Check engine light on, engine is sluggish when accelerating especially from a stop. Cam phasers malfunctioning causing rough idle and issues with accelerating. This has posed a major issue when attempting to pull out into traffic and not being able to accelerate ahead of incoming traffic. Engine has actually stopped at intersections, while going through car wash, at a stop.
Ford F-150 misfire problems
447 of the 38,399 owner complaints about the Ford F-150 describe misfire or rough idle, most of them for the 2011 model year.
- owner complaints
- 447
- worst model year
- 2011
- typical repair cost reported
- $1,249
- typical mileage
- 57,629
Is there a fix? There are 10 recalls for this area of the car. See below
By model year
Often reported together
Check engine light 148Loss of power 111Stalling 66Shudder 36Engine failure 28Won't shift 21Hesitation 20Jerking 15
Trouble codes mentioned
P0305 7P0300 7P2112 5P0306 5P0304 5P0430 3U0401 2P0722 2P0720 2P0316 2
What owners say
Trace water accumulation routing from clogged/faulty drain plug to corroded DCN wiring connector during rainfall. Due to manufacturing design of '23 Ford F150 model windshield drain cowls, minor debris allowed for water to backflow into the Data Communication Network (DCN) wiring harness and Body Control Module (BCM) connectors, interior electrical components, and interior of the cab wetting the upholstery and flooring within the front passenger side of truck. Driver experienced electrical black outs within the dash and center screens, lighting failures, and multiple system alert misfires while driving the vehicle. Alerts consistently glitching on the dash screen included: Service Vehicle Soon, Pre-Collision Assist Not Available, Service Advance Trac, Rear Belt Monitor Fault Service Required. The issues were reported to Ford, whose representatives noted the history behind water damages associated with cowl/drain designs, but confirmed the issue has not been formalized for recall. This known issue presents buyers with financial and physical safety risks, known by Ford, and places full responsibility for poor engineering on new owners. The vehicle is currently at the dealership for repairs and parts replacement. All at the owners expense.
Engine failure due to oil consumption. Low compression on bank 2. Changed coil packs, spark plugs and bank 2 Catalytic converter misfires stayed. Took to dealer for diagnostics and found low compression and recommended engine replacement. Now getting new truck because of expensive engine replacement causing me to roll the negative equity to my new truck.
This recall has been going on for over a year. I don't know how long these usually take, but this recall - Manufacturer Recall Number25S75 the federal safety agency Recall Number25V455 Recall StatusRecall Incomplete, remedy not yet available My truck runs rough at times which I believe is a direct result from the fuel pump on this recall, and it doesn't give me much confidence on my daily driver truck, especially going on long trips. I don't know if this message carries any weight in the timeline on this recall, but I would really like this fixed soon so I don't have a stall incident with my family in the vehicle.
The timing belt/chain is failing on F-150 trucks and multiple people have sent in issues. i think from 2015-2018. It looks like you are already looking at other Fords with same issue. what i was told is that there could be sudden stalling: If the timing is thrown off or the chain snaps, the engine cuts out instantly. Losing power steering and engine power while driving in traffic creates an immediate crash hazard. Severe Misfires and Power Loss: A slipping chain causes rough idling, violent shaking, and an inability to accelerate which happened to the truck. Due to this i had to get mine fixed in June of 2024 i have attached the invoices. I tried to upload invoice but said there was an error
I purchased a 2022 Ford F150 in September 2024. I began to notice occasional sluggishness when accelerating as the weather warmed up around March 2025. I contacted my local Ford dealership sharing the issue. The service manager suggested I consistently use a high octane fuel, which I consistently do, explaining I may just have "bad gas". The problem continued primarily when I was in heavy traffic with high temperatures. The truck acted as if it had a clogged fuel injector, sluggishness from start, low idle reducing below 1,000 RPM. I contacted a privately owned mechanic shop advising of my idle issues. The mechanic stated he doesn't believe a fuel injector would clog at 50,000 miles. In June 2025 received notification of a recall for my vehicle which I confirmed by VIN. The recall (#25V455) summarized the vehicle could sustain a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. The letter continued, I may experience poor engine performance, rough idle or reduction in power, the same issues I had been complaining about. I contacted the Ford dealership and they explained Ford had not determined how to remedy the problem. Fast forwarding to present, 3 August 2026, over a year since the recall letter and Ford has yet to remedy the problem. What's the hold up? Will Ford finally determine the remedy when my family is killed on the interstate because the vehicles fuel pump fails and it stalls? It appears to be apparent Ford does not want to take the financial hit of such a recall. This is unacceptable and needs to be looked into by the NTSB.
