1993 Ford F-250 technical service bulletins
88 technical service bulletins and manufacturer communications cover the 1993 Ford F-250.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- New transmission cooler flusher - service tips
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- TRANSMISSION-E40D-NO 2-3 upshift
- Transmission- E40D/4R100-1989-99-MAIN controls, separator plates and separator plate gaskets usage chart
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may...
- Information regarding the new transmission cooler flusher- service tip
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Information on the new flush and fill tool available through rotunda
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making...
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
- Front end shimmy may occur at various driving speeds and is usually induced when hitting bumps, such as...
- Information on a new transmission fluid usage chart
- Information on tire company telephone numbers for customer assistance
- Information on a buzzing or rattle noise from the exhaust system
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Service tip information regarding elimination of sanding rotors and drums
- Recommended guidelines for towing behind recreational vehicles
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable
- Some vehicles may exhibit excessive brake pedal travel, irregular front lining wear, and brake pull
- The rear parking brake cables may bind and not allow the rear brake shoes to return fully to the anchor...
- The parking brake pedal may go to the foor with little or no effort during application
- Front caliper piston boots damaged
- Availability of hub-mount brake rotor machining equipment
- Announcing the ford OEM air conditioning retrofit kit availability
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers
- Information on the defroster performance enhancement.
- Performance enhancement for defroster
- Some vehicles may develop "cavitation" erosion in the cylinder wall of the engine
- Part number information for the use of a child seat tether
- New clutch slave cylinder with a redesigned lip seal
- Headlamp- headlamp housing melts- ambulance and emergency vehicles only
- Fuel economy- customer expectations versus vehicle usage
- Fluid- transmission fluid usage charts
- Frame- rivet replacement with bolts- service tips
- Accessory drive belts- fead belt comes off- vehicles with 4.9L engine
- Exhaust leaks or noise at the joint between the y-pipe and the exhaust manifold
- The clutch may be hard to depress due to dust/contamination entering the slave cylinder
- Noise- "popping/creaking"- front frame or suspension brackets- frame- "popping/creaking"- fastener replacement
- Pop/clunk from steering linkage over bumps
- Diagnostic guides for out-of-warranty vehicles to be used as a master copy - diagnostic guides no longer...
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning...
- Wiring - electrical diode identification and service replacements
- Torque converter - leak test procedure - service tip
- Brakes - rear parking brake cable binds - vehicles built before 8/20/96 - all chassis cab vehicles are...
- Vibration - driveline vibration and/or driveline noise - regular cab 4X4 vehicles equipped with 7.5L...
- Pop/clunk from steering linkage over bumps
- Information on aode/4R7W transmission main control & case replacement
- Vehicles may exhibit a driveline vibration or noise while driving at highway speeds on steady cruise or decel
- Windshield and interior glass - fog/film
- Brakes - elimination of sanding rotors and drums - service tip
- Air conditioning - compressor failure - insufficient amount of refrigerant oil
- Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0L or 7.5L engine
- Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds
- Service tip information regarding the reverse clutch piston and piston seal usage
- 4X4 front axles must use hypoid 4X4 gear oil p/n F1TZ-19580-A & high temp 4X4 front axle & wheel bearing...
- During highway deceleration or engine start-up, there may be a hooting noise coming from the engine...
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because...
- Generator-motorcraft 95AMP-FRONT bearing CONCERN-FD1060/1460 engines- vehicles built before 7/3/95
- Engine- 'knocking' noise - when operating engine at 200-2300 RPM - FD1460 engine
- Vehicles experiencing occasional harsh reverse engagement concerns
- Steering gear-replacement of bendix, steering gear with new ross steeering gear
- Revised design transmission rear case bushing
- Delayed forward engagement and/or heat stained forward clutch plates after installing center support service
- Lack of power or no start condition may be due to exhaust restriction caused by a plugged catalytic...
- Unknown
- Hydromounted cab - evaporative emission lines rubbing on the fender
- Accessory drive belts - all 7.3 idi diesels come off accessory drive pulleys - vehicles built after 2/15/92
- Vehicles with manual transmission may have a lack of power or no start condition caused by a plugged...
- Some vehicles may exhibit a lack of power or a no start condition due to an exhaust restriction
- A rattle from the split seat bench may be due to a loose or missing seat bushing
- Knocking noise on initial start-up
- Under hood wire harness may become chafed
- Some diesel powered vehicles are experiencing drive belt tracking concerns due to front end accessory...
- There may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock...
- Revised oil pan gasket
- Early wear of fead tensioner pulley on vehicles with 5.0L/5.8L engines
- New design transmission range sensor
VIN decoder
See the problems and recalls for an exact car
Buying a used 1993 Ford F-250?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history