2006 Ford F-650 SD technical service bulletins
63 technical service bulletins and manufacturer communications cover the 2006 Ford F-650 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit...
- Loose mounting bracket due to poor rivet retention.
- Exterior mirror
- Exterior Mirror
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21,...
- Ford: 6.0L diesel hard start/long crank/no start du to low injector control pressure (ICP)
- 6.0L turbocharger carbon deposit diagnostics and service tips
- 2004-2006 F-650/F-750 and 2006 lcf - fuel tanks
- Some 2005-2007 F-650 and F-750 vehicles equipped w/ a 6.0L diesel engine may exhibit a hard start/long...
- Dual fuel tank
- 2005-2008 f-super duty manual transmission- clutch pedal concern
- Some 2004-2008 f-super duty 650-750 vehicles equipped with air suspension may exhibit a condition where...
- 6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK of power or surge with some 2003-2007 f-super duty,...
- Stuck or jumping/bouncing/erratic speedometer and/or tachometer
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- Buck/jerk when pulling large heavy gooseneck trailers
- Rear of vehicle is too high/low -5TH wheel and goose neck applications
- 6.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct
- White smoke, lacks power, exhaust odor, surges, runs rough, or no start
- ABS light on and possible C1175, C1236, P0500,P0503
- No start, no ECM/TCM communications and/or flashing automatic transmission indicator
- Right fuel tank empty - fuel does not transfer from left tank
- Adding additional bulbs to turn indicator or hazard flasher circuits
- Power steering pump pulley alignment
- Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start
- 6.0L oil seep or boost pressure leak at hot side charge air cooler duct
- Fuel tanks put into some vehicles were made out of steel
- Lack of power due to low fuel pressure - fuel tank liner seperation
- Vehicle diagnostics and programming using IDS-6.0L engine and low cab forward with 4.5L engine
- Check engine and/or stop engine light on - cummins engine only
- Steering wheel oscillation
- High pressure system diagnostics - 6.0L engines
- 6.0L turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke,...
- Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after...
- 6.0L - MIL on with DTC P2138, P2139, and P2140
- Lack of cooling fan operation
- Check engine light on, and/or stop engine light on
- Service calibration update - loss of RPM on deceleration - 6.8L
- 6.0L - reduced engine performance - high altitude
- Air filter water ingestion / snow packing with codes P0103
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Diagnostic trouble codes (DTC) P0340, P0344, P0345, P0349
- Buck/jerk steady throttle or slight tip in 6.0L
- Lack of power or lack of performance condition when operated above 5,000 feet of altitude
- Headlight adjustment needed
- Misfire and DTC P0300
- Turn signals flashing rapidly after modification
- Watch for oil flow from the base engine oil pump
- Oil flow from the base engine oil pump
- Runs rough or misfire due to a stuck valve
- Incorrect fuse value on instrument panel fuse #11 and fuse #20 in the owner guide
- Fuel conditioner
- Part changes on vehicles built after january, 2006
- Vehicle diagnostics and programming using wds - F-650/750 with 6.0L engine and low cab forward with 4.5L...
- Malfunction indicator lamp, diagnostic trouble codes P0172, P0175, P2106, hesitation, surge, harsh drive...
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode
- Headlight adjustment - chassis cab incomplete vehicles
- Safety belt retraction speed
- Service wiring harness replacement guidelines - service tips
- Misfire lack of power buck jerk excessive smoke crank no start 6.0L engine diagnostics for fuel system
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Ford F-650 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history