2007 Ford F-550 SD technical service bulletins
45 technical service bulletins and manufacturer communications cover the 2007 Ford F-550 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- These SKUs are Trailer Brake Control Modules
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- This SKU is a Spare Tire Hoist
- Concern during or after programing the VSM. The programming may fail or vehicle symptoms such as...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit...
- Exterior Mirror
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will...
- Ford: 6.0L diesel hard start/long crank/no start du to low injector control pressure (ICP)
- 2005-08 F250-550 super duty manual transmission - clutch pedal concern
- 6.0L turbocharger carbon deposit diagnostics and service tips
- Water in the fuel tank behind rear axle - 6.0L, 6.4L and 7.3L diesel engine
- 1999-2008 F250-F550 super duty 4X4 with electronic shift transfer case not engaging 4X4
- 2005-2008 f-super duty manual transmission- clutch pedal concern
- 6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK of power or surge with some 2003-2007 f-super duty,...
- Stuck or jumping/bouncing/erratic speedometer and/or tachometer
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- Buck/jerk when pulling large heavy gooseneck trailers
- Rear of vehicle is too high/low -5TH wheel and goose neck applications
- 6.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct
- Customer satisfaction program
- ABS light on and possible C1175, C1236, P0500,P0503
- Adding additional bulbs to turn indicator or hazard flasher circuits
- Power steering pump pulley alignment
- Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start
- 6.0L oil seep or boost pressure leak at hot side charge air cooler duct
- Lack of power due to low fuel pressure - fuel tank liner seperation
- High pressure system diagnostics - 6.0L engines
- 6.0L turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke,...
- Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after...
- 6.0L - MIL on with DTC P2138, P2139, and P2140
- Lack of cooling fan operation
- 6.0L - reduced engine performance - high altitude
- Air filter water ingestion / snow packing with codes P0103
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Lack of power or lack of performance condition when operated above 5,000 feet of altitude
- Misfire and DTC P0300
- Watch for oil flow from the base engine oil pump
- Oil flow from the base engine oil pump
- Runs rough or misfire due to a stuck valve
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Ford F-550 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history