1992 Ford F-350 fuel system problems

Filed Aug 7, 2017 · Fuel system · 130,000 miles · MT

Tl* the contact owns a 1992 ford f-350. While fueling the vehicle, the fuel was transferring to the rear fuel tank and overflowing. The failure caused fuel to leak out onto the ground. The vehicle was taken to kalispell ford, in kalispell mt 59901, but the recall had expired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the federal safety agency campaign number: 93v125000 (fuel system, gasoline). The approximate failure mileage was 130,000.

Filed Jun 4, 2004 · Fuel system · 45,000 miles · ID

The defective check valve within the fuel pump assembly causes a portion of the unused fuel from one tank to be returned to the second tank. When this occurs, the capacity of the second tank can be exceeded, causing fuel spill. Spilled fuel can result in a fire when exposed to the source of ignition. *ak the consumer contacted the dealer who indicated that the recall had expired and that they would not fix it under the recall.

Filed Aug 12, 2003 · Fuel system · MD

Consumer states that vehicle is leaking fuel. Dealer notified.

Filed Feb 25, 2003 · Fuel system · IL

Fuel leaked out of the front tank.

Filed Oct 28, 2002 · Fuel system · IL

Consumer states that when they had recall done, dealership forgot to install a part stated in the recall. Which cause recall redeem to fail. Went back, they corrected the problem, but later on problem reaccured. Ts

Filed Mar 30, 2001 · Fuel system · NE

When filling fuel tank, one tank would overflow into other tank and cause a spillage from that tank. Fuel tank repaired under recall a second time as goodwill gesture. Currently, service manager refusing to do repairs again. 2nd owner.

Filed Sep 10, 1999 · Fuel system · VA

The vehicle had been leaking fuel from front fuel tank. Had taken vehicle to mechanic & was informed the tank had rusted & needed replacing.

Filed Jul 17, 1999 · Engine, Fuel system · CA

Hers is a list of all failures since new. Rear axel seals, sway bar brackets, catalytic converter, ECM module, front seal on transmission, fuel pump, speedometer (twice), turn signal switch, water pump and now starting to leak again.

Filed Mar 29, 1999 · Fuel system · AZ · fire

Tire debris severed the filler neck region of vehicle causing gasoline to spill on roadway and come into contact with the undercarriage which resulted in fire.

Filed Sep 24, 1998 · Fuel system · CA · fire

Dual rear tire expolded and severed the rubber fuel fill line to the fuel tanks and immediately set the truck on fire. Truck, trailer and boat all burned.