2000 Ford F-250 technical service bulletins
89 technical service bulletins and manufacturer communications cover the 2000 Ford F-250.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Service tips before arc welding on the frame or body of a unit
- A cold weather reverse engagement stall
- General (PCM) power train control module programming procedures
- Vehicle lean sag when observed from rear of vehicle
- General power train control module (PCM) programming procedures
- Multiple vehicles - fuel level indication concerns - service tip
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost
- Malfunction indicator lamp (MIL) illuminated - system lean diagnostic trouble codes (dtc's) - service tips
- Excessive drive-away shudder or vibration under moderate to heavy acceleration from a stop
- Air bag light on with diagnostic trouble code (DTC) B1871 or B1935 following ecs/rcm replacement
- Oil/dust film at cac connections
- Oil leak at high pressure pump fittings and/or plug
- Squeaking noise coming from the upper door seal when driving over bumps
- Malfunction indicator lamp (MIL) illumination with no hard fault
- Rough idle and/or hesitation when acclerating on certain super duty vehicles equipped with a 5.4L or 6.8L...
- Gradual loss of power at cruise
- Engine-cylinder head deck LEAK-4.6 and 5.4L engines-new service-only gasket and cylinder head kits...
- Engine-light tick or rattle type noise from engine after cold start
- Some vehicles equipped with 4.2L, 4.6L and 5.4L engine may exhibit a lack of power condition
- Subject regarding heater hose to fuel rail flex line inspection
- Some vehicles equipped with a 5-SPEED mazda R2 manual transmission may exhibit a high effort condition...
- Information on vehicles exhibiting a perceived poor fuel range / economy, and or a faulty fuel gauge
- Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start,...
- Concerns with low power while in reverse
- Subject regarding 198196 bolt-on steering stops service group, all models 0307, HR0307A and HR1000A
- Some super duty f series equipped with pto capable transmissions may exhibit a failure to go t high idle...
- Concerns with corroded positive starter cable
- Some vehicles may exhibit a fuel fill valve sealing condition
- Concerns that some trucks may exhibit a loose / detached rear window halo trim gimp moulding
- A condition may exist where a driveline vibration and / or a transmission fluid leak from the extension...
- Some vehilces equipped with 4.6L romeo engine and manual transmission only, may exhibit a check engine...
- Inoperative or inaccurate speedometer as well as 4X4 light inoperative and / or diagnostic trouble code...
- Some vehicles may exhibit a no crank / no start condition in temperatures below 12 degrees c (10 degrees f)
- A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes...
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Vehicles may experience severe vehicle vibration, due to front driveshaft maybe one inch too long
- Some vehicles may exhibit an inoperative courtesy, glove compartment, underhood, running board lamps,...
- Concerns with rear brake noise
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt
- Inoperative or inaccurate speedometer, 4X4 lamp illuminated and / or diagnostic trouble codes (DTCS) P1635...
- Some vehicles equipped with a manual transfer case may exhbit an inoperative speedometer
- Concerns with courtesy, glove compartment, underhood, running board lamps; power windows; radio; and rear...
- Exhibiting a crackling / popping noise from the exhaust
- Information regarding erractic remote entry functions-new gem released
- Information regarding transfer case hall effect encoder tips
- Some vehicles may exhibit a delayed operation / inoperative instrument cluster with koeo or koer
- Exhibiting a delayed operation / inoperative instrument cluster with koeo or koer
- Some bi-fuel vehicles may require powertrain control module (PCM) replacement during service and may not...
- Information regarding change to the location of the ashtray
- Concerns with erratic remote entry functions
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may...
- Some vehicles may exhibit interior lights, power windows and / or inoperative running board lights for a...
- Some vehicles with 4.6L, or 6.8L engines may exhibit a roller finger follower coming off during engine...
- Some vehicles equipped with 10.50-INCH ring gear, full-floating rear axles may exhibit a leak at the...
- Concerns with vehicles exhibiting a windshield creak / squeak
- Vehicles may experience inner fender well- dented or dinged from stones being thrown into wheelwell
- Some vehicles may exhibit a crackling/popping noise from the exhaust, vehicles built between 11/1/97 and...
- All vehicles may exhibit an inoperative or inaccurate speedometer, 4X4 light inoperative and/or DTC P1635...
- Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range
- Some vehicles built between 11/1/97 and 12/8/99 may exhibit a crackling/popping noise from the exhaust
- On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off...
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble...
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks
- Some vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
- Some vehicles may require adjustment to the front end alignment settings to address tire-wear or vehicle...
- Engineering is currently investigating a condition where popping / cracking sounds CAN be heard from the...
- Service procedure for orange service tagged 4T100 transmissions
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Subject regarding front wipers operating while switch is in off position
- Exhibiting ABS codes of B2141 or B2477 following replacement of a gem module
- Some vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Information regarding the winners of the edsr of the month quality awards for the month of august
- (Continued from 13251 and 13252) uncommanded front wiper function. mjs
- Some vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer...
- This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal /...
- Concerns with outside passenger or driver side mirror slightly fulttering / shaking at highway speeds
- This online service bulletin mentions that late built regular cabs will not offer a tool box tray located...
- Vehicles built after 7/31/99 will no longer be equipped with a shield covering the starter relay and C120...
- Engineering is investigating all brake concerns on vehicles exhibiting brake noise
- Concerns with vehicles exhibiting a flicker in the dash lamp when switching from the headlamp to the park...
- Some vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer...
- Vehicles may exhibit an outside passenger or driver side mirror slight flutter / shake at highway speeds
- Experiencing windnoise at the top of the door glass seal / weatherstrip molding area
- Brief information regarding the discontinued tool box
- Subject regarding discontinue of the engine compartment beauty shield
- Some vehicles may exhibit a flicker in the dash lamps when switching from the headlamp to the park lamp...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2000 Ford F-250?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history