1999 Ford F Super Duty technical service bulletins
107 technical service bulletins and manufacturer communications cover the 1999 Ford F Super Duty.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford/lincoln/mercury: program of affected vehicles registered in ca (8500 gvwr), ma (6000 gvwr), or vt...
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Fuel conditioner
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Use of stainless steel exhaust studs in service for 5.4L 2V engine
- Intermittent rough idle - non-commanded EGR (exhaust gas recirculation valve) flow
- A driveline clunk or bump when starting from a stop
- Water leak - roof flange area - water accumulation in headliner and/or leak at the cab floor pan area
- Some 7.3L diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (EBP)
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
- Vacum pump inoperative or runs continuosly - climate control default to defrost
- Adding additional bulbs to turn indicator or hazard flasher circuits - service tips
- Engine buck, surge or jerk (also known as hitching/hesitation) while the speed control is active through...
- Malfunction indicator lamp illuminated with diagnostic trouble codes (DTCS) P0442, P0455, P0456, P0457 or...
- Leak oil around the exhaust backpressure actuator (EBP) - 7.3L diesel turbocharger pedestals
- Brake pull
- Remote keyless entry (RKE) - service tips
- Clear gel-like substance in the hydraulic brake master cylinder reservoir
- Coolant leak due to broken radiator hose clamp
- Tailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads
- Exhaust air rush noise and lower power
- Coolant leak due to a broken lower radiator hose clamp
- Some vehicles may exhibit interference and / or static in the land-mobile radio
- Some vehicles may exhibit an anti-lock brake system (ABS) light on, B2141/B2477, and/or an inaccurate...
- Some 4X4S may exhibit noise, vibration and ratcheting from the front wheel locking hubs that is initiated...
- Special field action on certain trucks equipped with 19.5-INCH commercial truck tires with steel cord...
- Information regarding electronic crash sensor /restraint control module replacement
- Some vehicles equipped with a 4.6L, 5.4L, or 6.8L engine may exhibit a rough idle / miss after start-up in...
- Some vehicles equipped with 7.3L dit engine may exhibit an engine that runs rough, misses, buck / jerk,...
- Some 4X4 vehicles may exhibit a squeak from the front leaf spring area
- Some vehicles equipped with 7.3L diesel engine may exhibit a pilot bearing issue resulting in the service...
- Some vehicles may exhibit a buck or jerk (also known as hitching) during highway driving at speeds 40 mph...
- Exhibiting a squeak from the front leaf spring area, caused by front spring tip isolator wear
- Information used when replacing the electronic crash sensor / restraint control module
- Information on 7.3L dit vehicles exhibiting an intermittent engine knock which may be perceived as a rod knock
- For vehicles that require configuration of the electronic crash sensor moudle to settings other than the...
- Exhibiting a pop or creaking noise under the cab of the vehicle on some trucks
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Some super duty f series 250 - 550 vehicles may exhibit tubocharger noise, exhaust noise, or oil / soot...
- Some vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on removing and / or replacing the generic electronic module (GEM)
- Experiencing a squeak type noise heard from the front springs as they compress during driving on some vehicles
- Some vehicles may exhibit a no 3-4 upshift, or a 3-4 / 4-3 shift hunt only while the cruise control is in use
- Some vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer...
- Some vehicles may exhibit condensation leaks on the passenger floor coming from the floor duct or heater...
- Information on vehicles built from 2/22/99 through 7/3/99 equipped with dual rear wheels (DRW) exhibiting...
- Information on replacing and removing the generic electronic module (GEM)
- Information on all vehicles built after 5/19/99 equipped with the 7.3L dit with a engine serial # greater...
- Some vehicles built from job 1 to 5/5/1999 may exhibit a squeaking noise emanating from the front springs
- Some trucks may exhibit a squeal type noise from the front axle area
- Subject regarding a pull condition under hard braking
- Subject regarding torquing of trackbar when performing alignment.
