for repair •Truck returned “all lights working,” but right side still not functioning •Manufacturer & Dealership Response: Ford Customer Assistance and dealership are denying responsibility and avoiding calls, leaving the defect unresolved nearly a year •Nationwide Problem: Common issue reported by many F-150 owners, indicating widespread safety defect •Request: Immediate review and corrective action for this recurring and escalating safety hazard INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On 3 separate occasions, while traveling at highway speeds on the NJ Garden State Parkway in the left lane, my truck’s service engine light soon wrench would come on out of nowhere, the throttle would cut out, and the gas pedal would go limp and unresponsive. The only way to get it operational again was to turn the truck off, let it sit for 10-15 min to drain the computers, and restart. Imagine doing 70-75 mph in the left most lane and you lose all throttle and have to get your vehicle all the way to the right shoulder without the ability to speed up to avoid being hit in the process. Now imagine that same thing happening 3 times within a month. The dealership found failed factory power train wiring and a failed gateway module. This truck’s a 2023 with 50k highway miles. Shouldn’t be failing like this. Now it’s been at the dealership for 3 weeks…..
Cabin coolant heater failed. Windshield would not properly defrost. This was recalled in our same model year with production dates through August 31 and our truck was produced on October 2.
Instrument cluster panel was rainbow now is all black unable to see how much gas in in truck tire pressure or all other important gauges.
"When driving on Interstate 15 in Draper/Bluffdale, external electronic interference forcefully disconnects the vehicle's infotainment and safety displays. This causes the main screen to go black, reboot, or freeze while moving at highway speeds (70+ MPH). This creates an immediate distraction hazard and disables navigation instructions during high-speed traffic flow. The vehicle's shielding is insufficient to protect the driver from this predictable external interference, leading to a recurring safety hazard in a known dead zone."
Regarding EV Battery Failure – 2023 Ford F-150 Lightning”} To Whom It May Concern, the federal safety agency I am writing to formally file a complaint against Ford Motor Company regarding a serious and ongoing battery issue with my electric vehicle, which remains unresolved despite multiple attempts to obtain warranty service. Vehicle Information: Vehicle: 2023 Ford F-150 Lightning VIN: [XXX] Mileage: Approximately 38000miles Warranty Status: Vehicle is still fully covered under the manufacturer’s warranty Description of the Problem: The vehicle’s battery is not functioning properly. After a full charge, the vehicle only drives approximately 50 miles, after which the battery becomes completely dead. Ford advertises a range of approximately 230 miles per full charge, which my vehicle has never achieved. The battery warning and error messages appear repeatedly on the dashboard, clearly indicating a battery-related issue. Despite this, no effective repair has been performed. Issues with Ford and Authorized Dealers: Ford Motor Company repeatedly refers me to authorized dealers. Each time I visit a dealer, I am charged approximately $140 for inspection, and the dealer claims that the battery is “fine” without providing any real fix. The problem continues exactly the same. Ford refuses to take responsibility and continues to redirect me back to dealers. Many local dealers do not even have qualified technicians capable of replacing or repairing EV batteries. They only perform basic checks, collect money, and return the vehicle without resolving the issue. This repeated back-and-forth between Ford and dealers has caused me financial loss, extreme inconvenience, and mental stress. The vehicle is unreliable and unsafe for regular use. Requested Resolution: I respectfully request the following: 1.Immediate replacement of the defective battery under manufacturer warranty, or 2.Assignment to a qualified EV service facility that can properly diagnose and replace the battery, a INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
I was driving and all of the dash lights came on simultaneously and I lost power braking ability while on the interstate. I was able to pull over and the truck shut off. I had to call a tow truck because it would not start back up. The AAA servicer reprogrammed the battery which turned all of the warning lights off except for the "push brake to start" warning and the truck will still not start because of this. The tech with AAA advised there is a recall related to this issue but my VIN search returns no results.