Truck has just started misfiring out of the blue, have had Ford dealerships look at it, have changed all 6 spark plugs and one ignition coil. The recall the federal safety agency 2025-366 may be the reason, it states there still is no remedy for this, recall was issued 1 year ago, July 2025. I need this remedy.
The truck’s fuel system can cut out under acceleration. This is very dangerous. Various times it has nearly stalled out under acceleration while trying to merge. The worst time was driving up a bridge, the truck began to hesitate nearly causing a crash. Every time it signals cylinder misfire, but that whole system has been replaced. Very dangerous, very disappointing.
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, there was a misfire coming from the engine. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The contact received notification of the federal safety agency Campaign Number: 24V455000 (Fuel System, Gasoline); however, the part for the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,000.
85,000 miles Tam phaser and timing system fail along with misfires fuel injector. At 115,000 miles engine failure on the freeway.
Related recalls
Engine and engine cooling: cooling system: hoses/lines/piping/fittings
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2025 F-150 trucks. Contact with the engine coolant hose may chafe the engine wire harness or cause a pull out of the Powertrain Control Module (PCM) connector pins, causing the engine to stall.
- Risk
- An engine stall increases the risk of a crash.
- Remedy
- Dealers will inspect, replace the engine wire harness as necessary, and relocate the engine coolant hose, free of charge. Owner notification letters were mailed September 12, 2025. The parts are anticipated to be available the third quarter of 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S63.
Recall number 25V398000 · Recall details
Engine and engine cooling: engine: hard parts internal/mechanical
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
- Risk
- A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
- Remedy
- Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S55.
Recall number 25V344000 · Recall details
Engine and engine cooling: engine: oil/lubrication
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Expedition, and 2024 Lincoln Navigator vehicles equipped with 3.5L GTDI engines. The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.
- Risk
- A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
- Remedy
- Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S30.
Recall number 25V198000 · Recall details
Engine and engine cooling: engine: oil/lubrication
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, 2024 Expedition and 2024 Lincoln Navigator vehicles equipped with a 3.5L GTDI engine. The engines may have a misaligned engine cup plug, which can result in a rapid oil leak.
- Risk
- A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
- Remedy
- Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed on May 23, 2024. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 24S70.
Recall number 24V851000 · Recall details
Engine and engine cooling: engine: hard parts internal/mechanical
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
- Risk
- A loss of drive power increases the risk of a crash.
- Remedy
- Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 24S55.
Recall number 24V635000 · Recall details
Engine
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
- Risk
- A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
- Remedy
- Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 20S08.
Recall number 20V098000 · Recall details
Engine
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
- Risk
- A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
- Remedy
- Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 19S11.
Recall number 19V278000 · Recall details
Engine
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
- Risk
- When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
- Remedy
- Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S45.
Recall number 18V894000 · Recall details
Engine
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with 3.5L engines. The cylinder heads may have been machined without lubrication supply holes for the camshaft bearing journals.
- Risk
- Without a proper supply of lubrication, the engine will fail, causing a stall and increasing the risk of a crash.
- Remedy
- Ford is not aware of any affected vehicles outside of dealer control. Should owner contact subsequently be required, arrangements will be made to transport their vehicle to a Ford or Lincoln dealer to have the engine replaced.The recall began October 24, 2017. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 17S37.
Recall number 17V672000 · Recall details
Engine and engine cooling
- What is wrong
- Roush is recalling 213 my 2007-2008 ford f-150 trucks altered to operate using liquid propane injection. The hydro-carbon paper affixed to the inside of the airbox lid with adhesive may become dislodged during operation.
- Risk
- This failure may result in a loss of performance, illumination of the malfunction indicator lamp (mil) and, in extreme cases, a stalling of the vehicle during operation without notice, which could result in a crash.
- Remedy
- Dealers will replace the airbox lid with a new one that includes the hydro-carbon paper which has been affixed using an adhesive promoter and greater pressure as recommended by the manufacturer free of charge. The recall began on october 21, 2008. Owners may contact roush at 1‑866‑307‑6788.
Recall number 08V523000 · Recall details
Questions about the Ford F-150 misfire
Which Ford F-150 years have misfire or rough idle problems?
The model years with the most reports are 2011 (86 complaints), 2012 (73 complaints) and 2013 (34 complaints).
How much does it cost to fix misfire or rough idle on the Ford F-150?
Owners who mentioned a price put the repair at about $1,249 (median of 52 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history