- Information regarding floorpan vibration during part-throttle acceleration
- Awareness message regarding new diesel injector
- Conditions with normally occuring intermittent transfer case bindup
- Information on windshield repairs
- Information regarding reprogramming powertrain control modules (PCMS)
- Concerns with transmission fluid leaking at radiator
- Some vehicles equipped with a dual media (AM / FM / cassette / cd) or AM / FM cassette radio may exhibit...
- Information on adjusting trailer tow mirrors
- Complaints that trailer tow mirrors hard to adjust in one or more directions
- Subject regarding upper radiator hose production change
- A low clutch pedal engagement and / or hard shifting after operating several miles may occur on some vehicles
- Some vehicles with 4R100 transmission may exhibit a flashing tcil with diagnostic trouble code (DTC) 1728...
- Some vehicles equipped with 7.3L engine and 4R100 transmission may exhibit a shift flare (increase in RPM...
- Brief information on vehicles exhibiting loss of power
- Subject regarding vehicles with 7.3L di and 4R100 transmission experiencing a grinding / scraping noise...
- Subject regarding hard start or no start condition
- Subject regarding the cupholder on some vehicles which may not fully retract into the cupholder instrument...
- Some vehicles equipped with 7.3L / M60D transmission may exhibit a low / soft clutch pedal condition
- This bulletin states that replacement under warranty of certain specified components on any 7.3L dit...
- Some vehicles with 7.3L engine and 4R100 transmission may exhibit an increase in engine RPM of 200 - 300...
- Some vehicles equipped with 7.3L / M6OD transmission may exhibit a low / soft clutch pedal condition
- Subject regarding engine diagnostic guide for warranty reimbursement
- Some vehicles with 7.3L / 4R100 transmission may exhibit an increase in engine RPM of 200 - 300 RPM...
- Some vehicles equipped with 7.3L / M60D may exhibit a low clutch concern
- Some trucks with 7.3L / M60D may exhibit gear rattle / rollover type noise from the transmission during...
- Service procedures and vehicle attitude service kits have been developed to assist customers and vehicle...
- Some vehicles equipped with 4R100 transmission may exhibit a flashing tcil with diagnostic trouble code...
- Subject regarding loss of power
- Some vehicles equipped with 4R100 transmission may exhibit a flashing tcil with diagnostic trouble code...
- Cold start engine noise
- Some trucks witj 4R100 transmissions may exhibit a concern of fuse #19 blown, overdrive cancel light...
- Repeat message revised will have to reconfigure gem with service card if vehicle equipped with manual...
- Low clutch pedal engagement 7.3L dit
- Rough idle
- Technical assistance for speedometer accuracy concerning 19999 f super duty trucks is available through...
- Subject regarding additional verbage to the service manual to the overhead trip computer section
- Some vehicles may exhibit hard shifting and low clutch pedal engagement (less than 1/2 in from floor)
- Some trucks equipped with the 7.3L dit may exhibit a lack of power, poor fuel economy, malfunction...
- Subject regarding new dual fuel filter element
- On some vehicles, the rubber stop bumper may be missing from the parking brake control, a replacement...
- Some vehicles equipped with the 7.3L dit may exhibit a lack of power, poor fuel economy, malfunction...
- New dual fuel filter element released for production on april 13 for trucks with 7.3L dit
- Subject regarding a missing rubber stop bumper from the parking brake cotnrol
- Some trucks equipped with the 7.3L dit engine may exhibit a lack of power and / or a whistle noise coming...
- Procedures for trailer tow mirror glass replacement
- Significant changes have been made to the 7.3L dit engine effective with the 1998 and 1999 model years
- Vehicles may exhibit an air bag light on and possible codes 1933 and / or 1935
- Conditions with the adapter tool # 014-00931-2 is installed on the fuel pump inlet as described, damage to...
- Some vehicles equipped with 5.4L or 6.8L engines may display a lack of power on acceleration
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Repairs to vinyl covered surfaces
- Service tips for surface defect removal without repainting
- Service procedure for orange service tagged transmissions
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Ford F Super Duty?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history