1997 Ford F-250 SD technical service bulletins
42 technical service bulletins and manufacturer communications cover the 1997 Ford F-250 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- General (PCM) power train control module programming procedures
- Loss of power and malfunction indicator lamp may also illuminate with diagnostic trouble codes 128 and 845...
- Moaning noise during 1500-2000 RPM on neutral engine run-up, or while driving under load
- Rough idle and engine miss due to injector bore scuffing at green engine break-in
- New transmission cooler flusher - service tips
- Malfunction indicator lamp (MIL) illumination with diagnostic trouble codes P0442, P0455, P0456, P0457,...
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing...
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Transmission- E40D/4R100-1989-99-MAIN controls, separator plates and separator plate gaskets usage chart
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may...
- Information regarding the new transmission cooler flusher- service tip
- Subject regarding 4R100 transmission flexplate replacement for vehicles with 7.3L diesel engine
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Information on the new flush and fill tool available through rotunda
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (NVH)...
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Subject regarding door trim panel replacement - service tip
- Information regarding reprogramming powertrain control modules (PCMS)
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Some trucks with E40D and california calibration 7-90P-R10/11 may stall during long decel conditions while...
- Exhibiting rough idle and engine miss due to injector bore scuffing at green engine break-in
- Locks failed
- Exhaust leak at exhaust manifolds--vehicle equipped with 7.0L 0R 7.5L engine
- Information on a new transmission fluid usage chart
- Some customers may require a heavy duty 7-WAY trailer wiring connector system when the vehicle is equipped...
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio
- Some vehicles may experience a popping / squeaking noise in the steering column while turning
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- A comprehensive pull and drift diagnostic procedure has been developed to assist technicians in helping to...
- A vibration or shudder may be felt during braking on some vehicles
- Lubricant leaking from rear axle seal contaminating brake shoes
- Availability of hub-mount brake rotor machining equipment
- Experiencing an engine stall condition on 1997 california f series 7.3L diesel E40D vehicles after a long...
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings
- Conditions with engine stalling during long decel while in manual 1 or manual 2 gear on some vehicles
- Information on the defroster performance enhancement.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Ford F-250 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history