2004 Ford F-250 SD suspension problems

Filed Dec 30, 2013 · Steering, Suspension · 23,900 miles · AZ

Front end shakes violently after hitting a rough spot on pavement at highway speed. Continues until speed is reduced to less than 50 MPH. There are several other complaints on your database for the same problem, so why isn't something being done about it? This is a very serious issue. My wife would not have been able to handle this happening to her. This happened once before about a year ago and I had the truck checked, but nothing could be found. Even though it's ten years old, truck only has a little over 24,000 miles.

Filed Apr 10, 2013 · Suspension · 40,000 miles · FL

Tl* the contact owns a 2004 ford f-250 sd. The contact stated that while driving approximately 45 MPH, the vehicle starting bouncing abnormally. The vehicle was taken to the dealer where the failure was unable to be duplicated. The contact mentioned that the vehicle was taken for diagnostic testing on several occasions for the same failure. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 40,000 and the current mileage was 180,000.

Filed Jun 24, 2012 · Steering, Suspension · 136,560 miles · VA

Traveling at regular motorway speeds (55 - 70) the truck vibrates violently and constantly. It stops once the vehicle slows to below 30mph. I have checked other complaints and will be checking tire pressure and seeing it a steering dampener can be added. This vehicle was unloaded at the time of the incident and had about 1/2 a tank of fuel on board.

Filed Jul 9, 2010 · Suspension · 94,565 miles · NC

I have a ford f250 super duty 4x4 with 94000 miles. I took it to get the tires aligned and was told the upper and lower ball joints were extremely worn. After getting home I found this website [ http://www.topix.com/forum/autos/ford-f-250-super-duty/tjddvleksir1jmv0j ] and it seems this is a common problem that is happening at low mileage on these trucks. This has probably been an on going issue with my truck but I didn't know it until I noticed extreme tire wear then it was to late. I believe this to be a safety hazard because the possibility of lose of control of the vehicle at total failure.

Filed Nov 8, 2009 · Steering, Suspension · 70,000 miles · FM

Vehicle shimmy and shake, steering wheel oscillation starts at approx. 50 MPH after going over slight bump in roadway. Continues until brakes are applied and speed is reduced to under 45 MPH.

Filed Oct 27, 2009 · Steering, Suspension · 58,246 miles · WA

On 2004 ford super duty, f-250, the dealer service department stated that the left front ball joints were loose. The vehicle has 58,246 miles on it with no accidents or misuse. This is pre-mature failure of major suspension parts. The dealer service department also stated that ford knew there was a problem with the ball joints due to the weight of the engine.

Filed Jul 13, 2009 · Suspension · 94,000 miles · PA

I own a ford 250 super duty 2004. Since february 2009 I have sporadically experienced uncontrollable wobbling of the steering wheel. It appears that it happens after making sharp turns or bumps and doesn't matter with the speed. I've taken the truck to a service center and 3 or more times they've taken it apart and can't find anything. They suggested taking it to a ford dealer. I did and explained it to the mechanic upon which he claims he's never heard of such a thing. As a last resort I googled ford 250 shaky steering and found what they call "ford death wobble". To my surprise there are numerous other accounts of this with people as confused as myself and my mechanics. From reading it appears that ford is aware but denies the existence of this happening. Also saw that I could at least complain to someone who may listen. My concern is crashing like some of the other unfortunate people and ford getting away with no consequences.

Filed May 6, 2008 · Steering, Suspension · 80,259 miles · FL

My 2004 f250 2wd superduty pickup shakes violently whenever I hit the smallest pothole or drive over railroad tracks. This caused my right tie rod to separate and run three people off the road. After new tie rods the problem still exist. This truck only has 81,000 miles on it .no one has any explanation as to what to do to fix this other than an after market steering stabilizer. Shouldn't ford be responsible for this fix before someone gets killed?

Filed May 2, 2008 · Suspension · 60,000 miles · IL

Daqte below is most recent date - experienced bounce, nearly into adjacent traffic lane as a result fo passing over rough spot on interstate highway - has occurred a number of times since 2006. Just became aware of this as a larger issue from good sam club.

Filed May 1, 2008 · Steering, Suspension · 22,000 miles · CA

At about 45 to 55mph truck sometimes develops a light shimmy in the front end. It occasionally becomes very severe feeling like the whole front suspension is about to come apart. It is especially prevalent when there is a slight left pressure on the steering wheel, like when changing lanes. Slowing will eliminate the bounce, but it is difficult to slow quickly when the front end is bouncing and severely vibrating. It causes a near total loss of control.