The instrument cluster on my vehicle has failed intermittently and/or completely, resulting in loss of speedometer visibility and loss of critical warning indicator information. This includes safety-related alerts necessary for driver awareness, such as warning lights and vehicle status indicators. Due to this failure, the vehicle is unsafe to operate because the driver cannot reliably monitor speed or receive safety warnings required for safe driving. A repair order was opened at a Ford dealership to address this issue. The vehicle is covered by an extended warranty provider, which approved a repair request related to the instrument cluster failure on December 16, 2024. The warranty provider further confirmed approval for instrument cluster replacement on December 22, 2024. These approvals confirm the defect was acknowledged and authorized for repair. Despite the safety defect remaining unresolved, the dealership closed the repair order. Ford corporate customer service has confirmed that the repair order shows as closed on their end, even though the instrument cluster failure has not been corrected and the vehicle remains unsafe to operate. Closing the repair order disrupted manufacturer responsibility tracking and reimbursement eligibility while the safety defect persists. As a result, I have incurred out-of-pocket expenses including towing, rental vehicle costs, and related transportation expenses. This instrument cluster failure constitutes a safety-related defect under DOT and the federal safety agency guidelines because it prevents safe operation of the vehicle. I am requesting manufacturer accountability and corrective action to ensure this safety defect is properly addressed and tracked.
front camera fault, service required, pre-collision avoidance not available. Lane departure warning fault, service required. This is an ongoing problem since date of purchase, 9/23/2025
While driving down the road, the driver gauge display screen completely goes dark. All information displayed normally on the screen, such as speed, mileage, and vital information about the vehicle stops, displaying entirely. This has happened multiple times. Usually the next day, the issue is solved. Then, several months later, the issue reappears. Whenever the vehicle is taken for repair, the dealer simply cannot replicate the issue. This is a known issue that has been reported online by many people.
Service vehicle Soon light came on and the problem was that the gear shifter folding mechanism broke. Ford has repaired it at no cost.
The contact owns a 2023 Ford F-150. The contact stated that while driving approximately 50 MPH and hauling a horse trailer with several horses inside, the automatic headlights activated, and the trailer brake erroneously activated, causing the vehicle to abruptly stop in the middle of the road. During the failure, no injuries were reported to the vehicle occupants or the horses inside the trailer. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 45,000.
One morning, my 2023 Ford F150 Lightning was completely inoperable. I had it towed to a dealer. From my understanding, it is a wire that runs from the front of the truck to the rear of the truck, and is in the channel about the drive train malfunctioned which seems very strange to me. Got a bunch of codes off the computer. Found some kind of module showing 0-2 volts and when wiggled, it went to zero and stayed. Circuuits CBB95 PINS 11 and 12 and ABB05 PIN 33 at C407 all had zero volts. He consulted Ford's self help and found a Ford contact who'd fixed similar issue. After researching, all was connected back up, he back probed the circuits, and finally found SBB05 grey/red Pin 5 had no current. Ford advised overlaying wire from 3471C to C407 over rear drive unit and secure to harness with zip ties. This successfully cleared all codes and truck worked. This could have been really bad if it happened during the middle of winter when driving putting me and my occupants in danger. I'm not sure what the dealer did with the part, but they replaced the wire and connectors. I had no idication there was any problem until the vehicle became completely inoperable. Ford did not cover this under warranty since i was out of the bumper to bumper warrantee mileage.
A/C airflow decreases out of the air vents although you can hear the motor blower running at high speed in the dashboard. The cabin temperature begins to increase and if humid the windows will begin to fog up the windshield, side windows and rear window impairing visibility which could lead to an accident if you do not pull over and remove the fog from the windshield/ windows. The dealership has inspected the vehicle, but they are never able to reproduce this issue while the vehicle is in their possession so they do nothing and simply turn away from the concern which many other Ford F-150 owners have expressed to their local ford dealerships and undoubtedly FORD motor company is aware of this issue, but are turning the blind eye as if it doesn’t exist. There are no warning lamps, messages or other symptoms prior to the issue occurring. I’m the second owner and this has happened to me twice within 2 weeks of owning this vehicle and I noticed the CarFax showed that my vehicle had been brought in numerous times to the ford dealership to be serviced for this exact same issue that I’m experiencing which has been confirmed by the dealership.
Driving down the road, a "service needed" code will pop up on the dash. It will then go away. However, in the next few minutes a "Shift Service Fault" will pop up on the screen. I then get a notification on my Ford app that says I have a Powertrain Fault.
Transmission harsh shifting, jerking, sudden loss of power, and unexpected downshifts. Goes into power saving mode every time I shut vehicle off. Remote start never available.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history