Ford F-150 oil consumption problems

Filed Oct 19, 2026 · Engine · NY

Excessive oil consumption of approximately 1 qt every 1000 miles. I am filing the oil to the acceptable level monthly.

Filed Sep 11, 2026 · Engine · TX

Engine failure due to oil consumption. Low compression on bank 2. Changed coil packs, spark plugs and bank 2 Catalytic converter misfires stayed. Took to dealer for diagnostics and found low compression and recommended engine replacement. Now getting new truck because of expensive engine replacement causing me to roll the negative equity to my new truck.

Filed Sep 9, 2026 · Transmission · AL

Transmission slips gears and sometimes shifts violently. I took the truck to a Ford dealership for an assessment and was told I need to replace the whole transmission. I also have a problem with oil consumption from the engine. I was told by the same dealership that this was a known problem with the 5.0 engines built from 2019 to, I believe 2023 and that it would require an engine replacement. I bought this truck from an individual and now I am stuck with it.

Filed Sep 8, 2026 · Engine · PA

My 2020 Ford F-150 (5.0L V8) experienced a sudden loss of engine power and stalled completely while I was driving. In the days leading up to this, the check engine light had illuminated, and I later discovered the vehicle had consumed a severe amount of engine oil — the dipstick read below the "add" line. Critically, no low oil pressure warning light or audible chime alerted me to the oil loss before the stall occurred. After the initial stall, the engine continued to struggle to maintain idle and stalled repeatedly whenever RPM dropped to approximately 1,000, making the vehicle unsafe to drive. I had the vehicle towed to a Ford dealership for diagnosis. The dealership's estimate confirmed the need for a full engine (long block) replacement, at a cost of approximately $19,824.56 (total estimate $21,491.04). I am aware that Ford issued Technical Service Bulletin 19-2365, which acknowledges that 2018-2020 F-150 trucks with the 5.0L engine may experience excessive oil consumption exceeding one quart per 3,000 miles with no visible external leaks, attributed to oil being drawn into the engine during deceleration fuel shut-off events. I believe this defect directly caused my vehicle's stalling and oil starvation, and that the lack of any dashboard warning prior to the failure is a separate and significant safety concern, since a driver has no way to know the engine is being damaged or that a stall is imminent.

Filed Sep 3, 2026 · Engine · MA

We purchased a used 2020 F­150 in late summer 2024. We brought it in for issues in November 2024, but the Ford dealership found no repairs were needed. We returned in March 2025 when the CDF drum failed requiring a transmission rebuild, a known issue with Technical Service Bulletin but not a recall. The engine continued consuming oil after this despite Ford completing all applicable service bulletins and advising there was nothing further to do. We took the vehicle in for service in May, 2026 and were told they had already updated software to address the oil consumption and we were told that should resolve the issue. On June 30, 2026, the truck was towed to the dealership after repeated stalling and a check engine light. The dealership again acknowledged this is a known issue with this engine - the valve seals are defective yet they had stalled our concerns so long at this point, we were past the warranty period. We researched and found this was a widespread, known issue asked whether Ford would offer customer loyalty assistance after 30 years of Ford ownership. We were told the truck's approximately 118,000 miles exceeded the assistance threshold. The engine replacement was quoted at $15,000. Ford advised us to repair the engine and save our receipt in case they should issue a recall at some point in the future. Given the value of the truck was $15,000 we chose not to keep investing in this vehicle and sold it for parts at a loss.

