2001 Ford F-550 SD fuel system problems

Filed Jan 9, 2019 · Fuel system · 150,000 miles · GA

Fuel tank delamination leading to stalling and eventual replacement of tank at my cost.

Filed Nov 2, 2011 · Engine, Fuel system · NC

This being 2nd diesel ford truck that has had same issue....losing power , blowing smoke. On this 2001 , I have replaced numerous filters, drained tank to clean ,wire harnesses,fuel injectors only to replace motor within a month or so due to contamination to system also transmission was replaced before new motor which I feel could of been due to strain on vehicle....needless to say the truck has started the same problem again.I have sank so much into it I'd never get my money out of it if sold.I feel that ford should be held responsible for this issue and all the money people have put out to correct the issues occurring, with hundreds of others. This issue is very dangerous when your trying to get home and it stalls out when driving due to loss of power.

Filed Jun 14, 2011 · Fuel system · TX

Tl* the contact owns a 2001 ford f-550 sd. The contact stated that the vehicle failed to start. The vehicle was taken to the dealer who diagnosed that the failure occurred as a result of paint delaminating inside of the fuel tank. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was unknown.

Filed Jun 14, 2011 · Fuel system · TX

Tl* the contact owns a 2001 ford f-550 sd. The contact stated that the vehicle stalled without warning. The vehicle was taken to the dealer who diagnosed that the paint inside of the fuel tank was chipping and contaminating the fuel system. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and current mileage was unknown.

Filed Jun 6, 2011 · Fuel system · 290,000 miles · TX

I have a 2001 ford f550 super duty flatbed towtruck, the trucks design is a combination from ford and international, which due to the faulty fuel tank delaminating and causing a financial lose of not only a days work, but also the need of having a two vehicles which while in tow stop traffic when all of a sudden the truck looses power and service engine soon light turns on. Cost over 1000.00 just in wrecker bills, and not to mention trashed the injectors, pump, and filter system and all the lines. Ford or international will not take any responsibility for a bad fuel tank recall. Truck is still down and seems that I will probably have to replace all parts mentioned at my cost.

Filed May 13, 2011 · Fuel system · NJ

We have 3 ford f550's that have gas tank leaks.

Filed May 13, 2011 · Fuel system · NJ

We own a landscape business in south jersey. We have 3 ford f550's and all 3 have leaks in their gas tanks. Im filing a complaint for each one. We would like this investigated, its a major safety hazard. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed May 13, 2011 · Fuel system · NJ

We own a landscape const business and we have 3 ford f550's and all 3 have leaks in the gas tanks. This is a very large safety hazard and we would like this addressed. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Apr 14, 2011 · Fuel system · 130,000 miles · NC

Tl* the contact owns a ford f550. While driving approximately 70 MPH the vehicle stalled without warning and was towed to an independent mechanic. The mechanic advised that the fuel tank would need to replace but the vehicle was not repaired. The contact stated that the part was not available because there was a high demand for the fuel tank. The approximate failure mileage was 130,000.

Filed Aug 23, 2010 · Fuel system · 80,182 miles · VA

June 21, 2007at shop for state inspection also engine missing. Replace fuel filter during regular service due to missing engine. June 17, 2008 - vehicle missing and stalling, diagnostics done , replaced wire assembly and gasket valve cover, cleaned motor sept. 23, 2008- missing in engine and stalling, diagnostics done, replaced camshaft sensors and carb cleaner added sept. 25, 2008 - missing and stalled would not start towed to shop. Diagnostics done, drained fuel tank discovered peeling and slivers, replaced fuel pump, gaskets and wire assembly, fuel injectors and replaced fuel tank.