2008 Ford F-550 SD technical service bulletins
86 technical service bulletins and manufacturer communications cover the 2008 Ford F-550 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless...
- All accessory stick-on keyless entry keypads come with a wallet card containing the master code
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- Concern during or after programing the VSM. The programming may fail or vehicle symptoms such as...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with...
- Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit...
- Exterior Mirror
- Ford: after rocker pedestal replacement, some diesel trucks are experiencing knocking engine, rough runs,...
- Ford: diesel engine runs rough, engine knocking, hard start, crank but no start due to height of improper...
- Ford: due to restrictions from cooling system contamination, diesel engine oil coolers primarily are being...
- Ford: there are exhaust leaks, caused by warped exhaust manifold, experience by diesel engine
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: when turning, there is a popping or clunking noise that is heard or felt, under floor pan, in some...
- Ford: some trucks, equipped with 6.4L diesel engine will lack power with diagnostic trouble codes (DTCS)...
- Ford: some trucks may exhibit a situation with diesel engine such as engine knocking, low power, exhaust...
- Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code during...
- Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code at full...
- Ford service campaign: there are multiple problems with the vehicle
- Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will...
- Ford: the malfunction light may be on with a lack of power
- Ford: some trucks with 6.4L engine will run rough, smokes, or no start due to gasoline or alcohol in the fuel
- Ford: supply/return lines installation at high pressure pump-revised washer for trucks equipped with 6.4L...
- Ford service campaign: some vehicles equipped with a 6.4L diesel engine may require a calibration update...
- Ford: some vehicles equipped with a 6.4L diesel engine and built between 8/3/07 and 1/2/08 may require a...
- Ford: some vehicles equipped with a 6.4L diesel engines and built prior to 8/2/07 may require a...
- Ford service campaign: certain 2008 model year f super duty vehicles equipped with a 6.4L diesel engine...
- Ford service campaign: vehicles fuel injector o rings CAN prematurely wear
- Ford: 6.4L diesel engine
- Ford super duty: demonstration/delivery hold S008 f super duty vehicles; 6/4L diesel engine cooling system...
- 2005-08 F250-550 super duty manual transmission - clutch pedal concern
- 6.4L air induction system restriction--snow--built before 9/18/2007
- 2008 f-super duty 6.4L - P040D DTC with a lack of power or lack of boost
- Ford sd trucks; this non MIL DTC will be stored in the powertrain control module (PCM) when the engine oil...
- Jerr-dan: revised carrier mud flap installation on 2008 ford F550 and dodge ram 4500/5000 chassis cabs.
- 2008 e-series and f-series super duty - steering gear leak
- 2008 f-series super duty diesels exhibiting DTC P0528 due to snow plow installation on vehicles without...
- 2008 f-super duty 6.4L diesel - MIL, P006B, P2563, P2263 with or without a drivability complaint
- 2008 f-super duty 6.4L diesel - vref codes P1335, P0193, P0642, P0643, or P0652
- Water in the fuel tank behind rear axle - 6.0L, 6.4L and 7.3L diesel engine
- The 2008 f-super duty vehicle is equipped w/ a smart junction box (SJB) or generic electronic module (GEM)...
- Hpl series wrecker applications
- 1999-2008 F250-F550 super duty 4X4 with electronic shift transfer case not engaging 4X4
- Helix angle and tooth pressure angle count and look the same
- 2008 f-super duty - 6.4L air induction snow restriction
- 2005-2008 f-super duty manual transmission- clutch pedal concern
- Some 2008 f-super duty - 6.4L diesel EGR valve and DPF failures due to high sulfur diesel fuel
- Some 2008 f-super duty vehicles built before 5/10/07 and equipped with a 5.4L or 6.8L engine and single...
- Ford: dual rear wheel (DRW) side marker lamps loose
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- Diesel exhaust modification on 2008 ford super duty f-series for mpl series wreckers
- Blizzard snowplows - on 2008 ford super duty trucks (snowplow headlamp switch operation w/snowplow...
- (Wiring fault on trailer) displayed in message center with DTC C2806
- Installation location for all 2008 ford super duty trucks (isolation module)
- Isolation module - installation location for all 2008 ford super duty trucks
- Rear of vehicle is too high/low -5TH wheel and goose neck applications
- Exhaust smoke from front of vehicle
- Some 2008 f-super duty - gas engines/torqshift with water in the transmission
- Some 2008 f-super duty - wiring fault on trailer displayed in message center with DTC C2806
- Lighting on snow plow equipped vehicles
- 6.4L-PCM update- built before 7/-30/2007- intermitten P0342 and/or P1326, update-pto function, turbo...
- In some of the affected vehicles, three fuel injectors were subjected to a reverse polarity voltage during...
- Air induction snow restriction
- Injector circuit open- dtc(s) P0201-P0208 with a misfire/rough running/lack of power condition
- 2008 f-super duty - soft or increased brake pedal travel - perform both master cylinder bypass test and...
- 2008 f-super duty - 6.4L diesel engine - the fuel cooling pump noise
- Uvc 15-WAY connections that are secured by an o-ring
- Dana S110 rear - axle fluid leak
- Wiring fault on trailer displayed in message center with DTC C2806
- Distance to empty (DTE) and fuel gauge service tip
- Mpl series wrecker application
- Rapid flashing turn lights
- After market fuel tanks
- Standard duty carrier applications
- Stop/turn lamp separation
- Power folding mirror
- Wiring fault on trailer, displayed in message center with DTC C2806
- Lack of power due to low fuel pressure - fuel tank liner seperation
- Wiring fault on trailer displayed in message center with DTC C2806
- Malfunction indicator lamp on with code P132B
- Air filter water ingestion / snow packing with codes P0103
- Injector circuit open codes P0201, P0202, P0203, P0204, P0205, P0206, P0207, P0208 with a misfire / rough...
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Ids unable to communicate with the PCM
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Ford F-550 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history