1996 Ford F-350 brakes problems

Filed Aug 4, 2007 · Brakes · 174,400 miles · CA

1/07 squeak in front left wheel, took to sears as brakes/bearings under warranty. Ended up w/ complete brake job front & rear. Picked up vehicle, poor pedal pressure, no e-brake. Took back to sears they adjusted. In april had rear brakes fail to stop vehicle while pulling horse trailer. Only front brakes engaged. Took back couldn't find a problem. Took to another shop they found only pads replaced on rt rear not on left. They did complete brake job on rear (new drums and pads) took in 2 weeks later still not correct and had vibration when braking. Ended up with re-surface of front rotors and new pads. 7/29/07 pulling horse trailer rear ended vehicle on 19th ave in sf due to rear brakes not engaging at all. Only fronts engaged. Rear brakes not working at all.

Filed Nov 7, 2005 · Brakes · 91,773 miles · NJ

Dt: the contact complained about a brake problem. The brake fluid caused corrosion on the brake fittings. On august 7, 2003 the front brakes failed while the vehicle was going up hill. The ford dealer replaced the tubing and fittings. On may 24, 2004 the rear brakes failed while he in a parking lot. Again the ford dealer replaced the tubing and fittings. On november 1, 2005 the master cylinder experienced corrosion at the brake fittings, causing the brakes to fail. There was brake fluid pouring out of the front driver side wheel. Another dealership drained the brake system and replaced the line. The problem has not recurred. *ak updated 11/29/2004 -

Filed Jun 22, 2003 · Brakes · 76,000 miles · MI · crash

Stepped on brake to release the parking brake and the brake peddle went to the floor, causing me to hit a post. On investigation I found the brake line to the rear wheels rotted in the middle. All other lines in the area are like new. I have owned much older vehicles without having brake line problems. I believe the material in these lines are quite inferior and dangerous for a vehicle. I had just been towing my fifth-wheel trailer the day before.

Filed Jun 2, 2002 · Brakes · OH

Drove this truck over 1000 miles this trip and parked it for 2 weeks. Then to travel a short distance brake pedal went to the floor first time to apply brakes.found brake fluid running off frame, and had mechanic inspect for problem.found brake line that goes to the rear brakes was rotted the full length front to rear. All other lines(fuel,etc) in the same area were in good condition.new line was installed..

Filed Apr 23, 2001 · Brakes · SC · crash

On a rainy day, rear brake lining grabbed actuating the ABS system. As I have found, this problem is discussed in ford tsb 9805a24a. The brake pedal fell as additional pressure was needed to stop. Described as "normal" in special service message 03731. (a nice way to describe a problem that you do not want to fix.) the ABS brakes stopped pumping. The system then appeared as though no brakes were applied. The truck was not slowing down. Either the back brakes and possibly the front were not functioning at all, or all 4 wheel were locked up and the truck was sliding. (tires were all in good condition.) I was forced to put the truck into a ditch in order to avoid the vehicle in front of me. Later testing on a wet surface revealed that I would have been better off to pump the brakes, something that manufacturers of ABS systems advise you not to do. As I understand from reading information by others who have had the same problem, the vacuum supply on the system is not sufficient to handle repeated operation by the ABS system. I still am not sure what the condition of the wheels were at the point when I had to leave the road, whether the front were rolling, or locked and whether the back were rolling or locked.

Filed Sep 4, 2000 · Brakes, Transmission · CA

No summary( dot number: tire size: 235-85r16 )

Filed May 4, 2000 · Brakes · MI

On two occasions rear brake shoes have expanded when brakes were applied, and stayed in contact with the brake drums, causing excessive wear and brake failure.

Filed Nov 18, 1999 · Brakes · PA

While driving at 55 MPH and without prior warning the front brake rotors cracked. Ford refuses to admit that they have a problem with brake rotors.

Filed May 11, 1999 · Brakes · GA

Power brake vacuum pump failed, resulting in loss of power brakes. The dealer has been notified.

Filed Feb 26, 1999 · Brakes · TX

Brakes will either grab hard or will not stop, and consumer will have to downshift.dealer has replaced calipers/rotors and drums ,and still cannot determine defect.