Filed Aug 13, 2026 · Transmission · FL

What happened is i bought a truck that Ford knows good & well has a defective CDF drum and outer shell but they refuse to issue a recall to fix the transmissions in those year models! Yet in late 2022 they acknowledged the problem and updated the 22+ year models with the correct parts while leaving those of us with the prior 4yrs of trucks out in the cold! My truck is currently undergoing getting a new transmission and it hasn't even reached 70K yet. At 61K I had to have all timing components along with a new oil pump replaced due to the common oil consumption issues on the 13th gen models. Now 8K miles later I'm having to have a new transmission because it started with all the common problems and known issues that everyone else has had with the 13th gen trucks. This is absolutely ridiculous and no if's, and's or but's about it Ford should be liable for it! Every single one of us especially those of us below 100K should be reimbursed. It is a disgrace to own and pay for a vehicle that spends more time at the shop than it does in your driveway! I am fuming mad. Due to my age and health condition this was supposed to be the last vehicle I ever buy yet being on a fixed income I now have a truck that I cannot trust to get me safely to my Dr's appointments or even the local places I have to visit on a weekly basis. Absolutely ludicrous! I have all invoices of all work that has been done and that info has also been put into the Carfax records. The shop i use is very proficient when it comes to recording the information. Within a week once the new transmission is installed I will have that invoice as well as it being loaded into the Carfax records.

Filed Jul 27, 2026 · Engine, Transmission · AL

I. Vehicle Purchase and Maintenance History In September 2020, I purchased this 2020 Ford F-150 new. II. Chronology of Defect and Repair Attempts Around 33,000 miles, the vehicle began exhibiting severe excessive oil consumption, an audible engine noise, and visible blue/gray smoke puffs emitting from the exhaust system. The following timeline outlines my exhaustive efforts to have Ford remedy this under warranty: • March 14, 2025 (36,370 miles): First formally reported the noise and exhaust smoke to Service Advisor Shelby Ray. The dealership initiated an official Ford Oil Consumption Test. I was instructed to drive 1,000-mile increments and return for unrecorded level checks. • May 21, 2025 (38,200 miles): Second formal report. The dealership performed Technical Service Bulletin (TSB) 192365 CP:6006, an established protocol recognizing inherent oil consumption flaws in this specific 5.0L engine. • August 7, 2025 – September 11, 2025 (41,119 miles): Third formal report. The vehicle was left at Tony Serra Ford for over a month (RO # 6034434) to perform engine repairs mandated by Ford tech lines. A loaner vehicle was provided. • December 9, 2025 (44,144 miles): Fourth formal report. The defect was noted as unresolved and still present between oil changes. The engine was found to be 2 quarts low on oil upon arrival. A new tech line case was opened. • May 7, 2026 – Present (48,086 miles): Fifth formal report. The engine noise and exhaust smoke. Truck has been at dealer for 3 months with no resolution.

Filed Jul 1, 2026 · Engine · WI

2019 F150 5.0 v8 Coyote engine consuming oil excessively even after TSB - 19-2365 Exhaust/Engine smoking on startup no matter what time of year.

Filed Jul 1, 2026 · Engine · AL

Back in Jan 2025 I noticed oil consumption from 2020 F150 with the 5.0 engine. There is class action lawsuit against Ford currently for this problem they know they have. I informed my local dealer, that has always serviced my tuck on time over the years, that it was smoking. I have owned this truck since new in Sep 2020. It had roughly 33K miles on it when I first noticed it. The dealership started running consumption test on it under warranty at 36,370 miles. They changed the oil regular for the test and instructed me to drive it 1000 miles each time between changes. One change before they tried to fix it, it had consumed 5 quarts of oil. Ford says 1 quart per 10K miles is normal. They changed several motor parts when it was at 41,121 which took about a month. The problem got worse and I informed them and they again started testing it again and instructed me to drive it 1000 miles each time. They pushed the milage up and also ran it over on the warranty time frame and it has been at their location for over a month now, and Ford doesn't want to pay for a motor that only has 48,086 miles on it due to being out of warranty. They knew this problem existed and caused the warranty to laps and never fixed it. Now they are asking me to pay $11,598.42 for a new motor they knew was bad 15k miles before warranty went out. I am going through steps to make someone aware of this issue I'm currently dealing with. This motor has this problem, and they knew it and never fixed it and intentionally ran my warranty out so they would not have to cover it.

Filed Jun 18, 2026 · Engine · VA

Had the truck 4 weeks from dealer and it was 5 quarts low on oil!! Got oil change. Another month passes and it was almost 2 guards low. Took it to shop they can’t find a leak. Another month passers and it’s 1.5 quarts low again! Every month have to put 1.5 to 2 quarts in it!!! Have not even had it 6 months yet! Must be a lemon!!!