2000 Ford F Super Duty technical service bulletins

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

• Oct 13, 2008 Service bulletinFord/lincoln/mercury: program of affected vehicles registered in ca (8500 gvwr), ma (6000 gvwr), or vt...
• Oct 1, 2007 Service bulletinSome 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
• Jan 1, 2006 Service bulletinFuel conditioner
• Nov 14, 2005 Service bulletinWds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
• Mar 21, 2005 Service bulletinUse of stainless steel exhaust studs in service for 5.4L 2V engine
• Mar 7, 2005 Service bulletinIntermittent rough idle - non-commanded EGR (exhaust gas recirculation valve) flow
• Jan 1, 2005 Service bulletinA driveline clunk or bump when starting from a stop
• Nov 29, 2004 Service bulletinWater leak - roof flange area - water accumulation in headliner and/or leak at the cab floor pan area
• Oct 18, 2004 Service bulletinSome 7.3L diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (EBP)
• Sep 6, 2004 Service bulletinMalfunction indicator lamp (MIL) illuminated - system lean diagnostic trouble codes (dtc's) - service tips
• Aug 23, 2004 Service bulletinEngine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
• Aug 23, 2004 Service bulletinVacum pump inoperative or runs continuosly - climate control default to defrost
• Jan 1, 2004 Service bulletinAdding additional bulbs to turn indicator or hazard flasher circuits - service tips
• Oct 30, 2003 Service bulletinEngine buck, surge or jerk (also known as hitching/hesitation) while the speed control is active through...
• Oct 13, 2003 Service bulletinMalfunction indicator lamp illuminated with diagnostic trouble codes (DTCS) P0442, P0455, P0456, P0457 or...
• Sep 29, 2003 Service bulletinLeak oil around the exhaust backpressure actuator (EBP) - 7.3L diesel turbocharger pedestals
• Sep 29, 2003 Service bulletinBrake pull
• Sep 15, 2003 Service bulletinRemote keyless entry (RKE) - service tips
• Jun 1, 2003 Service bulletinClear gel-like substance in the hydraulic brake master cylinder reservoir
• Jun 1, 2003 Service bulletinCoolant leak due to broken radiator hose clamp
• May 1, 2003 Service bulletinTailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads
• Mar 1, 2003 Service bulletinExhaust air rush noise and lower power
• Feb 1, 2003 Service bulletinCoolant leak due to a broken lower radiator hose clamp
• May 1, 2002 Service bulletinSome vehicles may exhibit interference and / or static in the land-mobile radio
• May 1, 2002 Service bulletinSome 5.4L windsor power improved engines may exhibit a slight oil leak or weep at the cylinder head to...
• Jan 1, 2002 Service bulletinSome vehicles may exhibit an anti-lock brake system (ABS) light on, B2141/B2477, and/or an inaccurate...
• May 1, 2001 Service bulletinSome 4X4S may exhibit noise, vibration and ratcheting from the front wheel locking hubs that is initiated...
• Mar 1, 2001 Service bulletinSpecial field action on certain trucks equipped with 19.5-INCH commercial truck tires with steel cord...
• Jan 22, 2001 Service bulletinSome vehicles equipped with 5.4L or 6.8L engine built through 9/10/2000 may exhibit a miss sound from the...
• Jan 22, 2001 Service bulletinSome vehicles may produce a malfunction indicator lamp illuminated, rough idle, a check engine light, and...
• Jan 1, 2001 Service bulletinInformation regarding electronic crash sensor /restraint control module replacement
• Dec 25, 2000 Service bulletinSome vehicles equipped with a 4.6L, 5.4L, or 6.8L engine may exhibit a rough idle / miss after start-up in...
• Sep 1, 2000 Service bulletinConcerns with a turbo hoot condition
• Jan 1, 2000 Service bulletinSome 4X4 vehicles may exhibit a squeak from the front leaf spring area
• Jan 1, 2000 Service bulletinSome vehicles equipped with 7.3L diesel engine may exhibit a pilot bearing issue resulting in the service...
• Jan 1, 2000 Service bulletinSome vehicles may exhibit a buck or jerk (also known as hitching) during highway driving at speeds 40 mph...
• Jan 1, 2000 Service bulletinExhibiting a squeak from the front leaf spring area, caused by front spring tip isolator wear
• Jan 1, 2000 Service bulletinInformation used when replacing the electronic crash sensor / restraint control module
• Dec 6, 1999 Service bulletinInformation on 7.3L dit vehicles exhibiting an intermittent engine knock which may be perceived as a rod knock
• Nov 1, 1999 Service bulletinFor vehicles that require configuration of the electronic crash sensor moudle to settings other than the...
• Nov 1, 1999 Service bulletinExhibiting a pop or creaking noise under the cab of the vehicle on some trucks
• Oct 18, 1999 Service bulletinService procedure for orange service tagged 4T100 transmissions
• Oct 18, 1999 Service bulletinSubject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
• Oct 1, 1999 Service bulletinSome vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
• Sep 20, 1999 Service bulletinInformation for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
• Sep 1, 1999 Service bulletinInformation on removing and / or replacing the generic electronic module (GEM)
• Aug 1, 1999 Service bulletinSome vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer...
• Aug 1, 1999 Service bulletinConcerns with vehicles exhibiting a flicker in the dash lamp when switching from the headlamp to the park...
• Aug 1, 1999 Service bulletinInformation on replacing and removing the generic electronic module (GEM)
• Aug 1, 1999 Service bulletinInformation on all vehicles built after 5/19/99 equipped with the 7.3L dit with a engine serial # greater...