1994 Ford F Super Duty technical service bulletins
113 technical service bulletins and manufacturer communications cover the 1994 Ford F Super Duty.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Loss of power and malfunction indicator lamp may also illuminate with diagnostic trouble codes 128 and 845...
- Hesitation, stumble, lack of power, rough idle and poor performance on vehicles with 7.3L di turbo diesel...
- A no-start or reduced power condition may occur intermittently
- Poor idle quality and/or low output after the engine returns to idle speed
- Hard starting after the fuel injectors have been replaced
- A lack of accelerator control when moving off of the idle position
- Rear of engine oil pan, near the crankshaft, may leak oil
- The water-in-fuel lamp may stay on and the fuel may be slow to drain or not drain at all when the fuel...
- Hard or no start, hesitation, idle rough, low power, misses, stalls
- No start/hard start and/or long crank time for vehicles with 7.3L di turbo diesel
- A high number of high pressure rexroth pumps and injection pressure regulators (IPR) are being replaced...
- Low RPM, no start, runs poorly, stall
- Lack of power and/or low performance condition caused by no return fuel flow to the fuel tank
- External oil leak diagnosis for 7.3L dit engines
- New transmission cooler flusher - service tips
- Exhaust air rush noise and lower power
- Brake shift interlock
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Transmission- E40D/4R100-1989-99-MAIN controls, separator plates and separator plate gaskets usage chart
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may...
- Information regarding the new transmission cooler flusher- service tip
- Subject regarding 4R100 transmission flexplate replacement for vehicles with 7.3L diesel engine
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Information on the new flush and fill tool available through rotunda
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Information regarding reprogramming powertrain control modules (PCMS)
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Mass air flow (maf)- sensor contamination- service tip
- Some vehicles with a 7.3L direct injection (DI) turbo diesel engine, one or more of the following concerns...
- Service procedures and vehicle attitude service kits have been developed to assist customers and vehicle...
- Steering wheel alignment- vehicles with motorhome chassis.
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
- Repeat message, no change- rough idle/miss
- Repeat message, no change: hard start/ no start
- Lack of power due to failure of engine turbo boost
- Vehicle stalls upon acceleration
- Exhaust leak at exhaust manifolds--vehicle equipped with 7.0L 0R 7.5L engine
- Information on vehicles exhibiting rough idle / miss
- Brief information vehicles exhibiting hard start / no start condition
- Brief information on vehicles exhibiting lack of power condition
- Brief information on vehicles exhibiting a stall on deceleration condition
- Brief information concern vehicles exhbiting external oil leaks
- Rear brake drag or excessive wear on rear brakes
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio
- Information on a buzzing or rattle noise from the exhaust system
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Service tip information regarding elimination of sanding rotors and drums
- Recommended guidelines for towing behind recreational vehicles
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable
- Experiencing excessive brake pedal travel accompanied by reduced braking effectiveness when the vehicle is...
- Availability of hub-mount brake rotor machining equipment
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Some vehicles may exhibit a flashing transmission control indicator lamp (TCIL) and diagnostic trouble...
- Part number information for the use of a child seat tether
- When the air cleaner is being replaced, the drain mechanism on the bottom of the air cleaner case is to be...
- Headlamp- headlamp housing melts- ambulance and emergency vehicles only
- Fuel economy- customer expectations versus vehicle usage
- Brakes- excessive brake pedal travel- f super duty motorhome chassis vehicles built through 11/2/94
- Steering- high effort during highway driving- f super duty motorhome chassis vehicles built from 7/1/93...
- Low RPM- 7.3L dit engine fails to start- code 340 stored in memory and/or engine fails to achieve rated...
- Fuel pump- availability of new style fuel pump and sender- f super duty motorhome chassis- service tip
- Fluid- transmission fluid usage charts
- Diesel exhaust smell in passenger cabin may be due to poor connection at the inlet or outlet to/from the turbo
- Frame- rivet replacement with bolts- service tips
- Exhaust leaks or noise at the joint between the y-pipe and the exhaust manifold
- Noise- "popping/creaking"- front frame or suspension brackets- frame- "popping/creaking"- fastener replacement
- Diagnostic guides for out-of-warranty vehicles to be used as a master copy - diagnostic guides no longer...
- Leak - oil leakat engine valley pan and/or high pressure oil pump - vehicles equipped with 7.3L diesel engine
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning...
- Torque converter - leak test procedure - service tip
- Suspension - front or rear - side-toside leveling procedures and attitude service kits for F53 rv basic...
- Windshield and interior glass - fog/film
- Brakes - elimination of sanding rotors and drums - service tip
- Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0L or 7.5L engine
- Experiencing front end shimmy occurring at various driving speeds and is usually induced when hitting...
- Service tip information regarding the reverse clutch piston and piston seal usage
- During highway deceleration or engine start-up, there may be a hooting noise coming from the engine...
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because...
- Air conditioning-lack of cooling at idle-a/c system shuts off due to high system PRESSURES-7.3L di turbo...
- Generator-motorcraft 95AMP-FRONT bearing CONCERN-FD1060/1460 engines- vehicles built before 7/3/95
- Engine- 'knocking' noise - when operating engine at 200-2300 RPM - FD1460 engine
- Leaks - oil - front cover or gear housing vehicles with FD1460 engine
- Revised design transmission rear case bushing
- Delayed forward engagement and/or heat stained forward clutch plates after installing center support service
- Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before...
- Unknown
- Vehicles may exhibit a poor idle quality and/or low output after the engine returns to idle speed
- Vehicles may be hard to start after the fuel injectors have been replaced
- Lack of accelerator control when moving off the idle position
- Hydromounted cab - evaporative emission lines rubbing on the fender
- The front bumper mounting torque specification has been revised for better overall bumper retention and...
- Vehicles with 7.3L direct injection diesel engines may experience one or more of the following conditions:...
- Some vehicles may exhibit a poor idle quality and/or low output after the engine returns to the idle speed
- Improper oil dipstick causes driveability concerns
- There may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock...
- A no start or reduced power condition may occur intermittently on some vehicles
- New design transmission range sensor
- Low performance/lack of power
- Clutch does not disengage
- Front window scraping noise when rolling glass down
- Hooting noise from the engine compartment
- Loss of power due to incorrect map sensor installed
- Transmission overheating, converter cover discoloration, clutches burned and burnt fluid tw
- Upgrade kit for the E40D transmission
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Ford F Super Duty?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history